2011 Ford Flex Owner Complaints

CAR SHUT OFF COMPLETELY WHILE DRIVING. IT HAS HAPPENED TWICE ONCE ON THE HIGHWAY AND ONCE ON A RESIDENTIAL STREET WHILE MAKING A LEFT HAND TURN BOTH TIMES POWER STEERING WAS GONE. TOOK CAR TO DEALER AND THEY CANNOT FIND ANYTHING BECAUSE IT DID NOT LEAVE A SIGNATURE. THE CAR HAS BEEN IN THE DEALERSHIP SHOP FOR TWO WEEKS NOW. *TR

10/28/2010

INTERMITTENT FAILURE OF ELECTRIC POWER STEERING ASSIST. THIS HAS OCCURRED 3 TIMES IN A 6 MONTH PERIOD. FAILURES ON INITIAL VEHICLE START, TRACTION/STABILITY CONTROL SYSTEM FAILURE IS INDICATED. STEERING WHEEL IS VERY DIFFICULT TO TURN DUE TO LACK OF POWER ASSIST. TURNING CAR OFF AND RESTARTING WILL CLEAR FAILURE INDICATION. REPORTED TO FORD DEALER, FORD WAS NOT ABLE TO DUPLICATE INTERMITTENT ISSUE. *TR

8/10/2011

OUR 2011 FORD FLEX WE BOUGHT "NEW" IN OCTOBER OF 2010. IT HAS ALL THE BELLS & WHISTLES & HAD A STICKER PRICE OF ALMOST $51,000 DOLLARS! THIS CAR DOESN'T LIKE TO GET WET! IT STALLS IN THE SNOW, RAIN, CAR WASH & EVEN PUDDLES! IT JUST "SHUTS DOWN" IN THE MIDDLE OF AN INTERSECTION.....IT WILL "PUTT PUTT" & ALMOST STALL ON HIGHWAYS. WE CAME SOOO CLOSE TO GETTING KILLED! UGH....WE HAVE TAKEN THIS CAR IN TO (METRO FORD IN RAYNHAM) AT LEAST "4" TIMES. THE LAST TIME WAS JUST A COUPLE OF MONTHS AGO & IT WAS THERE FOR "4 WEEKS"! THEN THIS WAS IT.........WE HAD TO TAKE OUR 19 YR OLD DAUGHTER TO THE ER LAST THURS. SHE FAINTED & HIT HER HEAD HARD! THIS CAR STALLED ALL THE WAY TO THE HOSPITAL!! WE ALMOST DIDN'T MAKE IT THERE!! THIS CAR IS A LEMON!!! WE WANT THIS CAR REPLACED!!! *TR

2/18/2014

TL* THE CONTACT OWNS A 2011 FORD FLEX. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THERE WAS SUDDEN REDUCTION OF ENGINE POWER WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE BOTH TURBO BOOSTER WERE REPLACED. MOST RECENTLY, THE FAILURE RECURRED AND ONE OF THE TURBO BOOSTER WAS REPLACED BY THE DEALER. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 68,260.

4/1/2014

TRANSMISSION ON FLEX OFTEN HESITATES AND THUNKS WITH A LURCH. THE LURCH IS SO BAD IT NOW FEELS LIKE WE ARE BEING HIT. IT HAS HAPPENED IN BOTH FORWARD AND REVERSE. TRIED TO GET IT REPAIRED TWICE AT DEALER - HAVEN'T BEEN ABLE TO FIX. ONLINE FORUMS WITH OWNERS AND SERVICE BULLETINS DESCRIBE SIMILAR PROBLEM. FORD NOT ACKNOWLEDGING ISSUE OR HELPING. *TR

11/13/2012

LUNGING AND STALLING AT START UP AND WHEN ACCELERATING AT HIGHWAY SPEEDS. *TR

6/10/2014

MY WIFE WAS DRIVING DOWN THE INTERSTATE YESTERDAY, WHEN THE REAR PASSENGER DOOR WINDOW SHATTERED INTO PIECES FOR APPARENTLY NO REASON. THANKFULLY NO ONE WAS INJURED. BASED ON INFORMATION FOUND ON THE INTERNET, THIS HAS HAPPENED WITH OTHER FORD MODELS AND YEARS AS WELL. I HAVE SEEN WHERE NHTSA HAS INVESTIGATED THIS SIMILAR ISSUE WITH 2010-2011 FORD ESCAPE AND MERCURY MARINER, BUT HAVE NOT BEEN ABLE TO FIND THE RESULTS OF THE INVESTIGATION. CARCOMPLAINTS.COM SHOWS 3 COMPLAINTS ABOUT THE SAME ISSUE WITH THE FORD FLEX. *TR

3/18/2015

TWO OUT OF FOUR OF OUR WINDOW UP/DOWN CONTROL BUTTONS ARE NOT WORKING. THE TWO THAT ARE NOT WORKING ARE ALSO THE TWO THAT ARE USED THE LEAST AMOUNT. I BELIEVE IT TO BE A MANUFACTURERS DEFECT.

