2022 Ford Explorer Owner Complaints

Ford released a bulletin - 22S27- to all dealers to immediately stop demo/delivery for all new Explorers in stock as of 4/19/22. At issue is a possibility of a fractured bolt that causes the differential to separate and cause "severe vibration" rendering the vehicle disabled. No fix was mentioned other than a software update possibly by the end of June 22 (2d qtr). This is serious if dealers are told to stop delivery! I just got mine in the beginning of April. Ford needs to step up and address this to ALL owners and not just dealers. It appears that Ford is waiting for failure of the parts before allowing any repairs. So far, only software is mentioned which supposedly throttles the engine to avoid putting stress on the rear end. This of course does NOT address the physical issue with a fractured bolt. Apparently, Ford redesigned the differential to use only one bolt vs two they had used earlier. Please pursue this as soon as possible with Ford to make them put out an emergency recall to resolve this very serious defect in manufacturing. Normally, recalls are for something that can be addressed eventually based on reported issues. However, there have not been that many incidents. For Ford to issue this notice to dealers indicates the seriousness or expected seriousnes. Thank you for your attention!

4/20/2022

This is my second submission. I will continue to submit to attempt to have NHTSA find out why FORD will only offer a software tweak to fix a very dangerous physical issue with all 20-22 Ford Explorers. Ford provided Advance Notice 22S27 to dealers dated 4/19/22 advising them to STOP delivery of any in stock Explorer due to a possible bolt fracture on the rear subframe which if cracked will disable the vehicle. Their "fix" is a software update that will reduce power to avoid acceleration which will put stress on the bolt. Ford decided to remove the second bolt from all the Explorers which subsequently will put stress on the one bolt they left intact. Ford needs to recall and put that bolt back on the subframe as the vehicle was originally designed to have. Please, please address this issue with Ford to make them fix the physical issue!

4/23/2022

Purchased car 5/31/22 from Apple Ford, 8800 Stanford Blvd, Columbia MD 21045. Started hearing sounds of rodent infestation 2 days later. Sporadic scurrying sounds that seemed to be coming from metal frame area above headliner in the car. Have recorded the sounds and attempted to share this verification of infestation with dealership, to no avail. As disabled vet w/anxiety/ptsd, scurrying sounds are unnerving, rodents are known to cause wiring damage which affects vehicle safety, sudden emergence of rodents when operating vehicle is additional safety hazard to myself, my passengers and others. Dealership removed headliner and stated no indication of rodents found. I repeatedly notified dealer the sound is one of clawing/scurrying on metal and that I have video evidence that verifies rodent infestation. So far, there are no warning lights, etc or other symptoms of the problem.

6/22/2022

On July 10th, 3:45 pm, after being parked in a parking lot for an hour in the sun, I opened the rear driver side door, the moonroof made a "pop" sound, then glass showered down. The glass popped UP, not down, and we were not in motion. Nor had we heard any impacts while driving at any time previously.

7/19/2022

The contact owns a 2022 Ford Explorer. The contact stated while driving at various speeds, the Forward Collision Avoidance system activated without incident. The contact also stated that the Back Over Prevention camera would display several errors while in use. Additionally, the thermostat would indicate the wrong vehicle temperature causing the engine hot warning message to appear on the instrument panel. The thermostat and the Back Over Prevention camera sensors were both replaced. The Forward Collision Avoidance sensors were also replaced; however, the failure returned a month after repair. The manufacturer had been notified of the failure. The vehicle had yet to be repaired. The failure mileage was 7,700.

8/22/2022

APIM Module failure at 148 miles on a brand new 2022 Explorer XLT. SYNC display went black. No response to touch. No warning lamps or alerts. Radio still plays and can be controlled by steering wheel controls. Contacted dealer and they said to disconnect negative battery terminal for more than 30 minutes. Performed requested action. Display is still dark. No reverse camera or safety (ADAS) functions. Took it to dealer again and they ran diagnostics to determine APIM module failure. So now I have a brand new Explorer with reduced safety features and no center console display. I cannot control any ADAS or radio features. Dealer has no estimated timeline for repair. Dealer also stated that they are getting APIM module failures DAILY.

8/23/2022

On four occasions over the past 30 days the vehicle has simply lost power while driving. No acceleration and the vehicle coasts to a stop and will not restart. On a few occasions it restarted after some time. Just shutdown while driving down the road. The third time it happened we took to the dealer and they claimed to fix a fuel pump module. It happened again a few days later. Took it back to the dealer and they claimed it was just low on gas even though it’s happened four times and there was gas in the tank. Took it home from the dealer a second time and simply ran it in the driveway for ten minutes and the engine stopped. Tried a second time and same result. Wouldn’t start again for 10 minutes.

