2023 Ford Explorer Owner Complaints

I purchased a new 2023 Ford Explorer and during the finance process I found out it had a rear back up camera recall . I wasn’t able to take possession of my vehicle . It’s been sitting on the car dealership lot where I bought it . I bought it May 26th and the repair still hasn’t been resolved !! I want my vehicle !! I’m making a substantial payment on a vehicle I can’t have !!!! Please resolve this ASAP !!!!

7/13/2023

At 36-42 mph the vehicle vibrates underneath, not the stearing wheel, it is clear something is not right. The vibration goes away when you hit 43 mph it smooths out and you dont feel it. No lights come on, I have had it checked and because there is no recall or a faulty light coming on or a sensor in my computer module, there is nothing Ford can do they say. They did tell me that Ford is aware of this as there are about 8 other vehicles they have seen that have this same issue. I am thinking possiibly the drive shaft is not balanced properly, I have done some research online and otheres have complained about this too. Hopeing this will be looked into further, hate the spend all this money on a vehicle and find that by driving it we are ruining something else and then have to spend more money to fix it or it casues someone to get into an accident. Please look into this, my vehicle is not the only one out there and it is brand new.

7/30/2023

I rented a 2023 Ford Explorer. I had many issues with the added safety features while renting it, ultimately resulting in an accident. Firstly, the lane keeping assist did not function properly. In construction zones, back roads, and during rainy weather, the vehicle would jerk very hard to one side of the other. Even after trying to shut off the lane keeping assist feature, it it would automatically turn back on. Luckily, most of those incidents would happen in low traffic areas. Until the final time it happened, resulting in a head on collision with another vehicle. Additionally, the screen that displayed the lane assist activity would go blank randomly while driving. Also. There was a constant issue with the a pop up screen saying to keep holding the steering wheel. Even when I would have both hands on the steering wheel, it would pop up, and sometimes, if it wouldn’t disappear in time, the vehicle would start to automatically brake and slow down the vehicles, even if I was going 70+ miles per hour. The last 12 hours of the vehicle rental drive time, the “keep hold of steering wheel” pop up would pop up more and more frequently. To the point where I would have to constantly let go of the steering wheel and re grab it over and over until it eventually disappear.

4/16/2023

I leased a brand new 2023 Ford Explorer. The day I was driving it home I noticed a distinct cracking/popping sound when I turned the steering wheel to the left while lifting my foot off the brake. It is not a series of pops. It’s just one pop when the wheel is turned. When I got home I took out the paper mat that was on the floor to make sure there were no other sounds in the car. The sound happens each time I am in my vehicle & it only happens when the wheel is turned to the left going less than 1 mph. I took it to a Ford dealership. The service advisor heard the sound when I drove a few feet & turned the wheel to the left in the parking lot. The service technician was able to reproduce the sound without driving at all. He turned the wheel, while in the park position, and reproduced it. There are no warning lamps. As of now, I have not been told what it is but it’s concerning knowing cracking sounds could be rack, steering, tie rod, ball joint or any number of steering or suspension problems. I’m now worried driving my new SUV.

8/3/2023

Every time i was traveling in sport mode, shifting was delayed & was very rough transition to next gear. Car was not accelerating or decelerating properly. Burning smell came from the engine. Car’s electrical momentarily went haywire. Wrench light came on. This happened within 18 hours of purchasing this NEW car. And several times over the subsequent week. Indicator light went on intermittently & so did same problems described above. My safety was put at risk because my car was not driving properly which caused distraction. I was confused about what to do. It also made it difficult to change lanes or speed up/slow down because it was jerky. The dealership i bought it from said a ford engineer came out to inspect the car & that several parts were ordered to fix it, including a battery for the electric motor & a wiring harness. They said it was a big issue and those parts were hard to come by, but i only learned this after 30+ days of the vehicle being under their control. I only dropped it off for a “test.” They did not make documentation of any of this work and would not release records to me. They also declined to release the car to me when i was tired of the lack of transparency. They said they couldnt give it back j til it was fixed but never provided work order with estimate or details of coverage. I never signed anything giving them permission to replace or repair the parts, especially because they would not disclose the ford engineer’s findings to me until a few weeks later after i threatened to invoke my rights under lemon law. They had already taken the car apart & ordered parts by then-without my informed consent.