5/12/2015

ON AUGUST 8, 2011 AND FEBRUARY 8, 2012, MY NEW FLEX SHUT DOWN WHILE I WAS DRIVING. THE DASHBOARD LIGHTS FLASHED ON, AND THE VEHICLE TURNED OFF - TOTAL ELECTRICAL FAILURE - COULDN'T ACCELERATE OR BRAKE - HAD TO PAINFULLY PULL CAR OFF THE ROAD. CAR WAS TOWED TO DEALER. FORD DEALER PERFORMED DIAGNOSTICS TO NO AVAIL, AS WHEN THE ENGINE SHUT DOWN, I TURNED THE KEY OFF, THEN BACK ON AGAIN - THIS DESTROYED THE DATA. SEEMS LIKE A FUNDAMENTAL DATA SYSTEM FLAW. NONETHELESS, I DROVE AWAY FROM THE DEALERSHIP IN FEAR, ONLY TO HAVE THE INCIDENT RECUR SIX MONTHS LATER. NOW I AM DRIVING WITH A DATA FLIGHT RECORDER FOR A MERE TEN DAYS, THE BUTTON OF WHICH I MUST PUSH, IF AND WHEN THE CAR SHUTS DOWN AGAIN. WITHOUT RECORDED DATA, THOUGH FORD BELIEVES MY REPORT, I SEEM TO HAVE NO RECOURSE WITH FORD. I NOW AM DRIVING IN FEAR FOR MY OWN AND OTHERS' LIVES. HAS THIS HAPPENED TO ANYONE ELSE? *TR

2/16/2012

WAS DRIVING DOWN THE FREEWAY-NO RAIN OR INCLEMENT WEATHER. AT 70MPH HAD TOTAL LOSS OF POWER (NO LIGHTS, NO POWER STEERING, NOTHING) WITH NO PREVIOUS WARNING. ABLE TO GET TO SIDE OF ROAD WITHOUT INCIDENT. CAR RESTARTED AND HAD NO FURTHER PROBLEMS. I IMMEDIATELY CALLED MY FORD DEALER AND HAD THE CAR SERVICED AFTER WE RETURNED HOME FROM VACATION. I ALSO HAD THIS HAPPEN DURING MY FIRST WEEK OF OWNERSHIP OF THE CAR ABOUT OCT, 20 WHEN I LOST TOTAL POWER AGAIN, BUT AT A MUCH LOWER SPEED (30MPH) I ALSO CALLED FORD AND HAD MY CAR SERVICED AFTER THIS. *TR

3/7/2013

A FRIEND OF MINE RECENTLY PURCHASED A 2011 FORD FLEX. UPON BRINGING IT HOME WE DECIDED TO LET MY CHILDREN INSIDE THE VEHICLE TO "CHECK IT OUT" AS MY OLDER SON WOULD SAY. WHEN MY YOUNGEST SON, 18 MONTHS AT THE TIME ENTERED THE SECOND ROW OF THE CAR, HE WENT TO REACH FOR THE SEAT BELT( TRYING TO BE COOL LIKE HIS BROTHER WHO WAS ALREADY BUCKLED AND ON A PRETEND ROAD TRIP)AND ACCIDENTALLY BUMPED AGAINST AN AUTOMATIC SEAT FOLD BUTTON WHICH CAUSED THE SEAT BACK TO FLIP DOWN HITTING HIM IN THE FACE, KNOCKING HIM INTO THE BACK OF THE DRIVER'S SEAT AND DOWN ONTO THE FLOOR WHERE THE SEAT CONTINUED TO FOLD. THIS HAS HAPPENED 2 TIMES BEFORE MY FRIEND DECIDED TO DISCONNECT THE SWITCH HIMSELF. LUCKILY THERE WERE NO MAJOR INJURIES, ONLY A BITTEN TONGUE, A RED MARK ON HIS FOREHEAD AND AFTER THE SECOND TIME( WHICH WAS NOT AS FORCEFUL DUE TO THE FACT THAT THE SEATING FOLDING ONTO HIM THE FIRST TIME HAD WEEKEND THE MOTOR A BIT) HOWEVER NOW HE DOES HAVE A SLIGHT FEAR OF GETTING INTO THE CAR. I THINK THE AUTOMATIC SEAT FEATURE IS NOT WHAT CAUSED THIS, BUT THE PLACEMENT OF THE BUTTON ITSELF WHICH IS RIGHT ALONGSIDE THE 2ND ROW SEAT WHERE IT IS EASY TO ACCIDENTALLY PUSH IT, EASY ENOUGH FOR MY 5 YEAR OLD TO REACH WHILE SEATED AND BELTED IN(THE BUTTON CAN BE ACTIVATED WITH DOOR OPEN OR SHUT) IF THEY CAN'T CHANGE THE PLACEMENT OF THE BUTTON THEY SHOULD AT LEAST BE OUTFITTED WITH SOME TYPE OF FLIP COVER YOU HAVE TO OPEN BEFORE THE BUTTON CAN BE PUSHED PREVENTING THINGS LIKE THIS FROM HAPPENING. *TR

1/27/2011

TL* THE CONTACT OWNS A 2011 FORD FLEX. THE CONTACT STATED THAT THE VEHICLE WAS PARKED WHEN ONE OF HER CHILDREN ACCIDENTALLY PRESSED THE BUTTON TO AUTOMATICALLY FOLD DOWN THE THIRD ROW PASSENGER SEAT. WHILE THE SEAT WAS FOLDING DOWN, ANOTHER CHILD'S LEG GOT STUCK BETWEEN THE SEAT AND FLOORBOARD. AS A RESULT, THE CHILD SUFFERED BRUISES AND CARPET BURNS. THE CONTACT EXPRESSED SERIOUS CONCERN THAT THE SEAT CONTINUED TO FOLD DOWN FORCEFULLY WHEN THE CHILD WAS STUCK. THE CONTACT ALSO EXPRESSED CONCERN OVER HOW DIFFICULT IT WAS TO FREE THE CHILD ONCE THE CHILD'S LEG WAS WEDGED BETWEEN THE SEAT AND FLOORBOARD. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA. THE FAILURE MILEAGE WAS 16,439. THE VIN WAS UNAVAILABLE.