6/28/2022

The contact owns a 2022 Ford Explorer. The contact stated that while driving at various speeds, the engine randomly disconnected from the transmission and the vehicle started idling while losing motive power while attempting to accelerate. During the failure the message "Brake Applied; Power Reduced" was displayed. The contact indicated that the failure occurred on six separate occasions and lasted approximately four minutes each time. The vehicle was taken to the local dealer who replaced the brake sensors, but the failure continued to occur. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 1,200.

11/3/2022

The contact owns a 2022 Ford Explorer. The contact stated while driving at various speeds, the Forward Collision Avoidance system activated without incident. The contact also stated that the Back Over Prevention camera would display several errors while in use. Additionally, the thermostat would indicate the wrong vehicle temperature causing the engine hot warning message to appear on the instrument panel. The thermostat and the Back Over Prevention camera sensors were both replaced. The Forward Collision Avoidance sensors were also replaced; however, the failure returned a month after repair. The manufacturer had been notified of the failure. The vehicle had yet to be repaired. The failure mileage was 7,700.

8/22/2022

The contact owns a 2022 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V022000 (Back Over Prevention) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated while driving 15 MPH, the vehicle hesitated while accelerating and lost motive power. No warning light was illuminated. Additionally, the rearview camera was inoperable while reversing. The contact stated that the front driver's side seat inadvertently moved towards the steering wheel while driving. The headlights inadvertently turned off while driving at night. The contact stated that the transmission also failed to shift into gear. The vehicle was towed to the dealer, where it was diagnosed with unknown electrical failures due to faulty programming. The dealer confirmed that parts were not available to perform the recall repair. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was 1,800. VIN tool confirms parts not available.

5/30/2023

The contact owns a 2022 Ford Explorer. The contact stated that while driving at various speeds, the engine randomly disconnected from the transmission and the vehicle started idling while losing motive power while attempting to accelerate. During the failure the message "Brake Applied; Power Reduced" was displayed. The contact indicated that the failure occurred on six separate occasions and lasted approximately four minutes each time. The vehicle was taken to the local dealer who replaced the brake sensors, but the failure continued to occur. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 1,200.

11/3/2022

while waiting on red lights and brake pedal has applied pressure the car will still keep rolling forward. Car is new less then 30 days. Dealership confirmed andhas had my vehicle over 50 days. Dealership will not provide me a service record to date after multiple requests in writing and verbally. Car dropped off at dealership 10/24 and to date is still there 12/10. pursuing lemon.

12/10/2022

Ford released a bulletin - 22S27- to all dealers to immediately stop demo/delivery for all new Explorers in stock as of 4/19/22. At issue is a possibility of a fractured bolt that causes the differential to separate and cause "severe vibration" rendering the vehicle disabled. No fix was mentioned other than a software update possibly by the end of June 22 (2d qtr). This is serious if dealers are told to stop delivery! I just got mine in the beginning of April. Ford needs to step up and address this to ALL owners and not just dealers. It appears that Ford is waiting for failure of the parts before allowing any repairs. So far, only software is mentioned which supposedly throttles the engine to avoid putting stress on the rear end. This of course does NOT address the physical issue with a fractured bolt. Apparently, Ford redesigned the differential to use only one bolt vs two they had used earlier. Please pursue this as soon as possible with Ford to make them put out an emergency recall to resolve this very serious defect in manufacturing. Normally, recalls are for something that can be addressed eventually based on reported issues. However, there have not been that many incidents. For Ford to issue this notice to dealers indicates the seriousness or expected seriousnes. Thank you for your attention!

4/20/2022

This is my second submission. I will continue to submit to attempt to have NHTSA find out why FORD will only offer a software tweak to fix a very dangerous physical issue with all 20-22 Ford Explorers. Ford provided Advance Notice 22S27 to dealers dated 4/19/22 advising them to STOP delivery of any in stock Explorer due to a possible bolt fracture on the rear subframe which if cracked will disable the vehicle. Their "fix" is a software update that will reduce power to avoid acceleration which will put stress on the bolt. Ford decided to remove the second bolt from all the Explorers which subsequently will put stress on the one bolt they left intact. Ford needs to recall and put that bolt back on the subframe as the vehicle was originally designed to have. Please, please address this issue with Ford to make them fix the physical issue!

4/23/2022

Upon cold start exhaust burns blue smoke. Vehicle was taken to dealership and diagnosed with a bad turbo seal, resulting in motor being removed and turbo replaced on passenger side at 2865 miles. Now a 6439 miles the drives side turbo seal is causing the same issue, blue smoke pouring out of the exhaust on cold starts. Car is driven with care and not abused in anyway. Other owners of the same version of this vehicle with two turbos are also experiencing the same issue. For both environmental and safety reasons, these engines should be recalled and inspected for this premature failure.

