2015 Ford Transit Connect Owner Complaints

ALL INTERIOR DISPLAYS AND GAUGES GO BLANK WHILE STILL PARKED OR DRIVING AT ANY SPEED INCLUDING HIGHWAY SPEEDS, TURN SIGNALS AND HAZARD LIGHTS FAIL TO ACTIVATE. MULTIPLE OCCASIONS OVER LAST 4 MONTHS, INCREASING IN FREQUENCY. OCCURRED MULTIPLE TIMES DURING 4 HOUR TRIP ON 07/17/2017. SYSTEM MAY OR MAY NOT RECOVER, ONLY TO GO BLANK AGAIN SHORTLY AFTER. SOMETIMES WHEN RAIN SENSING WIPERS ACTIVATE. SOMETIMES "HILL ASSIST INACTIVE" AND TRACTION CONTROL DISABLED MESSAGES ON SYSTEM RECOVERY.

7/18/2017

THE VEHICLE WAS SITTING PARKED CURBSIDE WHILE OUR DAUGHTER WAS IN SCHOOL AND ON A BREAK, I WENT TO MOVE THE CAR CLOSER AND WHEN I SHUT THE DRIVER'S DOOR, THE BACK GLASS SHATTERED AND FELL TO THE STREET.

10/18/2017

TL* THE CONTACT OWNS A 2015 FORD TRANSIT CONNECT. WHILE DRIVING 2 MPH, THE REAR PASSENGER DOOR SWUNG OPEN. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 16V643000 (LATCHES/LOCKS/LINKAGES). IN ADDITION, NONE OF THE DOORS WOULD OPEN OR CLOSE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 8,000.

10/17/2016

TL* THE CONTACT OWNS A 2015 FORD TRANSIT CONNECT. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V643000 (LATCHES/LOCKS/LINKAGES); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

10/27/2016

A DOOR LATCH WITH A FRACTURED PAWL SPRING TAB TYPICALLY RESULTS IN A "DOOR WILL NOT CLOSE" CONDITION. A DOOR THAT OPENS WHILE DRIVING INCREASES THE RISK OF INJURY. *TR

12/1/2016

FORD RECALL #16S30 WAS ORIGINALLY ISSUED IN JANUARY OF 2017. ELEVEN MONTHS LATER MY LOCAL DEALER STILL DOES NOT HAVE PARTS TO FIX THIS PROBLEM. I HAVE TRIED CONTACTING THEM AT SEVERAL DIFFERENT POINTS, AND I GET NOWHERE. WHY IS FORD NOT MAKING THESE PARTS AVAILABLE TO DEALERS? MY DOOR LATCH IS NOW INOPERABLE ON ONE SIDE.

11/28/2017

THE VEHICLE ROLLED WHEN THE SHIFT LEVER WAS PLACED INTO PARK POSITION. THE DRIVER HAD PARKED THE VEHICLE. THE SHIFT LEVER BUSHING HAD BECOME DETACHED FROM THE SHIFT LEVER ON THE TRANSMISSION. THIS IS THE SAME PROBLEM THAT HAS BEEN THE SUBJECT OF A RECALL FOR FORD FUSION AND FORD ESCAPE VEHICLES. THIS ALSO HAPPENED ON ANOTHER OF OUR 2015 FORD TRANSIT CONNECT VEHICLES.

9/17/2018

THE TRANSMISSION SHIFT LINKAGE SEPARATED FROM THE HOUSING DUE TO A BUSHING FAILURE. IT SHOWED IN PARK, BUT THE CAR ROLLED AND THE EMERGENCY BRAKE WAS REQUIRED. THE CAR WAS PARKED IN THE DRIVEWAY AT THE TIME.