9/27/2011

CPSC: I1380138A. 2011 FORD FLEX. CONSUMER STATED THAT THE CHEMICALS USED TO MELT ICE AND SNOW CAUSES BRAKES ROTORS TO ROT. STATED AT 23,000 MILES HIS REAR BRAKES HAD TO BE REPLACED. ALSO AT 32,000 MILES ALL THE ROTORS WERE ROTTEN AGAIN. *LN

8/22/2013

PERSISTENT BRAKE SQUEALING EVEN THOUGH BRAKES WERE REGULARLY SERVICED. ON FURTHER INSPECTION, IT WAS DISCOVERED THAT A FRONT BRAKE CALIPER WAS CRACKED AND LEAKING. HAD TO BE REPLACED. REPLACED BOTH FRONT CALIPERS AND ASSOCIATED PARTS FOR SAFETY REASONS, PARTS AND LABOR TOTALED OVER $1000. NO ONE HAD EVER HEARD OF A CALIPER FAILING ON A CAR WITH SO FEW MILES. SQUEALING HAS BEEN RESOLVED SINCE THIS REPAIR. *TR

3/17/2014

CAR SHUT OFF COMPLETELY WHILE DRIVING. IT HAS HAPPENED TWICE ONCE ON THE HIGHWAY AND ONCE ON A RESIDENTIAL STREET WHILE MAKING A LEFT HAND TURN BOTH TIMES POWER STEERING WAS GONE. TOOK CAR TO DEALER AND THEY CANNOT FIND ANYTHING BECAUSE IT DID NOT LEAVE A SIGNATURE. THE CAR HAS BEEN IN THE DEALERSHIP SHOP FOR TWO WEEKS NOW. *TR

10/28/2010

THERE IS A STRONG SULFUR SMELL IN THE CABIN AFTER A HARD ACCELERATION, IT SMELLS SIMILAR TO CATALYTIC CONVERTER EXHAUST ODOR. SERVICE DEPARTMENT WAS ABLE TO REPLICATE THE ODOR BUT TOLD ME THAT THEY DO NOT KNOW HOW TO FIX THE PROBLEM.

9/21/2011

I PURCHASED A 2011 FORD FLEX NEW. AT 24000 MILES MY TIRES WERE BAD AND NEEDED REPLACING. THE TIRES WERE DEFECTIVE. THE DEALER HAD ME PAY HALF PRICE. AT 48 K THE NEW TIRES ARE AGAIN BAD AND NEED REPLACING. MANY COMPLAINTS ONLINE OF FORD FLEX OWNERS WITH SUBSTANDARD TIRES. FORD MUST BE AWARE OF THIS WHEN 7 OUT 10 PEOPLE COME IN WITH THIS PROBLEM. OWNERS SHOULD BE GIVEN NEW TIRES OF A DIFFERENT MAKE AT FORDS EXPENSE. MY CAR WAS LOOKED AT BY A TIRE REPAIR SHOP TIRE KINGDOM WHO EXPLAINED THE TIRES FORD PROVIDES FOR THE FLEX ARE NOT INTENDED FOR A VEHICLE OF THAT MAKE AND WEIGHT GVW.

5/30/2015

I WAS ATTEMPTING TO CHANGE THE TIRE, WHILE JACKING UP THE CAR IT BECAME DIFFICULT. I STOPPED, AND LOWERD THE CAR. THEN EXAMINED THE JACK AND FOUND THAT THE THREADED NUT THAT THE UP AND DOWN ADJUSTING ROD THREADS THRU WAS CRACKED OPEN.THIS NUT LOOKS TO BE OF SOME TYPE OF POT METAL, UNLIKE THE REST OF JACK WICH IS STEEL. I TALKED TO FORD MOTOR CO AND THEY SAID THE MOST THEY MIGHT DO IS REPLACE THE JACK. THAT JACK IS AN ACCIDENT WAITING TO HAPPEN. I WANT A SAFE JACK .

9/3/2015

UPON ACCELERATION, USUALLY FROM A COMPLETE STOP SUCH AS ACCELERATING FROM A STOP SIGN OR ON A GREEN LIGHT, IT FEELS AS THOUGH THE GEARS DO NO CATCH & THE CAR JERKS AND THE RPM'S RAISE BUT THE CAR STOPS ACCELERATING. WILL ALSO HAVE A "STUTTERING" OR "JERKING" WHILE AT A COMPLETE STOP WITH BREAK PEDAL BEING PRESSED DOWN. I HAVE TAKEN THIS ISSUE TO THE DEALERSHIP AS IT IS STILL UNDER EXTENDED WARRANTY AND HAVE BEEN TOLD THAT EVERYTHING CHECKED OUT NORMAL & THE MECHANIC AT THE DEALERSHIP WAS UNABLE TO GET THE VEHICLE TO HAVE SUCH DESCRIBED MALFUNCTIONS BECAUSE IT IS DOESN'T HAPPEN EVERY SINGLE TIME THE CAR IS DRIVEN. THE JERKING WHILE DRIVING ACTUALLY OCCURS ON A DAILY BASIS BUT IS SPORADIC & CAN JERK YOU FORWARD DUE TO THE SUDDEN LOSS OF ACCELERATION CAPABILITY, STARTLING AND PAINFUL BECAUSE THE SEATBELT MECHANISM HAS ENGAGED IN THE PAST.