5/18/2023

This vehicle is used as a law enforcement vehicle. The officer was attempting to make a traffic stop on a speeding motorcycle. The officer turned around and accelerated relatively fast considering the speed and potential to not stop. When the pedal reached its maximum downward position, it just snapped off. The pedal appeared to only be connected by two small plastic rings which broke off. see the attached photos.

5/30/2023

The contact owns a 2022 Ford Explorer. The contact stated that while driving approximately 30 mph when another vehicle suddenly pulled in front of their vehicle causing them to hit the driver's side of their vehicle. The contact's vehicle had damage to the front bumper and passenger side of the vehicle. The airbags did not deploy. The seat belt failed to lock causing the contact to slam into the steering wheel. The contact injuries to their left shoulder, left foot, head, neck, back, and stomach area. Medical attention was needed. A police report was filed. The vehicle was able to be driven away. The vehicle had not been taken to the dealer. The vehicle had not been diagnosed or repaired. The manufacturer was made aware of the failure and referred them to NHTSA. The approximate failure mileage was 12,994.

5/24/2023

The contact rented a 2022 Ford Explorer. The contact stated that while her husband was driving approximately 65 mph, attempting to slow down, he crashed into a deer. There were no warning lights illuminated. The passenger-side front knee air bag was partially deployed. The passenger sustained bruising to her lower leg. There was a plastic substance released from the air bag which cut her ankle. The passenger was taken to the hospital where medical attention was provided. The vehicle was towed to a tow lot. A police report was filed. There were no reported fire. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 36,000. The VIN was not available.

7/7/2023

The windshield just cracked on its own no rock hit it. I rolled down side window to order food and when I rolled it up it spread all over and now leaking inside windshield. Also driving with side windows down the windows vibrate very shaky it doesn’t do that in any other vehicle f150 doesn’t vibrate at all.

4/19/2022

The contact owns a 2022 Ford Explorer. The contact stated while driving at various speeds in the rain, the windshield wipers were engaged but failed to operate as needed. The contact stated that the windshield wipers were not wiping water off the windshield as the rubber on the wiper blades were defective. The dealer was notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and advised the contact to report the failure to the NHTSA Hotline. The failure mileage was approximately 500.

11/21/2022

The contact owns a 2022 Ford Explorer. The contact stated while starting the vehicle, the steering wheel started moving independently from side to side, without warning. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was 207,000.

2/1/2023

The steering wheel moves back and forth by it's self.

2/1/2023

While at a gas station I opened the hood to check the oil, and the hood folded backwards far enough to contact, and destroy the windshield. My wife was cleaning the windshield at the time, and narrowly avoided having her hand/forearm severely injured by the hood. This is not supposed to happen. Whatever mechanism that is meant to prevent an incident like this was either defective, or non existent.

7/11/2022

Today, in my 2 month old 2022 Ford Explorer ST. The latch that holds/locks the hood (over engine) broke while driving 25 mph on city street and the hood smashed into my front windshield. I have never opened the hood since purchasing the vehicle and the hood ajar light never lite up until after it smashed into my windshield. I took the car to Ford Service and they are deferring responsibility. Even if I wanted to open the hood, I would have to pull the open lever upwards six inches twice to open (which I never did). And even if I accidently opened the hood, the door ajar light should have turned on, which it did not. This was very scary and I am very fortunate I did not run into another vehicle or object since it blocked all viability.

7/29/2022

Navigation System started to re route my waypoint making me go to a location that was not enter in the system. Car has been access remotly apparently by the ford pass app. my location has been disclose and my security put at risk several times. Automatic Emergency Braking will activate at any moment even when not necessary. there is a big security risk and concerns on ford pass app and ford security system is totally vulnerable. car is been inspected by the insurance company Car unsafe to drive Car was taken to ford dealership and they where unable to identify the issues. after that car was taken to a insurance location for deep inspection.

10/5/2022

Ford Explorer Pre-Collision (Forward Collision) not worked properly to detect the car and apply the brakes. While i am driving Ford Explorer 2022 XLT vehicle came from Right side and the Explorer did not recognized the Vehicle (Jeep Wrangler) to apply the brakes. This incident happend on June 4, 2023.

6/30/2023

while waiting on red lights and brake pedal has applied pressure the car will still keep rolling forward. Car is new less then 30 days. Dealership confirmed andhas had my vehicle over 50 days. Dealership will not provide me a service record to date after multiple requests in writing and verbally. Car dropped off at dealership 10/24 and to date is still there 12/10. pursuing lemon.

12/10/2022

Ford explorer didn’t recognize the vehicle coming from right side and it didn’t applied emergency brakes as well as it didn’t show any forward collision alert also.