10/15/2018

THE CHECK ENGINE LIGHT CAME ON AT ABOUT 81,000 MILES, AND A WEIRD NOISE STARTED HAPPENING COMING FROM THE ENGINE AREA. I GOT INTO THE DEALER SERVICE DEPARTMENT (DEALER WHERE I BOUGHT THE CAR) AT ABOUT 81,500 MILES. THEY DIAGNOSED A BAD CATALYTIC CONVERTER - IT WAS BREAKING UP. SEVERAL ISSUES AROSE FROM THAT: FIRST, I HAVE BEEN SMELLING CARBON MONOXIDE IN THE CAB FOR QUITE A WHILE AND DID NOT KNOW WHY (NOW I THINK I KNOW - CLOGGED CATALYTIC, REVERSION THROUGH THE ENGINE BAY). SECOND THE CATALYTIC WARRANTY EXPIRES AT 80,000 MILES. (THE LIGHT WENT ON AT 81,000). THIRD, AT THE TIME OF PURCHASE, THE DEALER FINANCE GUY FORCED ME TO BUY AN EXTENDED WARRANTY. HE SAID THAT FORD WOULD NOT FINANCE ME IF I DID NOT BUY IT SO I AGREED. IT WAS OVER $2000 TAKEN OUT OF MY DOWN PAYMENT. I FULLY EXPECTED THE EXTENDED WARRANTY TO COVER THE BROKEN CAT - WRONG - CATS ARE NOT COVERED. THE REPAIR WAS QUOTED AT ABOUT $1000. MY BEEF HERE IS SEVERAL FOLD: THE 1) FORD WARRANTY EXPIRES AT 80,000 AND THE ENGINE LIGHT COMES ON AT 81,000 EVEN THOUGH THE CONVERTER HAD BEEN GOING BAD THE WHOLE TIME. 2) I HAVE BEEN BREATHING CO2 IN THE PASSENGER COMPARTMENT. 3) THE EXTENDED WARRANTY WAS USELESS AND I PAID A HEFTY SUM FOR IT. THE REPAIR IS QUITE EXPENSIVE AND THE PROBLEM IS NOT COVERED BY ANY OF THE WARRANTIES I HAVE, WHICH I THINK IS UNFAIR. I HAVE NOT BROUGHT THIS COMPLAINT TO THE DEALER TO ALLOW THEM A REBUTTAL - I SIMPLY LEFT IN SHOCK THAT I AM ON THE HOOK, AND NOW I'M BREATHING THE STINK OF A DECOMPOSING CAT IF I DON'T USE RECIRCULATE (AND A SLIGHT AMOUNT EVEN IF I DO USE RECIRCULATE, WHICH IS ANOTHER COMPLAINT - RECIRCULATE STILL LETS IN OUTSIDE AIR. IN TRAFFIC, YOU ARE ALWAYS BREATHING EXHAUST).

2/11/2018

UNDER NORMAL DRIVING THE VEHICLE GOT REAL HOT ,AND OVER HEATED. THE WATER AND OIL LEVELS WHERE AT THE PROPER LEVELS. THE ENGINE HEAD CRACKED OR BLEW THE HEAD GASKET . TOWED TO FORD THEY HAD TO REPLACE THE ENGINE. THIS HAPPENED ON THE HIGHWAY, GOING HOME. THE NEXT DAY THE VEHICLE WOULD NOT START. THERE IS A SAFETY RECALL # 17S09, OUT ON THESE VEHICLES, BUT MY VIN # WAS NOT ON THE LIST. YET LM HAVE THE SAME ISSUE. LUCKILY WE CAUGHT IT BEFORE IT GOT HOT ENOUGH TO CATCH ON FIRE.

8/29/2018

WE'VE ONLY HAD THIS VEHICLE FOR 6 MONTHS AND HAVE HAD TIRE REPLACEMENTS, TRANSMISSION ISSUES, PEDAL RECALL, AND THE DOORS UNOPENING TWICE (RECALL)

2/20/2018

WHAT DO YOU DO WHEN YOUR STEERING WHEEL SUDDENLY FAILS TO CONTROL YOUR CAR WHILE YOU ARE DRIVING? WITH THE STEERING WHEEL CRANKED AS FAR AS IT WOULD GO, MY CAR CONTINUED GOING STRAIGHT AS I PULLED INTO A PARKING LOT. I STOPPED THE CAR COMPLETELY, BLOCKING TRAFFIC. THEN I SLOWLY DROVE FORWARD WITH NO CONTROL OVER STEERING. THANKFULLY, THE CAR ENDED UP IN A SUITABLE PARKING SPACE, BUT NOT DUE TO MY EFFORTS. I HAD NO MEANS WITH WHICH TO AIM THE CAR. ALL I COULD DO WAS CALL FOR SOMEONE TO GO GET ME. ONE DAY EARLIER, THIS CAR WAS ON AN INTERSTATE DRIVING AT 70 MPH. I SHUDDER TO THINK ABOUT THE HARM THIS WOULD HAVE CAUSED IF IT HAD HAPPENED 24 HOURS EARLIER! FORD'S ONLINE DOCUMENTATION REFERS TO "LOSS OF STEERING ASSIST." THAT'S NOT WHAT HAPPENED. I LOST ALL CONTROL OVER STEERING WITH A STEERING WHEEL THAT MOVES EASILY IN ANY DIRECTION BUT WITH NO EFFECT ON WHERE THE CAR IS GOING. THERE WAS NO WARNING OF ANY KIND WHEN THIS HAPPENED.