7/16/2015

MY 2011 FORD FLEX IS BACK AT THE DEALERSHIP AFTER THREE TURBOS BEING REPLACED ON IT'S 3.5 LITER ECOBOOST ENGINE. OUR VEHICLE WAS AT THE DELERAHIP FOR A MONTH AND WE JUST GOT IT BACK ON THURSDAY. ON SATURDAY I WAS ON THE HIGHWAY WHEN IT BEGAN SHUTTERING AND JUST DIED. I WAS LEFT POWERLESS IN THE LEFT LANE OF A FOUR LANE HIGHWAY AND HAD TO MANUVER ACROSS THREE LANES TO GET TO THE SHOULDER WITH THREE CHILDREN ON BOARD. VEHICLE WOULD NOT RESTART AND WHILE TURNING THE KEY WHITE SMOKE BILLOWING FROM UNDER THE HOOD. VERY STRONG SMELL OF ELECTRICAL BURNING. I THOUGHT IT WA GOING TO CATCH ON FIRE AND HAD THE CHILDREN GET OUT OF THE VEHICLE ON THE SIDE OF A VERY BUSY HIGHWAY. THIS IS THE THIRD TIME AT THE DEALERSHIP FOR THIS CAR WITH ENGINE PROBLEMS. PLEASE ADVISE ON WHAT COURSE OF ACTION I NEED TO TAKE SO THIS DEFECTIVE ENGINE DOES NOT CAUSE DEATH OR INJURY.

2/5/2017

MY VEHICLE WILL ACT AS IF IT IS IN NEUTRAL WHEN I PULL AWAY FROM A STOP. THE ENGINE REVS WITH NO FORWARD MOVEMENT THEN THE TRANSMISSION "BANGS" INTO GEAR AND THE VEHICLE PROCEEDS. THE HESITATION COULD CAUSE AN ACCIDENT. THERE ARE NUMEROUS REPORTS FROM OTHER OWNERS ON THE FORDFLEX.NET FORUM ABOUT THIS, FORD HAS NOT BEEN ABLE TO HELP ME RECTIFY THE PROBLEM. *TR

3/28/2011

MY VEHICLE WILL ACT AS IF IT IS IN NEUTRAL WHEN I PULL AWAY FROM A STOP. THE ENGINE REVS WITH NO FORWARD MOVEMENT THEN THE TRANSMISSION "BANGS" INTO GEAR AND THE VEHICLE PROCEEDS. THE HESITATION COULD CAUSE AN ACCIDENT. THERE ARE NUMEROUS REPORTS FROM OTHER OWNERS ON THE FORDFLEX.NET FORUM ABOUT THIS, FORD HAS NOT BEEN ABLE TO HELP ME RECTIFY THE PROBLEM. THIS HAPPENED TO ME AS WELL, AND HAS HAPPENED ON 3 OCCASIONS FORD HAS LOOKED, BUT NOT FOUND ANY PROBLEM OR SOLUTION. *TR

4/15/2011

HANKOOK OPTIMA 19" TIRE SIDEWALL FOR FORD FLEX. I PURCHASE A BRAND NEW 2011 FORD FLEX ON 5/5/11 WITH 19" HANKOOK OPTIMA TIRES. 2 DAYS AGO, MY SIDEWALL BUSTED AS I ENTERED MY DRIVEWAY, WHICH RAISED, BUT THAT I HAVE DRIVEN OVER HUNDREDS OF TIMES WITH MY INFINITY FX35 TIRES WITHOUT A PROBLEM. I DON'T BELIEVE THE BRAND NEW SIDEWALL SHOULD BUST IF YOU GO OVER A BUMP WRONG. *TR

5/19/2011

BF GOODRICH ADVANTAGE T/A TIRES SIZE 23560R17. I HAD WEAR ON TIRES AFTER 18000 MILES. REPLACED TIRES WITH ANOTHER SET. AFTER ONLY 23000 MILES I HAVE WEAR ON TIRES AND THEY NEED REPLACING. THIS TIRE IS SUPPOSED TO BE GOOD FOR OVER 36K MILES. THEY ARE SUBSTANDARD AND DEFECTIVE AND BE GOODRICH AND FORD MOTOR COMPANY SHOULD BE AWARE OF THESE 7 OUT OF 10 OWNERS COMPLAIN OF DEFECTS AND NOTHING IS DONE OF CHANGED.

5/30/2015

MY WIFE WAS DRIVING DOWN THE INTERSTATE YESTERDAY, WHEN THE REAR PASSENGER DOOR WINDOW SHATTERED INTO PIECES FOR APPARENTLY NO REASON. THANKFULLY NO ONE WAS INJURED. BASED ON INFORMATION FOUND ON THE INTERNET, THIS HAS HAPPENED WITH OTHER FORD MODELS AND YEARS AS WELL. I HAVE SEEN WHERE NHTSA HAS INVESTIGATED THIS SIMILAR ISSUE WITH 2010-2011 FORD ESCAPE AND MERCURY MARINER, BUT HAVE NOT BEEN ABLE TO FIND THE RESULTS OF THE INVESTIGATION. CARCOMPLAINTS.COM SHOWS 3 COMPLAINTS ABOUT THE SAME ISSUE WITH THE FORD FLEX. *TR