7/8/2023

In late October, 2022, when reversing in my driveway, I hit a tree. The rear camera alert system did not notify me of the presence / closeness of the tree (lived here almost 6 years, should know of tree but heavily rely on the camera and alerts to let me know if I'm too close). On another day, my husband was in the car with me and as I was reversing - he said "your alert didn't go off, this is probably why you hit that tree." I was unaware until today (1/30) that there is an active recall on my car for this issue. I had the damage fixed in November at Gerber Collision Center in Sebastian FL (Micco Rd). The cost of the fix was $2046 out of pocket (did not claim through insurance). Rear-driver side lamp, bumper, quarter panel. Invoice for repairs is included for detail in what all needed to be fixed. Pictures are not great and are after we taped the light on.

1/30/2023

Vehicle is as purchases brand new in august 2022. After a few months when engaging reverse, there is a lag time of 3-10 seconds. The reverse screen in dash does not engage as well. Local dealer “fixed” in February 2023 at roughly 5k miles. Issue has returned. When brought to dealer beginning of May 2023. We were informed they would not work on it as it’s a known issue with no fix. Issue is creating problems when attempting parallel parks, k-turns, parking, anything to do in the road requiring timliness and safe execution of parking. When vehicle has the lag time it is not in gear and wil roll if on an incline.

5/21/2023

The passenger side front seatbelt was not bolted to anchor.

5/11/2022

During a 2000 mile road trip, the front passenger seatbelt was nearly cut through at the point where the seatbelt exits the tensioner above the passenger's right shoulder. The location of the cut along the length of the webbing aligns with the position of the webbing when the seatbelt was in use by the front passenger. Based upon the location and nature of the cut, it appears that some surface within the assembly was sharp enough to cut through the section of belt. There were no injuries associated with this incident. The vehicle was parked as soon as we reached our destination and no passengers are allowed to sit in the front right passenger seat until the issue is corrected. The seat belt tensioner / pre-tensioner assembly was examined by the Ford Dealership in Taber, AB, Canada on 22 DEC 2022. The dealership confirmed that the issue was a warranty repair, but they were unable to provide a replacement part in the amount of time we had left in Taber as we were still in Transit. When we reached our destination in Pierceland, SK, I ordered the replacement tensioner from / through the nearest Ford dealership (Cold Lake, AB). I have an appointment to have seatbelt assembly replaced tomorrow (27 DEC 2022) at that dealership. The seat belt tensioner assembly

12/26/2022

APIM Module failure at 148 miles on a brand new 2022 Explorer XLT. SYNC display went black. No response to touch. No warning lamps or alerts. Radio still plays and can be controlled by steering wheel controls. Contacted dealer and they said to disconnect negative battery terminal for more than 30 minutes. Performed requested action. Display is still dark. No reverse camera or safety (ADAS) functions. Took it to dealer again and they ran diagnostics to determine APIM module failure. So now I have a brand new Explorer with reduced safety features and no center console display. I cannot control any ADAS or radio features. Dealer has no estimated timeline for repair. Dealer also stated that they are getting APIM module failures DAILY.

8/23/2022

When the car is put into reverse. The reverse camera display is delayed in showing or shows a blue screen in lieu of the rear view. It started to happen around the 26 or 28,000 mile mark.

9/25/2024

APIM Module failure at 148 miles on a brand new 2022 Explorer XLT. SYNC display went black. No response to touch. No warning lamps or alerts. Radio still plays and can be controlled by steering wheel controls. Contacted dealer and they said to disconnect negative battery terminal for more than 30 minutes. Performed requested action. Display is still dark. No reverse camera or safety (ADAS) functions. Took it to dealer again and they ran diagnostics to determine APIM module failure. So now I have a brand new Explorer with reduced safety features and no center console display. I cannot control any ADAS or radio features. Dealer has no estimated timeline for repair. Dealer also stated that they are getting APIM module failures DAILY.

8/23/2022

I was backing up at low speed (less than 1 mph) to park by gently letting my foot off the brake to back. I was using the rear backup camera to gauge how far I could go back without striking the vehicle behind me. The screen showed video that I was still several feet away from the vehicle behind me when I felt a sudden bump. I stepped on the brake hard to ensure I was no longer moving but the camera still showed several feet between my rear bumper and the vehicle behind me. I put the vehicle in park and got out to verify that I had struck the vehicle behind me. I had. I returned to the driver’s seat, put the vehicle back in reverse to see what the camera showed and now it appeared on the screen that my bumper was touching the vehicle behind me. The video on the screen had absolutely froze while I was backing, which contributed to me making an error in judgement while backing, causing me to strike the vehicle behind me. The DuPage County Sheriff’s Office (Illinois) completed a crash report. SOPC23-08519

6/26/2023

The contact owns a 2022 Ford Explorer. The contact stated that while the vehicle was stationary and idling in a pharmacy drive-thru line with the auto hold parking feature activated, the vehicle suddenly experienced unintended acceleration and drove forward driving over a median divider and crashing into a parked vehicle. The contact indicated that the auto-hold parking feature was activated but malfunctioned. During the crash, no air bags were deployed and no injuries were reported. A police report was taken at the scene and the vehicle was towed away. The cause of the failure was not yet determined. The manufacturer and local dealer were notified of the failure. The failure mileage was 6,500.