11/29/2023

On 11/27/2023, my family and I were in this vehicle as I was driving on a side street. Suddenly the engine shut down while I was driving. I was fortunate enough to pull the car into a parking lot to be towed to a nearby Ford dealer. After a week of research the problem, they could not find anything wrong and returned the car to me. A week later, as I was driving to a major intersection, it shut down again. I called for a tow truck and was able to bring it to a Ford dealer nearby in Greer, SC. Again, they could not find out what the problem was and returned the car to me. I am currently driving the car but I am fearful for my life because I dont know of when this engine shut down would happen again? What if it could happen while I am driving in the middle of a major national highway? If it shuts down on a highway while an 18-wheeler truck behind me, I do not think that I will be alive to write this report. I urge your office to review this matter with the Ford corporation for me to return the car to them. Thank you, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

12/26/2023

The transmission was very difficult time trying to figure out how to start shifting gears, and when it did I felt very hard shifting. The engine revved up, struggled to rev up when accelerating, held gears, chugged, slipped, it felt extremely lazy, and hard shift. The RPMs were fluctuating like crazy. You slam on the accelerator the RPMs start going up then it starts fluctuating crazy.

3/25/2023

At 36-42 mph the vehicle vibrates underneath, not the stearing wheel, it is clear something is not right. The vibration goes away when you hit 43 mph it smooths out and you dont feel it. No lights come on, I have had it checked and because there is no recall or a faulty light coming on or a sensor in my computer module, there is nothing Ford can do they say. They did tell me that Ford is aware of this as there are about 8 other vehicles they have seen that have this same issue. I am thinking possiibly the drive shaft is not balanced properly, I have done some research online and otheres have complained about this too. Hopeing this will be looked into further, hate the spend all this money on a vehicle and find that by driving it we are ruining something else and then have to spend more money to fix it or it casues someone to get into an accident. Please look into this, my vehicle is not the only one out there and it is brand new.

7/30/2023

The transmission was very difficult time trying to figure out how to start shifting gears, and when it did I felt very hard shifting. The engine revved up, struggled to rev up when accelerating, held gears, chugged, slipped, it felt extremely lazy, and hard shift. The RPMs were fluctuating like crazy. You slam on the accelerator the RPMs start going up then it starts fluctuating crazy.

3/25/2023

At 36-42 mph the vehicle vibrates underneath, not the stearing wheel, it is clear something is not right. The vibration goes away when you hit 43 mph it smooths out and you dont feel it. No lights come on, I have had it checked and because there is no recall or a faulty light coming on or a sensor in my computer module, there is nothing Ford can do they say. They did tell me that Ford is aware of this as there are about 8 other vehicles they have seen that have this same issue. I am thinking possiibly the drive shaft is not balanced properly, I have done some research online and otheres have complained about this too. Hopeing this will be looked into further, hate the spend all this money on a vehicle and find that by driving it we are ruining something else and then have to spend more money to fix it or it casues someone to get into an accident. Please look into this, my vehicle is not the only one out there and it is brand new.

7/30/2023

The contact owns a 2023 Ford Explorer. The contact stated there was an unknown part loosened at the front of the vehicle. While driving at unknown speeds, there was an abnormal rattling noise detected from the strut that had become louder over time. There were no warning lights illuminated. The vehicle was taken to the local dealer, where the front-end bolts were tightened. The vehicle was repaired, but the failure recurred. The manufacturer was contacted, opened a case, and referred the contact to the NHTSA Hotline. The contact related the failure to NHTSA Campaign Number: 24V091000 (Suspension, Steering). The approximate failure mileage was 3,000.