8/13/2018

I HAVE CONTACTED THE FORD DEALERSHIP AS WELL AS FORD MOTOR CO.'S CUSTOMER RELATIONS DEPARTMENT ABOUT A PROBLEM WITH MY 2015 FORD TRANSIT'S LOW BEAM HEADLIGHTS BEING INADEQUATE TO SEE AT NIGHT. HERE IS AN EMAIL I SENT TO DIANA ON 9/2816 DESCRIBING THE PROBLEM. PURCHASED NEW 2015 TRANSIT CONNECT, JANUARY 2016. NOTICED LOW BEAM HEADLIGHTS SHINE APPROXIMATELY 60 FEET OUT IN FRONT OF THE CAR. THE LIGHTS ARE NOT CAPABLE OF PROVIDING CORRECT, PROPER LIGHTING. TOOK THE VEHICLE INTO THE FORD DEALER, VILLA FORD, ORANGE CA ON 9/28/16 AND LEFT THE CAR OVERNIGHT.. THE DEALER NEVER EVEN GOT TO THE CAR! I HAVE READ MANY OTHER COMPLAINTS REGARDING THE 2015 TRANSIT CONNECT ON THE INTERNET INCLUDING, EDMUNDS SITE. DIANA AT FORD MOTOR CO. NATIONAL CUSTOMER SERVICE COMPLETELY STOPPED RESPONDING ON 9/2916 AND DID NOTHING. SHE CLAIMED THERE WAS NO SUCH VIN NUMBER AND STOPPED COMMUNICATION WITHOUT ADDRESSING THE SAFETY ISSUE IN ANY WAY. SO, I CALLED FORD CUSTOMER SERVICE, (800)392-3673, AND SPOKE TO ASHLEY. ASHLEY CALLED VILLA FORD IN ORANGE CA. ASHLEY INFORMED ME VILLA FORD SAID THEY DID NOT UNDERSTAND THE PROBLEM WITH THE LOW BEAM HEADLIGHTS. ASHLEY. THEN TOLD ME THERE WAS NOTHING FORD COULD DO. AT THE LAST HOUR OF THE SECOND DAY I WAS INFORMED THEY HAD NOT GOT AROUND TO THE CAR, BUT WOULD HAVE A MECHANIC SEND A QUESTION TO FORD MOTOR CO AN ASK A QUESTION ABOUT THE INADEQUATE HEADLIGHTS. I WAS TOLD BY THE SERVICE REP MATT JUKAM, HE WOULD CALL ME THE NEXT DAY.HE NEVER CALLED. THE VOLTAGE WAS NEVER CHECKED, THE FUSE WAS NEVER CHECKED, HEADLIGHT BULBS WERE NOT OFFERED. VILLA FORD NEVER EVEN LOOKED AT THE CAR AND I LEFT MY VEHICLE FOR TWO DAYS. PHIL TERRY CUSTORM RELATIONS MANAGER FORD MOTOR CO. PO BOX 6248 DEARBORN MI 48126 I DROVE THE VEHICLE 4400 MILES IN ALL SITUATIONS. SAFETY IS AT QUESTION IN ANY DRIVING SITUATION AT NIGHT. .

10/2/2016

CONTACTED FORD DEALER TO CHECK THE LOW BEAM LIGHTS BECAUSE THE LIGHT WERE FOCUSED 60 FT. IN FRONT THE VAN ON THE PAVEMENT AND WERE INSUFFICIENT TO SEE AT NIGHT. LEFT THE CAR AT VILLA TWO DAYS AND THE DEALER NEVER GOT AROUND TO LOOKING AT THE VAN. CONTACTED FORD IN MICHIGAN. FORD CALLED THE DEALER WHO TOLD FORD, "WE DON'T UNDERSTAND THE PROBLEM." FORD MOTOR, INC. IN MICHIGAN TOLD ME THERE WAS NOTHING THEY COULD DO. COMPLAINED TO CA ATTORNEY GENERAL. FORD STILL REFUSES TO LOOK INTO THE MATTER. FORD HAS DONE NOTHING INCLUDING TO LOOK AT MY VAN AND INSPECT THE LIGHTS.