11/22/2022

When using my Cruise Control the speed jumps up to 75-85 mph without my input. For example, when I set the cruise control to 55 it suddenly jumps up to 75 or 85 mph on its own. This happens when the speed signs on the road change. This past week I used my cruise control for a long trip. I was on a highway that changed the posted speed from 55 to 65 mph. The cruise control suddenly went from the posted speed of 55 mph to 85 mph. This is very concerning! It has happened several times and I can no longer use the cruise controller. I have approximately 5,000 miles on my vehicle .

3/27/2023

The contact owns a 2022 Ford Explorer. The contact received notification of NHTSA Campaign Number: 22V088000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The local dealer was contacted and an appointment was scheduled to determine whether the vehicle was safe to drive. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and informed the contact that they were focusing on repairing the unsold vehicles first. The manufacturer referred the contact to the NHTSA for assistance. The contact stated upon refueling in the vehicle, the fuel shut-off valve failed to stop fuel from being pumped when the gas tank was full, causing a fuel leak. The failure mileage was approximately 1,400. Parts distribution disconnect.

4/28/2022

The contact owns a 2022 Ford Explorer. The contact stated that while the vehicle was parked on an incline, and with a quarter tank of fuel in the vehicle, the vehicle failed to start. There was no warning light illuminated. The vehicle was towed to the local dealer. The cause of the failure was not yet determined. The manufacturer was notified of the failure. The failure mileage was 20,000.

3/18/2024

The contact owns a 2022 Ford Explorer. The contact stated that while operating the vehicle and attempting to roll up the window, the rear passenger’s side window failed to operate. The vehicle was taken to an independent mechanic who diagnosed that the wiring harness needed to be repaired, the window was very hot, and the battery needed to be replaced. The dealer was not contacted. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 7,420.

5/2/2022

The contact owns a 2022 Ford Explorer. The contact stated that while the vehicle was parked and idling with the air conditioner activated, the rear hatch door window suddenly shattered. The contact stated that during the failure, there was no impact on the window to cause the shattering of the window. The cause of the failure was not yet determined, and the vehicle was not yet repaired. The local dealer and manufacturer were notified of the failure, but no assistance was provided. The failure mileage was 28,000.

6/24/2024

Pirelli Scorpion All season tires 275/45 R21. Tire completely "blew out" while driving 30 mph on a main road. There was no obvious hissing sound commonly when running over an object. There was an explosive sound and within seconds had a complete flat. The vehicle did get damaged on the inside tire well along with bumper damage/Crack.

2/23/2023

Tire: 275/45/r21 110w all season Reported to authorized dealer (ford dealership) back in November 2024. Authorized representative from Pirelli came out this month to dealership regarding issue. No concern for safety whatsoever. Rep. Only offered maybe 25% that’s with purchasing new set of tires and sending my current tires back. Tires are falling apart in chunks.

1/23/2025

When using my Cruise Control the speed jumps up to 75-85 mph without my input. For example, when I set the cruise control to 55 it suddenly jumps up to 75 or 85 mph on its own. This happens when the speed signs on the road change. This past week I used my cruise control for a long trip. I was on a highway that changed the posted speed from 55 to 65 mph. The cruise control suddenly went from the posted speed of 55 mph to 85 mph. This is very concerning! It has happened several times and I can no longer use the cruise controller. I have approximately 5,000 miles on my vehicle .

3/27/2023

On [XXX] my 2022 Ford Explorer was involved in a collision during my morning commute to work. On [XXX] while stopped at a stoplight across from Sheetz, with the auto brake hold engaged for a minute or two already, my vehicle accelerated forward into the vehicle in front of me. The impact was so sudden that the driver of the vehicle I collided with thought I had been rear ended. While I had contacted my insurance company (Erie Insurance) regarding the collision, I had also reached out to my service center, Laurel Ford (Windber, PA), concerning the incident. Because of my concerns with the auto brake hold and Copilot system with the collision, they had me bring it in on 16 September to run diagnostics. Later that day on the 16th, I had received a phone call from the service tech letting me know that he did find system error logs approx. 40 minutes prior to the collision. He let me know that he was going to keep diagnosing and will be most likely reaching out to his next level service support. The next day on the 17th, the service technician called me back to let me know that when he reported the issue to his support center he was advised to park the vehicle, not let it be driven, and for the service manager to get with me to file a report (Ford reference # XXX). Since that time, nothing more has happened with my Explorer. I have both the current manufacturer's warranty and Ford Protect warranty. The most recent update from Laurel Ford was that Ford Corporate said a Field Service Engineer needed to evaluate the issue. The Laurel Ford Service Center is no longer getting replies from corporate and has a regional manager involved, with no luck so far. It has been an extreme burden and has been beyond stressful using my wife's car for work, l'm in the military and my base is over 40 miles away, while she relies on friends/family to get to her work and also make sure that both of my kids get to their activities. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