3/18/2015

I HAD JUST FINISHED VACUUMING THE INSIDE OF MY 2011 FORD FLEX. THE REAR AUTOMATIC LIFTGATE WAS UP AND I WAS LEANING INTO THE BACK OF THE FLEX REINSTALLING MY CARGO NET WHEN THE HYDRAULICS FAILED AND THE LIFTGATE CAME SLAMMING DOWN ON MY BACK. I SUSTAINED BRUISING AND MUSCLE INJURY. IF IT WAS MY ARM OR LEG IT MIGHT HAVE RESULTED IN AN AMPUTATION. IF IT WAS MY HEAD / NECK IT COULD HAVE RESULTED IN A FATALITY. IF IT WAS MY CHILD HE COULD HAVE BEEN PARALYZED. WHY ARE THERE NO SAFETY FEATURES THAT PREVENTS THE LIFTGATE FROM SLAMMING SHUT IF THE HYDRAULICS FAIL?

8/24/2015

TL* THE CONTACT OWNS A 2011 FORD FLEX. THE CONTACT STATED THAT SHE WAS UNABLE TO ADJUST THE DRIVER'S SIDE-VIEW MIRRORS. THE CONTACT STATED THAT THE PLASTIC CASE SURROUNDING THE SIDE VIEW MIRRORS WERE MELTING DUE TO THE SUN. THE VEHICLE WAS TAKEN TO THE DEALER, WHO DID NOT DETERMINE A CAUSE FOR THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO FURTHER ASSISTANCE. THE FAILURE AND CURRENT MILEAGE WAS 9,000. UPDATED 8/23/13 *CN UPDATED 09/13/2013 *JS

5/14/2013

MY WIFE WAS DRIVING DOWN THE INTERSTATE YESTERDAY, WHEN THE REAR PASSENGER DOOR WINDOW SHATTERED INTO PIECES FOR APPARENTLY NO REASON. THANKFULLY NO ONE WAS INJURED. BASED ON INFORMATION FOUND ON THE INTERNET, THIS HAS HAPPENED WITH OTHER FORD MODELS AND YEARS AS WELL. I HAVE SEEN WHERE NHTSA HAS INVESTIGATED THIS SIMILAR ISSUE WITH 2010-2011 FORD ESCAPE AND MERCURY MARINER, BUT HAVE NOT BEEN ABLE TO FIND THE RESULTS OF THE INVESTIGATION. CARCOMPLAINTS.COM SHOWS 3 COMPLAINTS ABOUT THE SAME ISSUE WITH THE FORD FLEX. *TR

3/18/2015

UPON ACCELERATION, USUALLY FROM A COMPLETE STOP SUCH AS ACCELERATING FROM A STOP SIGN OR ON A GREEN LIGHT, IT FEELS AS THOUGH THE GEARS DO NO CATCH & THE CAR JERKS AND THE RPM'S RAISE BUT THE CAR STOPS ACCELERATING. WILL ALSO HAVE A "STUTTERING" OR "JERKING" WHILE AT A COMPLETE STOP WITH BREAK PEDAL BEING PRESSED DOWN. I HAVE TAKEN THIS ISSUE TO THE DEALERSHIP AS IT IS STILL UNDER EXTENDED WARRANTY AND HAVE BEEN TOLD THAT EVERYTHING CHECKED OUT NORMAL & THE MECHANIC AT THE DEALERSHIP WAS UNABLE TO GET THE VEHICLE TO HAVE SUCH DESCRIBED MALFUNCTIONS BECAUSE IT IS DOESN'T HAPPEN EVERY SINGLE TIME THE CAR IS DRIVEN. THE JERKING WHILE DRIVING ACTUALLY OCCURS ON A DAILY BASIS BUT IS SPORADIC & CAN JERK YOU FORWARD DUE TO THE SUDDEN LOSS OF ACCELERATION CAPABILITY, STARTLING AND PAINFUL BECAUSE THE SEATBELT MECHANISM HAS ENGAGED IN THE PAST.

7/16/2015

WHILE ACCELERATING FROM A STOP WITH THE ECOBOOST SYSTEM , THE CAR WILL ALMOST STALL, THEN SPEED UP WITH OUT YOUR FOOT ON THE PEDAL. IT BLOWS BLACK SMOKE AND THEN IT WILL BE FINE. THIS HAS HAPPENED ON AND OFF FOR THE PAST SEVERAL MONTHS, THE CAR HAD AN EXTENDED WARRANTY IN WHICH THIS SHOWED UP. WHILE THIS WAS GOING ON I HAVE HAD TO REPLACE THE POWER TRANSFER UNIT BECAUSE IT LOCKED UP, THEN THE CAR WOULD ONLY WORK IN FRONT WHEEL DRIVE, HAVE HAD NOTHING BUT TROUBLE SINCE THE CAR RADIATOR FAN SYSTEM BURNED UP AND THEY REPLACED. THEY HAVE RE-FLASHED MODULES AFTER THEY COULD NOT FIGURE OUT WHAT WAS HAPPENING, HOWEVER IT STILL DOES IT. I AM WORRIED AS THE CAR HAS SPEED UP TO 2000 RPM WHILE DRIVING AND STAYED THERE WITH OUT THE GAS PEDAL BEING PRESSED.