10/21/2016

ALL INTERIOR DISPLAYS AND GAUGES GO BLANK WHILE STILL PARKED OR DRIVING AT ANY SPEED INCLUDING HIGHWAY SPEEDS, TURN SIGNALS AND HAZARD LIGHTS FAIL TO ACTIVATE. MULTIPLE OCCASIONS OVER LAST 4 MONTHS, INCREASING IN FREQUENCY. OCCURRED MULTIPLE TIMES DURING 4 HOUR TRIP ON 07/17/2017. SYSTEM MAY OR MAY NOT RECOVER, ONLY TO GO BLANK AGAIN SHORTLY AFTER. SOMETIMES WHEN RAIN SENSING WIPERS ACTIVATE. SOMETIMES "HILL ASSIST INACTIVE" AND TRACTION CONTROL DISABLED MESSAGES ON SYSTEM RECOVERY.

7/18/2017

TL* THE CONTACT OWNS A 2015 FORD TRANSIT CONNECT. THE CONTACT STATED THAT THERE WERE SEVERAL ELECTRICAL FAILURES IN THE VEHICLE. VARIOUS WARNING INDICATORS FLASHED, THE WINDOWS FAILED TO GO UP AND DOWN, AND THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS SERVICED BY MORE THAN FOUR DEALERS, BUT THE FAILURES STILL OCCURRED. THE FIRST DEALER WAS LASCO FORD (2525 OWEN RD, FENTON, MI 48430, (888) 486-1708). THE SECOND DEALER WAS CREST FORD (26333 VAN DYKE AVE, CENTER LINE, MI 48015, (888) 614-2160). THE THIRD DEALER WAS ELDER FORD (777 JOHN R RD, TROY, MI 48083, (888) 467-5023). THE FOURTH DEALER WAS SUBURBAN FORD OF STERLING HEIGHTS (40333 VAN DYKE AVE, STERLING HEIGHTS, MI 48313, (586) 268-7500). A FIFTH DEALER (DEAN SELLERS FORD, 2600 W MAPLE RD, TROY, MI 48084, (888) 418-7132) REFUSED TO SERVICE THE VEHICLE. A SIXTH DEALER (ROYAL OAK FORD, 27550 WOODWARD AVE, ROYAL OAK, MI 48067, (248) 548-4100) SERVICED THE ELECTRICAL FAILURES AND BRAKE SYSTEM. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE VIN AND FAILURE MILEAGE WERE NOT AVAILABLE.

10/11/2018

TL* THE CONTACT OWNED A 2015 FORD TRANSIT CONNECT. THE CONTACT STATED THAT THE FRONT PASSENGER SEAT BACK FAILED TO REMAIN IN THE UPRIGHT POSITION WHILE A PASSENGER WAS SEATED IN THE FRONT PASSENGER SEAT. THE VEHICLE WAS TAKEN TO THE DEALER TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT AN ENGINEER WOULD HAVE TO INSPECT THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT STATED THAT THE VEHICLE WAS RETURNED TO THE DEALER. THE APPROXIMATE FAILURE MILEAGE WAS 20. UPDATED 04/05/17*LJ

2/7/2017

TL* THE CONTACT OWNS A 2015 FORD TRANSIT CONNECT. THE CONTACT STATED THAT THE PLASTIC BEHIND THE ARMREST FRACTURED, WHICH COULD CAUSE A LACERATION WHILE ENTERING OR EXITING THE VEHICLE. THE CONTACT ALSO STATED THAT THE SEAT BACKS FOR THE REAR SEATS WERE MISSING AND COULD CAUSE INJURIES IN THE EVENT OF A CRASH. JOHN C. STEWART & SON INC (LOCATED AT 5227 VT-103, CUTTINGSVILLE, VT 05738, (802) 492-3312) WAS CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT STATED THAT THE SAME FAILURES WERE EVIDENT IN SEVERAL 2016 FORD TRANSIT CONNECT VANS. THE MANUFACTURER WAS INFORMED OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 40,000. *DT *AS*JB

5/29/2019

WE'VE ONLY HAD THIS VEHICLE FOR 6 MONTHS AND HAVE HAD TIRE REPLACEMENTS, TRANSMISSION ISSUES, PEDAL RECALL, AND THE DOORS UNOPENING TWICE (RECALL)

2/20/2018

AFTER HEARING LOUD ROARING IN THE FRONT OF VEHICLE, TOOK TO MECHANIC WHO DISCOVERED BEARINGS IN LEFT WHEEL NEEDED TO BE REPLACED. THIS WAS WHEN THE VEHICLE WAS ONLY 16 MONTHS OLD WITH 8,000 MILES. THIS WEEK TOOK THE VAN TO THE SAME MECHANIC AFTER HEARING THE SAME ROARING IN THE FRONT, REPLACED BEARINGS IN THE RIGHT FRONT WHEEL. VAN HAS ONLY 30000 MILES. DOESNT SEEM REASONABLE THAT THIS SHOULD HAPPEN TO BOTH WHEELS, INSTALLKED INCORRECTLY OR NOT LUBRICATED CORRECTLY AT THE FACTORY?