1/3/2025

The sun roof/ moon roof shattered while going down the road at 70 MPH. Glass showered down on my wife as she was traveling until she could stop and get the glass cleaned up.

3/27/2023

Driving on the highway and the sunroof exploded. No one around and no overpass. No signs of impact or object in or near vehicle. No other damage to vehicle.

5/19/2024

The contact owns a 2022 Ford Explorer. The contact stated while driving 60 MPH, the tires began to make a thumping sound and the steering wheel started to vibrate. The vehicle was towed to a dealer where it was diagnosed that the axle seal needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 26,000.

9/21/2023

The contact leased a 2022 Ford Explorer. The contact stated while driving 75 MPH, the vehicle started shuddering uncontrollably and was making an abnormal grinding sound. The contact was able to veer to the side of the road. The vehicle was towed to the dealer, where it was diagnosed that the front driver's side axle was fractured. The dealer informed the contact that the failure was unprecedented. The vehicle was not repaired. The manufacturer was notified of the failure and a case was opened. The failure mileage was approximately 15,629.

11/7/2023

Purge valve has now failed twice since owning the vehicle (1 year and 5 months old). First purge valve went out when the vehicle was only 4 months old (Oct 2022). Second purge valve went out at 1 year old (June/July 2022). The main concern that I am reaching out for- Drivers side headlight - a small bird flew into the headlight and cracked it. Placed a hole in the headlight, causing water to get in and stop working. There is no way that a headlight should crack from a bird flying into it.

11/30/2023

An alert often shows up on the dashboard "check headlamp system. See manual". This is occasionally associated with one headlamp not working. This happens on and off. The alert spontaneously turns on, may stay for days or weeks and then spontaneously turns off. Ford dealership service were unable to fix this problem. This has happened multiple times since we purchased the car

1/9/2025

The contact owns a 2022 Ford Explorer. The contact stated that while attempting to reverse, the vehicle failed to move, after which the contact became aware that the parking brake had failed to properly disengage. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 40,000.

3/18/2024

The contact owns a 2022 Ford Explorer. The contact stated that the vehicle was experiencing an unintended activation of the electric parking brake while the vehicle was in park(P). The contact stated upon starting the vehicle and shifting into gear, the message "Park Brake Fault - Service Now" was displayed, and the vehicle made an abnormally loud beeping sound and then failed to respond. The contact stated that upon pressing the Push to Start button for several minutes, the vehicle became drivable; however, the failure recurred upon parking the vehicle. The vehicle was taken to the dealer, where it was determined that the failure could be related to the electric parking brake sensor or to the brake booster. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the VIN was not included in a related recall. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 45,700.

2/28/2025

The contact owns a 2022 Ford Explorer. The contact stated that while his wife was driving at approximately 50 MPH, the hood came ajar and shattered the front windshield. The driver heard two abnormal beeps before the failure. There was glass on the interior of the vehicle. There were no reported injuries. The driver was able to continue driving. There were no warning lights illuminated. The contact noticed that the safety latch was missing. The vehicle was taken to the local dealer, who informed the contact that the latch had to be pulled twice to unlock. The vehicle was not diagnosed or repaired. The dealer referred him to the body shop. The manufacturer was contacted and declined a claim for the repair. The failure mileage was approximately 18,000.

4/15/2024

The contact owns a 2022 Ford Explorer. The contact stated that while driving 35 MPH, the hood suddenly opened and struck the windshield, causing the windshield to crack. The contact stated that the month prior to the failure, the hood had been opened for a routine oil change. There were no warning lights illuminated. There were no reported injuries. The vehicle was taken to a body shop. The local dealer was contacted and referred the contact to the manufacturer for assistance. The vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 45,000.

4/24/2025

There’s no accident . The passenger front recliner is stuck in the reclined position ( laying all the way back ). In the seated position , facing forward , the left side of the seat is stuck . The right side near the passenger door wants to come up, but not the left side. The seat is laying down flat in the reclined position . This is a safety issue .