10/5/2015

ON 2100 HRS 21 NOV 2015, MY DAUGHTER WAS INVOLVED IN A DEER STRIKE ACCIDENT ON HWY 36 VICINITY HAMILTON, MISSOURI. SHE WAS TRAVELING EAST ON THE HIGHWAY 36 AT 55-60 MPH WHEN A DEER RAN INTO THE PATH OF THE CAR. THE IMPACT WAS FROM CENTER LINE OF THE CAR TOWARDS THE DRIVERS SIDE. SHE APPLIED THE BRAKES UPON SEEING THE DEER BUT THE STRIKE AND APPLICATION OF BRAKES WERE PRETTY MUCH SIMULTANEOUS. SHE PULLED THE CAR OFF THE ROAD AND COULDN'T EXIT THE DRIVER'S DOOR BECAUSE THE FRONT FENDER OVERLAPPING THE DOOR DUE TO IMPACT. THE AIRBAG DID NOT DEPLOY, SHE WAS WEARING HER SEAT BELT WHICH PROBABLY SAVED HER FROM ANY MAJOR INJURIES. BASED UPON THE FRONTAL DAMAGE TO THE VEHICLE THE AIRBAG SHOULD HAVE DEPLOYED. AS YOU CAN SEE IN THE ATTACHED PHOTOS THE FRAME AND INTERNAL BUMPER ARE EXPOSED APPROXIMATELY A FOOT BEYOND THE BODY WHICH HAS BEEN CRUSHED BACK. IN MY OPINION IT APPEARS THAT THERE WAS ENOUGH FRONTAL FORCE WHICH SHOULD HAVE DEPLOYED THE AIRBAG. I THEREFORE FEEL THE AIRBAG WAS DEFECTIVE AND CREATED A SIGNIFICANT SAFETY ISSUE.

11/23/2015

This accident didn’t involve myself. It involved my father who borrowed my 2011 Ford Flex for the evening. This was a one vehicle accident. It is unknown what happened to cause him to Swerve and hit a hit. The air bags didn’t deploy in the Vehicle. My father was wearing his seatbelt. An electric fire started and the car burnt along with my father he wasn’t able to be pulled from the vehicle before it caught fire. According to the witnesses, the airbags did not go off. My father had blunt trauma to the chest and to his frontal lobe and broken ribs. In addition to lots of other injuries that would’ve been avoided if the airbags would have went off. My father could’ve been alive if the airbags went off. But instead, he is dead. The pain and suffering and Trauma that I live through every day of my life of missing my father has been unbearable this past year. I 100% believe the fire started from the air bags not going off and it was faulty wiring in this vehicle. I believe this whole Heartedly. My father Didn’t deserve to die this way. I have a flash drive of the scene with pictures taken by the Missouri State Highway patrol that has been certified. I can send as Evidence as well. I have not viewed this flash drive as it would be too traumatic for me to view them of my father. I do not want to picture him like that. But I feel this case needs to be investigated. I no longer can be OK with this situation. The insurance company never inspected it. My insurance company was the General- Full Coverage- also the vehicle had a lean on it with Car Mart. Not sure if anyone inspected the vehicle after the accident. I know the Missouri house patrol did a full investigation. It set at at tow yard for months in Columbia, Mo. There were multiple people on the scene. Macon Co. ambulance, Macon Co. fire and rescue Macon Co. corners office which they called wrong time of death Which letters to believe my father wasn’t dead yet From the accident. The air bags could have saved HIM!!!!!!

7/23/2024

MY CURRENT PROBLEM AND HAS BEEN FOR THE LAST TWO YEARS IS THE STEERING. AS OF AROUND TWO YEARS AGO I HAVE ON MULTIPLE OCCASIONS THE POWER STEERING LOSING THE POWER AND RESULTING IN A VERY HARD TO CONTROL STEERING WHEEL WHILE DRIVING AND VERY DANGEROUS. THIS HAS HAPPENED ROUGHLY 6 TIMES IN TWO YEARS. THE PROBLEM WOULD USUALLY CORRECT WITHIN AROUND FIVE SECONDS OR SO. I HAVE FOUND THERE ARE MANY ISSUES ON THE INTERNET WITH THIS FORD PROBLEM THERE IS A RECALL ON THIS ISSUE BUT MY VEHICLE COMES WITHIN A MONTH OF THE RECALL SO NO HELP FROM THE DEALER. THEY WANT AROUND 3000-3500 FOR REPLACEMENT. WORD IS THEY HAVE DOUBLED THE COST OF THE PART TO MAKE UP FOR THE RECALL MONEY THEY ARE OUT. THIS IS VERY SERIOUS AND FORD NEEDS TO HANDLE THIS ISSUE. I AM TOLD THE STEERING IS ELECTRICAL. MY SECOND ISSUE IS AND HAS BEEN GOING ON FOR AROUND TWO YEARS ALSO. THE LIGHTS WILL GO OUT EACH AT DIFFERENT TIMES. IF I REACH DOWN AND TURN THE SWITCH OFF AND ON AGAIN THEY WILL COME BACK ON AND CORRECT, BUT WILL GO OUT AGAIN. ONE MIGHT GO OUT AND THEN ONE STAY ON. A DANGEROUS SITUATION OCCURS WHEN THEY BOTH FAIL. TURNING THE SWITCH ON AND OFF ALWAYS TURNS THEM ON. PROBLEM HAS BEEN HAPPENING FOR TWO YEARS. NEITHER ARE NOT FIXED AT THE MOMENT.

10/8/2018

I had changed all my bulbs and fuses to my car for my brake lights several times and they still don’t work. My car almost got hit with me and my kids in it due to my break lights not working. Also my car keeps saying service advance trac and keeps saying it every time I drive. My car also keeps running out of power steering fluid every two week I have to add more to keep it from making that loud noise while driving.