5/29/2019

I WAS INVOLVED IN A CAR ACCIDENT (WHICH WASN'T MY FAULT) MY FRONT CARGO WITH THE OTHER FORD PASSENGER REAR DOOR. MY AIRBAG DIDN'T DEPLOY, BUT THE LIGHT IS ON, MY SEATBELT DAMAGED. BUT ALL THE AIRBAGS OF THE OTHER CAR DEPLOYED.

1/10/2020

MY SISTER HAVE ACCIDENT FRONTAL COLLISION ANY AIRBAG WAS DEPLOY...THE SPEED AT IMPACT MOMENT WAS AROUND 35 MILES DRIVING I A CITY ROAD

1/29/2020

The contact owns a 2015 Ford Transit Connect. The contact stated while reversing, the back over prevention camera system failed to function as intended. The contact stated that the back over prevention camera system independently activated and deactivated. In addition, the contact stated that occasionally the back over prevention camera system was inoperable. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure but provided no assistance. The contact referenced an unknown recall; however, the VIN was not included. The contact was informed to take the vehicle to the dealer for a diagnostic test. The failure mileage was approximately 65,000.

5/30/2025

The contact owns a 2015 Ford Transit Connect. The contact received notifications of NHTSA Campaign Numbers: 20V331000 (LATCHES/LOCKS/LINKAGES), 23V502000 (LATCHES/LOCKS/LINKAGES), and 25V572000 (BACK OVER PREVENTION); however, the parts to do the recall repairs were not yet available. The contact stated that the dealer refused to perform the recall repairs regarding the latches, locks, and linkages. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

10/14/2025

TL* THE CONTACT OWNS A 2015 FORD TRANSIT CONNECT. WHILE DRIVING 2 MPH, THE REAR PASSENGER DOOR SWUNG OPEN. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 16V643000 (LATCHES/LOCKS/LINKAGES). IN ADDITION, NONE OF THE DOORS WOULD OPEN OR CLOSE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 8,000.

10/17/2016

TL* THE CONTACT OWNS A 2015 FORD TRANSIT CONNECT. WHILE DRIVING 65 MPH, THE PASSENGER IN THE CONTACT'S VEHICLE FELT LIGHTHEADED AND NAUSEOUS. THE CONTACT WAS ABLE TO PULL THE VEHICLE SAFELY OFF OF THE ROADWAY. THE PASSENGER EXITED THE VEHICLE AND PASSED OUT. THE CONTACT EXITED THE VEHICLE TO CHECK ON THE PASSENGER AND ALSO PASSED OUT. THE CONTACT STATED THAT THROUGH A TEXT MESSAGE SENT PRIOR TO PASSING OUT, THE CONTACT'S CHILDREN WERE ABLE TO SEND EMERGENCY SERVICES TO THE LOCATION WHERE THE VEHICLE WAS STOPPED. THE CONTACT AND PASSENGER WERE TRANSPORTED BY AMBULANCE TO SEEK MEDICAL ATTENTION DUE TO CARBON MONOXIDE POISONING. THE CONTACT STATED THAT OXYGEN WAS ADMINISTERED TO BOTH OCCUPANTS AND THEY STARTED TO FEEL BETTER. THE VEHICLE WAS PREVIOUSLY TAKEN TO AL PACKER FORD WEST PALM BEACH (1530 N. MILITARY TRAIL, WEST PALM BEACH, FL, 33409, 561-689-6550) DUE TO A STRONG EXHAUST ODOR IN THE VEHICLE. THE VEHICLE WAS RETURNED WITHOUT THE CONTACT BEING INFORMED OF WHAT CAUSED THE EXHAUST ODOR. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 87,000. *DT*JB *DT *JB

12/13/2018

DRIVING STRAIGHT ON A HIGHLY TRAVELED ROAD (ONE LANE EACH DIRECTION, HAS RESIDENCES AND BUSINESSES). WHILE IN MOTION, STARTED MAKING A NOISE, SO SLOWED DOWN,AND THEN BACK PASSENGER AXLE AND WHEEL CAME OFF AND VEHICLE WAS RIDING ON THE WHEEL HUB! ODOMETER SHOWS 65,594 MILES.