7/1/2024

Seat warning module failed. When unbuckling seatbelt car does not recognize you unbuckled, therefore the airbag system does not recognize which seats are occupied. This would also cause a safety concern as you do not have to buckle the seatbelt with no warning or alert there is an issue. Car has been at Ford dealer for service for a month with them failing to find any other vehicle that they can replicate the problem. This is one Ford dealer, but it should be something that is investigated as it might be easily overlooked. Car has been in the dealership for the last month with no answers from Ford or resolution to the safety issue, following Federal regulations the dealer will not release the car back to us as it has a safety system malfunctioning.

1/8/2025

Rear liftgate intermittently and randomly opens when standing or walking near the rear, the rear left, or the rear right of the vehicle. In each situation the key is on my person (pocket or purse) and the key fob is not being engaged in any manner. I purchased my vehicle in January 2022 and it has happened more than a dozen times since I purchased it. I have concerns if it opens and I don't realize it and when my pets are in the back in case they were to jump out. It doesn't seem to matter whether the vehicle is locked or unlocked. It has happened while pumping gas and the vehicle was unlocked, it has happened while walking to the driver side rear passenger door to retrieve an item when the car was locked. On more than one occasion, it has randomly closed on me when standing under the liftgate while removing items from the back of the vehicle and hit me on the head. While researching this problem, it seems to be a common problem with any vehicle that has an electronic liftgate going back many many years. Multiple makes and models have reportedly had the same issue. I don't want it to open while driving as one other person reported as happening to them. The dealership had no idea how to fix the problem.

6/9/2022

The contact owns a 2022 Ford Explorer. The contact stated while his fiancé was at a complete stop, the auto-hold mode designed to maintain the brake pedal depressed was engaged. However, the vehicle accelerated unintendedly and crashed into the rear of the vehicle in front of him. There was no warning light illuminated. The air bags did not deploy. The contact stated it was a minor crash. The contact's fiancé did not sustain any injuries. The driver of the other vehicle sustained unknown injuries and sought medical assistance. A police report was filed. The contact's fiancé was able to drive the vehicle. The dealer was not notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The contact was awaiting a call back from the manufacturer. The failure mileage was approximately 9,980.

8/12/2022

The contact owns a 2022 Ford Explorer. The contact stated while driving at various speeds, the Forward Collision Avoidance system activated without incident. The contact also stated that the Back Over Prevention camera would display several errors while in use. Additionally, the thermostat would indicate the wrong vehicle temperature causing the engine hot warning message to appear on the instrument panel. The thermostat and the Back Over Prevention camera sensors were both replaced. The Forward Collision Avoidance sensors were also replaced; however, the failure returned a month after repair. The manufacturer had been notified of the failure. The vehicle had yet to be repaired. The failure mileage was 7,700.

8/22/2022

In late October, 2022, when reversing in my driveway, I hit a tree. The rear camera alert system did not notify me of the presence / closeness of the tree (lived here almost 6 years, should know of tree but heavily rely on the camera and alerts to let me know if I'm too close). On another day, my husband was in the car with me and as I was reversing - he said "your alert didn't go off, this is probably why you hit that tree." I was unaware until today (1/30) that there is an active recall on my car for this issue. I had the damage fixed in November at Gerber Collision Center in Sebastian FL (Micco Rd). The cost of the fix was $2046 out of pocket (did not claim through insurance). Rear-driver side lamp, bumper, quarter panel. Invoice for repairs is included for detail in what all needed to be fixed. Pictures are not great and are after we taped the light on.

1/30/2023

Since "fixing" my vehicle with retrofitted 2nd row HVAC controls, the 2nd row heating is unable to be controlled from the front, which means if you have a child in a car seat who can't reach the 2nd row controls you must reach behind while driving to adjust the heat. If you try to adjust from the front controls, it shuts off the overhead vents and only blows from one 3rd row floor vent, which doesn't provide much heat for the 2nd row passengers. The AC controls work properly when controlled from the front. I've taken my vehicle to Ford several times and they tried reprogramming, etc. and compared to other vehicles of the same model year and said they are functioning the same as mine. I believe this poses a serious safety risk as who is not going to attempt to reach back to provide some heat to a cold child?

3/8/2023

VEHICLE REAR AXLES CLICK WHEN YOU PLACE VEHICLE IN REVERSE AND DRIVE THIS IS THE CV AXLES BREAKING EVENTUALLY LEADING TO POWER LOSS.

8/3/2023

The plastic window switch has peeled, creating essentially a very sharp edge that has cut me and caused bleeding and pain. It is available for inspection and I have pictures. This is a problem known to Ford. The vehicle was dropped of at a Ford dealership, Crossley Ford Liberty, MO. The problem identified, but not covered under warranty.

9/21/2023

The contact owns a 2022 Ford Explorer. The contact stated that while driving at an undisclosed speed, the reverse mode did not function as needed. The contact stated that when the gear shifter was shifted to reverse mode, the vehicle rolled either forward or backwards and then hesitated. The vehicle was taken to the dealer, however the failure was not diagnosed. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 10,000.