3/4/2024

There is a load knocking noise coming from the front suspension. I have taken the vehicle in 3 times to Ford and after I drive off the lot the issue is gone. But after driving for a few days the issue returns. There is a loud clicking noise as well when you back up the vehicle coming from the front suspension.

4/5/2024

The contact owns a 2023 Ford Explorer. The contact stated that upon purchasing the vehicle, she was made aware that the VIN was included in NHTSA Campaign Number: 23V342000 (Back Over Prevention) however, the parts to do the recall repair were not yet available. The dealer confirmed that the parts were not available for the recall repair. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

8/10/2023

The contact owns a 2023 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V342000 (Back Over Prevention) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

8/11/2023

The contact owns a 2023 Ford Explorer. The contact stated while driving at an undisclosed speed, the seat belt warning light failed to illuminate while the seat belt was manually unlatched. The contact stated that the seat belt warning light was only illuminated during the initial start-up of the vehicle and then deactivated after the seat belt was latched. The vehicle was not taken to a dealer. The vehicle was not diagnosed nor repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 5,000.

1/10/2024

The seat belt minder is not working. it works when you are at park and dont put the seat belt and start driving. but if you are buckled, start driving and then while driving take the belts off, no warning sound is provided. this problem is not yet reported to the dealer. no warnings or problems noted prior.

6/3/2024

For a week before 3/19/24, the driver door made increasing crunching noises when opened and closed. On 3/20/24 the driver door would not open and was subsequently left at Dean Sellers Ford for diagnosis and repair. The dealer relayed that there was a repair advisory on this issue which related to closed investigation / action PE23-013. On 3/21/24, the repair was completed and paid even though Ford Motor has previously agreed to announce a recall by March 2024. As on 4/2/24, no recall notification has been announced or received.

4/1/2024

While driving the vehicle, I noticed a sound like something was flapping in the wind. I checked around and under the vehicle and noticed the bottom of the back bumper was loose. I took the vehicle to the dealership where it was purchased. They told me there was nothing broken or loose. They also told me the stabilizing piece that is usually on the bumper is taken off to install the hitch and nothing is put back on the bumper to secure it. The hitch on my vehicle was factory installed. This is a safety issue in that the bumper, or pieces of it, could break off while driving causing an accident or injury. In addition, the damage to my vehicle could be substantial.

9/22/2024

I rented a 2023 Ford Explorer. I had many issues with the added safety features while renting it, ultimately resulting in an accident. Firstly, the lane keeping assist did not function properly. In construction zones, back roads, and during rainy weather, the vehicle would jerk very hard to one side of the other. Even after trying to shut off the lane keeping assist feature, it it would automatically turn back on. Luckily, most of those incidents would happen in low traffic areas. Until the final time it happened, resulting in a head on collision with another vehicle. Additionally, the screen that displayed the lane assist activity would go blank randomly while driving. Also. There was a constant issue with the a pop up screen saying to keep holding the steering wheel. Even when I would have both hands on the steering wheel, it would pop up, and sometimes, if it wouldn’t disappear in time, the vehicle would start to automatically brake and slow down the vehicles, even if I was going 70+ miles per hour. The last 12 hours of the vehicle rental drive time, the “keep hold of steering wheel” pop up would pop up more and more frequently. To the point where I would have to constantly let go of the steering wheel and re grab it over and over until it eventually disappear.