5/2/2019

TL* THE CONTACT OWNS A 2015 FORD TRANSIT CONNECT. THE CONTACT STATED THAT THE PLASTIC BEHIND THE ARMREST FRACTURED, WHICH COULD CAUSE A LACERATION WHILE ENTERING OR EXITING THE VEHICLE. THE CONTACT ALSO STATED THAT THE SEAT BACKS FOR THE REAR SEATS WERE MISSING AND COULD CAUSE INJURIES IN THE EVENT OF A CRASH. JOHN C. STEWART & SON INC (LOCATED AT 5227 VT-103, CUTTINGSVILLE, VT 05738, (802) 492-3312) WAS CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT STATED THAT THE SAME FAILURES WERE EVIDENT IN SEVERAL 2016 FORD TRANSIT CONNECT VANS. THE MANUFACTURER WAS INFORMED OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 40,000. *DT *AS*JB

5/29/2019

Rear glass on liftgate spontaneously exploded. No apparent cause. Glass shards were showered inside the cabin and the rear of the vehicle. This seems to be an issue with the Transit Connect and other Ford models. NHTSA is aware of the problem.

6/10/2021

The vehicle receives a considerable amount of water through the windshield when it rains (it can be more than a liter depends of the time on the road) it runs down through the glass and also falls on the dash. It can cause visibility problems while driving because the water run on the the driver's side of the glass too.

12/9/2022

2015 Ford transit connect 150: while driving on the freeway 60-65 mph, the brakes seem to lock up without depressing the pedal, slowing to 40 mph and shaking uncontrollably. putting on the brake to exit the flow of traffic, braking caused the vehicle to shake even more finally by pumping the accelerator, the speed increased again. finally getting off of the freeway the brake pedal went to the floor. i had to pump the brake pedal until it finally reacted. less than a week later, getting on the freeway almost the exact thing happened. luckily i was a bit more prepared when i felt the shaking. today, driving the van back to our warehouse approx 15 miles on regular streets (not freeway driving) the brakes again went to the floor. master cylinder not leaking, brakes seem to be in good shape...but something is wrong we brought the vehicle to Sawgrass Ford in Sunrise Florida. they had it for over a month. they were unable to determine the problem and only made suggestions to completely change out all the brake components for $5-$6,000.00 but also said that they could not guarantee that this would fix the problem. the brakes were serviced approximately 6-7 months prior to these incidents I called Corporate Ford office. was told that the 2016 ford transit connect had Brake Hydrolic Control Unit recalls, but the 2015 doesn't have the recall listed. I also looking on manywebsites to verify any other2015/2016 problems with the brakes "locking up" or vehicle going into safe mode (another possibility) there were numerous complaints and concerns regarding 2016 & even 2017 situations very similar to what i went through. ford told me that model DV6Z2C405D BRAKE HYDROLIC CONTROL UNIT did not have an official recall. but that Ford stopped using that model and started using model EK4Z2C405A which was recalled and then replaced the recall with FK4Z2C405C. Seems like there may have been a problem with the 2015 model which caused the to change and with the 2016 model as well

3/2/2023

The contact owns a 2015 Ford Transit Connect. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated, and the contact became aware that the engine was overheating. The contact was not able to pull the vehicle to the side of the road and was forced to keep driving. The vehicle was taken to an independent mechanic; however, had not yet been diagnosed. The contact related the failure with an unknown NHTSA recall; however, the vehicle was not included. The local dealer was contacted and confirmed that the vehicle was not under recall. The manufacturer was not made aware of the failure. The failure mileage was approximately 190,000.

6/21/2024

The contact owns a 2015 Ford Transit Connect. The contact stated while her husband was closing the door, he heard an abnormal sound. The driver removed the panel and located a separation. The side panels had separated, and he became aware that water was entering the vehicle. There were no warning lights illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 14V777000 (Structure). The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 133,934.

7/23/2024

The contact owns a 2015 Ford Transit Connect. The contact stated while driving 35 MPH, The vehicle speedometer failed to display the speed of the vehicle. The vehicle was not taken to a dealer or independent mechanic for diagnoses or repairs. The manufacturer was not notified of the failure and offered no assistance. The contact was referred to call the NHTSA Hotline to file a complaint. The failure mileage was 49,000.

12/27/2024