3/6/2024

The contact owns a 2022 Ford Explorer. The contact stated while reversing, the rearview camera failed to display properly with a delay while shifting into gear. The vehicle was taken to the dealer where it was diagnosed with a hardware system failure which needed to be replaced. The vehicle was repaired but the failure persisted. The dealer stated that a known software system recall had been associated with the vehicle, but the VIN was not associated with the recall. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was unknown.

5/1/2024

The contact owns a 2022 Ford Explorer. The contact stated that the passenger’s side rear window failed to roll up. The contact stated that after inspecting the vehicle, as a certified engineer, the master control switch on the driver’s side door had remained in the down position allowing for the window to remain down. The plastic around the switch was warped, causing the switch to remain in a downward position to activate the button. The contact manually raised the window and disconnected the connector from the circuit board to allow all other windows to properly function. The dealer was contacted, and it was confirmed that the VIN was not under recall for the failure. The vehicle had not been taken to the dealer to be diagnosed or repaired. The manufacturer was made aware of the failure and a case was opened. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 43,000.

6/24/2024

No accident, I noticed strap fraying when inspecting the car seat. The lower car seat straps have fraying on them, rendering the car seat unsafe and unusable. My child will not be safe if a car crash would occur, she could potentially be released from the seat. It was reported to evenflo with pictures. They are claiming it is our fault and my 3 year old did it with something sharp. You cannot see the back of the straps as they enter the car seat. We do have photos of the proof. We also know there is an ongoing investigation into evenflo for this very reason.

8/22/2024

The contact owns a 2022 Ford Explorer. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that brake pedal was depressed. The vehicle was taken to the dealer where it was diagnosed with a failed valve body. The contact was informed that the valve body needed to be replaced. The vehicle was repaired under warranty. The failure reoccurred. The vehicle was taken to the dealer where it was diagnosed with a failed output speed sensor. The contact was informed that the output speed sensor needed to be replaced and recalibrated. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The manufacturer approved of the buyback; however, the contact stated that the Lemon Law requirement limited the ownership to two years. The failure mileage was approximately 39,793.

3/14/2025

The contact owns a 2022 Ford Explorer. The contact stated that while the vehicle was turned off, the contact was notified by the Ford App that the check engine warning light was illuminated and the message “Fuel Door Open" was displayed. The contact stated that the vehicle previously had a transmission software update due to the vehicle hesitating to accelerate while driving. Additionally, the speedometer intermittently failed to function as needed. The vehicle was taken to the dealer, who determined that there was water intrusion into the body control module fuse panel. The contact was informed that the battery and body control module fuse panel needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 61,500.

4/4/2025

The contact owns a 2022 Ford Explorer. The contact stated that while driving at 20-25 MPH, the brakes were applied, and the brake pedal fell off. The brake pedal was not responding. The vehicle increased in speed to 43 MPH. The contact maneuvered around an unknown vehicle to avoid an accident, but the unknown vehicle turned and crashed into the passenger-side quarter panel. The vehicle traveled off a curb and landed in a ditch. The contact and two passengers occupying the second-row seats and one child passenger occupying the third row in a car seat sustained bruises and cuts and were transported to the hospital. The air bags did not deploy. There was no fire. A police report was filed. There was an abnormal beeping sound detected. There were no warning lights illuminated. The vehicle was towed to a body shop. The vehicle was towed to the local dealer but was not diagnosed or repaired. The manufacturer was contacted, who opened a claim and declined to assist. The failure mileage was approximately 57,865.

5/5/2025

The contact owns a 2022 Ford Explorer. The contact stated that upon starting the vehicle, the check engine warning light illuminated and remained illuminated. Additionally, there was an abnormal rattling sound coming from the front end of the vehicle, and there was an abnormal gasoline odor inside the cabin of the vehicle. The vehicle was taken to a local independent mechanic to be diagnosed, and the contact was informed that the catalytic converter was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 72,378.

7/1/2025

The contact owns a 2022 Ford Explorer. The contact’s son started the vehicle and became aware that the "Cylinder Head Temperature Overheated" message was displayed on the instrument panel while the vehicle was parked in the driveway. The vehicle was towed to the dealer, who diagnosed that the engine and engine cooling system had failed due to water leaking into the turbo. The dealer stated that the sensor failed to identify and inform the driver that the engine was running hot. The contact became aware that the failure had occurred with the previous owner of the vehicle approximately 2 - 3 years ago. The contact was informed that the engine needed to be replaced, or the turbocharger could be replaced as a temporary repair. The vehicle was not repaired. The manufacturer was informed of the failure and opened a case. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 105,000.

7/28/2025