10/22/2025

TL* THE CONTACT OWNS A 2011 FORD FLEX. WHILE DRIVING APPROXIMATELY 70 MPH WITH THE AIR CONDITIONER ACTIVATED THE CONTACT NOTICED A SMELL SIMILAR TO PETROLEUM TAR COMING FROM THE VENTS. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE CONTACT TESTED THE INTERIOR OF THE VEHICLE WITH A CARBON MONOXIDE TESTER AND THE LEVEL OF CARBON MONOXIDE INCREASED WHILE ACCELERATING. A TEST WAS ALSO PERFORMED WITH THE FIRE DEPARTMENT CARBON MONOXIDE READER AND THE LEVEL INCREASED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 50.

7/20/2011

TL* THE CONTACT OWNS A 2011 FORD FLEX. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE RACK THAT WAS MOUNTED ON THE ROOF DETACHED FROM THE VEHICLE AND HIT ANOTHER VEHICLE THAT WAS TRAVELING BEHIND THE CONTACT. AN AUTHORIZED DEALER WAS NOTIFIED AND AN APPOINTMENT WAS SCHEDULED TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 9,000 AND THE CURRENT MILEAGE WAS 9,100. THE VIN WAS UNAVAILABLE.

8/8/2011

THERE WAS NO SPECIFIC INCIDENT; THE PROBLEM RECURS SPONTANEOUSLY, WITHOUT INCIDENT. THE PROBLEM IS THAT THE SUPER LATCH BELT LOOSENS SIGNIFICANTLY ON ITS OWN AFTER BEING CORRECTLY AND TIGHTLY INSTALLED. IT HAS HAPPENED NUMEROUS TIMES WHILE INSTALLED REAR-FACING IN TWO DIFFERENT CARS. REINSTALLATION DID NOT HELP, SO THE MANUFACTURER WAS CONTACTED TO GET A NEW LATCH BELT. I'VE HAD THE SAME PROBLEMS WITH THE NEW LATCH BELT. UNFORTUNATELY, THE SEAT DOES NOT INSTALL WELL WITH A SEAT BELT BECAUSE OUR CARS HAVE STEMS ON THE FEMALE PART OF THE BELTS, CAUSING IT TO INTERFERE WITH THE BELT PATH ON THE CHILD RESTRAINT. THIS CHILD RESTRAINT IS THEREFORE UNUSABLE FOR US. (RELATED VEHICLE INFORMATION: MODEL YEAR=2011, MAKE=FORD, MODEL=FLEX). *TR

11/9/2011

THE EXHAUST MUFFLER HOLDING HOOK IS SEVERLY RUSTED. PART WAS REPLACED BY THE DEALER IN 05/03/11. REPLACED PART IS SEVERLY RUSTED AGAIN. VEHICLE HAS 7500 MILES ONLY. THE VEHICLE IS DRIVEN TO A MINIMUM DURING THE WINTER MONTHS. THIS IS A POTENTIAL HAZARD SINCE THE MUFLER COULD FALL OFF THE CAR WHILE DRIVING DUE TO EXECIVE RUST OF THE SUPPORTS. *TR

5/4/2012

THERE WERE TWO OCCURRENCES. ON 7/5/12, THE FLEX WAS PARKED BUT STILL RUNNING, WE RAISED THE REAR DOOR/TAILGATE TO REMOVE ITEMS FROM THE FLEX. ONE OF MY 4 YEAR OLD DAUGHTERS STOOD NEAR THE BACK BUMPER AREA AND RECEIVED A BURN TO HER LEG FROM ONE OF THE EXHAUST PIPES CREATING A C SHAPE IMPRINT OF THE TAILPIPE OPENING. THIS WAS WITNESSED BY A HOTEL EMPLOYEE. THE ADULT LEANED IN TO THE VEHICLE MANY TIMES, BUT DID NOT BURN. ON 7/6/12, THE FLEX WAS PARKED AND NOT RUNNING. AGAIN, THE BACK DOOR/TAILGATE WAS RAISED AND WE WERE GETTING ITEMS OUT OF THE VEHICLE AND GETTING READY FOR OUR EVENT. EVEN AFTER WARNING (OF THE TAILPIPE), THE SAME 4 YEAR OLD MANAGED TO RECEIVE ANOTHER BURN TO THE SAME LEG FROM THE EXHAUST/TAIL PIPE. *TR

7/9/2012

THE CAR HAS A TERRIBLE SMELL COMING FROM THE AIR CONDITIONING UNIT. THE CAR HAS BEEN TO THE DEALER ON SEVERAL OCCASIONS WHERE THEY STATE THAT IT'S THE 'FILTER' BUT THE PROBLEM CONTINUES. THIS ISSUE HAS NEVER BEEN FULLY RESOLVED AND IS ON-GOING. THE CAR HAS OTHER MINOR DEFECTS WITH THE WINDOW OPERATION (LOUD SQUEALING AS IF THE WINDOW IS RUBBING AGAINST SOMETHING) AND THE DEALER HAS FAILED TO RESOLVE THAT ISSUE AS WELL. I AM CONCERNED THAT THE SMELL INSIDE THE CAR COULD BE TOXIC AND UNSAFE FOR MY CHILDREN. HOW CAN I GET THE DEALER TO TEST THE AIR QUALITY AND QUIT REPLACING THE FILTER AS A TEMPORARY ATTEMPT TO AN ONGOING PROBLEM? *TR

5/15/2013

AUTOMATIC/MOTORIZED REAR HATCH FAILED.....MOTOR OPENED HATCH TO FULL NORMAL EXTENSION AND THEN SLAMMED DOWN WITH NOTHING TO SLOW IT DOWN...NARROWLY MISSING MY 5 YEAR OLD CHILD. WAS TOLD SHOCKS FAILED AS WELL AS HATCH MOTOR.... SO NOTHING IN PLACE TO SLOW DOWN THE FALL. TYPICALLY IF MOTOR GOES OUT...SHOCKS ARE THERE TO SLOW IT DOWN. DEALERSHIP SURMISES THAT SHOCKS WERE PROBABLY ALREADY "OUT" AND THE MOTOR HAS BEEN CONTROLLING THE HATCH ON ITS OWN, WITHOUT THE ASSISTANCE OF THE SHOCKS. "DON'T KNOW SHOCKS ARE BAD UNTIL MOTOR GOES OUT"..RESULTING IN NOTHING HOLDING IT UP. EXTREMELY DANGEROUS AND COULD HAVE EASILY INJURED MY CHILD IF I HADN'T REACTED SO QUICKLY. FORD CLAIMS THEY HAVE NEVER HAD ANY COMPLAINTS, BUT WOULD INVESTIGATE. I HAD JUST PURCHASED THE CAR "CERTIFIED" 2 MONTHS AGO. NOT SOMETHING THEY CHECK DURING CERTIFICATION PROCESS. *TR

8/9/2014

THE DRIVERS SIDE SEAT BELT JUST LOCKED UP AND WILL NOT COME BACK OUT, TOOK IT TO THE DEALER AND THEY WANT 623.00 TO REPLACE IT ARE YOU KIDDING ME ?? PAID 19,000 FOR THE CAR LESS THEN A YEAR AGO SO I TRY TO GOOGLE THIS PROBLEM AND IT SAYS IF I TRY TO FIX IT MYSELF THE AIRBAGS COULD BE SET OFF REALLY ?? I GUESS I'LL JUST HAVE TO LISTEN TO THE ANNOYING DING DING DING EVERY 2 MINS WHILE DRIVING NO BIGGY THANKS FORD THERE SHOULD BE A RECALL ON THE SELTBELTS. *TR

11/22/2014

TL* THE CONTACT OWNS A 2011 FORD FLEX. WHILE AT THE DEALER FOR UNRELATED SERVICE, THE TECHNICIAN DIAGNOSED THAT THE REAR TIE RODS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 47,000.

5/13/2015

TL* THE CONTACT OWNS A 2011 FORD FLEX. THE CONTACT STATED THAT THERE WAS UNEVEN TIRE TREAD WEAR TO THE TIRES. THE CONTACT STATED THAT THE SET OF TIRES WERE REPLACED TWICE. THE CONTACT STATED THAT THE FAILURE WAS DUE TO A MECHANICAL DESIGN OF THE VEHICLE'S SUSPENSION SYSTEM, WHICH CAUSED THE UNEVEN WEAR OF THE TIRES. THE CONTACT STATED THAT THE SUSPENSION SYSTEM WAS POORLY DESIGNED THAT IT WAS IMPOSSIBLE FOR THE TIRES TO REMAIN BALANCED OR ALIGNED. THE VEHICLE WAS TAKEN TO TOM HOLZER FORD DEALER LOCATED AT: 39300 W 10 MILE RD, FARMINGTON HILLS, MI 48335, (248) 474-1234, WHERE THE VEHICLE WAS DIAGNOSED. THE CONTACT WAS INFORMED THAT THE MECHANIC WAS UNABLE TO FIND A FAULT OR EVEN A FAILURE WITH THE DESIGN OF THE VEHICLE THAT WOULD HAVE CAUSED THE UNEVEN WEAR WITH THE TIRES. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND NOTIFIED OF THE FAILURE. THE MANUFACTURER REFERRED THE CONTACT TO CALL NHTSA TO FILE A COMPLAINT. THE APPROXIMATE FAILURE MILEAGE WAS 73,500.

12/13/2017

TL* THE CONTACT OWNS A 2011 FORD FLEX. WHILE DRIVING, THE VEHICLE SUDDENLY SWITCHED INTO 'LIMP MODE' AND THE SPEED WOULD NOT EXCEED 20 MPH. THE VEHICLE WAS TOWED TO STAR FORD (1101 S. VANN BLVD, GLEN DALE, CA) WHERE IT WAS DIAGNOSED THAT THE THROTTLE BODY WAS FAULTY AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 56,000. THE VIN WAS INVALID.

1/2/2019

TL* THE CONTACT OWNS A 2011 FORD FLEX. THE CONTACT STATED THAT THE CRUISE CONTROL FUNCTION FAILED TO DISENGAGE WHILE DRIVING AT ANY RATE OF SPEED. THE VEHICLE WAS NOT DIAGNOSED BY A DEALER. THE CONTACT WAS AN INDEPENDENT MECHANIC AND DIAGNOSED THAT THE COMPUTER FAILED TO FUNCTION PROPERLY. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 160,000.

1/4/2019

Fuel pump failure shut down engine in seconds on the freeway and left us stranded on the freeway with highspeed traffic. Problem confirmed by the dealer. Vehicle inspected by the manufacturer. No warning, engine just lost power on the freeway.

7/5/2021