4/16/2023

The lane assist system put the vehicle into a skid on snowy road with no markings on roadway. The vehicle is available to inspect but insurance company is pushing to pickup vehicle as it was totaled. The system put vehicle into a skid that resulted into going into the ditch and hitting a power pole. As far as we know nobody has looked into system failure we did report it to sheriff and insurance company. This is the first time the lane departure turned on a snow covered road

4/1/2024

-PARKING BRAKE IS AUTO ENGAGED 100% OF THE TIME AT START or WHILE SHIFTING OUT OF PARK or SHIFTING BETWEEN GEARS. DRIVE or REVERSE -TO DISENGAGE THE PARK BRAKE YOU HAVE TO DEPRESS THE ACCELERATOR PEDAL. -PRESSURE ON THE ACCELERATOR TO DISENGAGE IS INCONNSISTENT EVERY TIME. -VEHICLE LURCHES UNCONTROLLABLY WHEN RELEASING THE VEHICLE OFF THE EMERGENCY PARKING BRAKE SETTING. -THE JOLT OF THE VEHICLE FROM THE DEPRESS PRESSURE IS SO SIGNIFICANT AND DANGEROUS CAUSING THE RISK TO HITTING ANY PARKED VEHICLE WHILE PARALLEL PARKING OR HITTING STRUCTURE/GARAGE WHEN PARKING, JOLTING INTO TRAFFIC FROM A STOPPED/PARKED POSITION or TO PEOPLE WALKING NEAR THE VEHICLE WHILE TRYING TO MANIPULATE THE VEHICLE. -WHEN THE AUTO HOLD FEATURE IS TURNED ON, IT CAN BE ASSUMED TO BE ENGAGED BY PRESSING THE BRAKE PEDAL but IF THE PEDAL ISN'T ENGAGED WITH ENOUGH FULL PRESSURE THE AUTO HOLD WILL NOT FULLY ACTIVATE. IN NOTIFICATION WHEN ON IS IN SMALL GREEN TEXT THAT CAN BE EASILY MISSED/CONFUSED WITH THE GREEN SYMBOL SIMILAR IN SIZE TO THE GREEN AUTO HEADLIGHT SETTING IN THE SAME ZONE. THIS CAN CAUSE SOMEONE TO BELIEVE AUTO HOLD IN ENGAGED WHEN USING PERIPHERIAL VISION FOR THE INDICATOR QUE WITHOUT DIRECTLY TAKING EYES OFF THE FORWARD CONDITION. THIS GIVES THE DRIVER A FALSE CONFIDENCE TO REMOVE THEIR FOOT FROM THE BRAKE AND HAVE THE VEHICLE CREEP FORWARD AND CAN LEAD TO ACCIDENT OR INJURY.

7/17/2023

There seems to be two issues of concern; 1. Braking system .. when you are in your car, you can hear constant clicking from the engine and the brake light keeps turning and on and off. The light keeps indicating that the brake is on. This happens continuously every day. 2. Steering… when you are switching lanes, it’s not a smooth transition. It feels like a jerk each time and feels like if you were to put the brake, the car will flip over. Very concerning. Happens all the time.

1/8/2024

New car has millions of tiny dots everywhere in the windshield placed in irregular pattern. Not visible at normal light they brightly shine when sun is low and shining. I almost can't see anything in front of the car. Here is someone else on internet having exactly same problem. https: [XXX] Windshield is clear, washed multiple times - it doesn't seem that it can be removed from outside. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

8/14/2023

The rear side window just disintegrated. Was at the beach on Aug. 25, 2023 the car was parked in hot sun when I went out in the morning noticed the glass had just cracked around the corners. There was no evidence of a break-in attempt.

9/28/2023

As the passenger, following a passenger side impact, (T bone) I sustained 1st and 2nd degree burns extending from my ribs to my hip. To my knowledge the only airbags that inflated were the curtain air bags. Immediately upon impact I had a burning sensation on my right side that slowly began to spread. Once out of the car it was discovered that something had burned through 3 layers of clothing with the singed edges sticking to my skin. My vehicle was not drivable and was towed to a body shop. I spoke to the insurance company about the incident as I am receiving medical treatment for the burns. No one was interested in investigating the air bag.

12/12/2023

Side seat airbag has exhaust port facing inwards, instead of outward, towards the door of the vehicle, that caused the hot chemical from the airbag to push out all the gas at the left side of my body, melting my clothes and causing chemical burns to my side when it deployed upon a wreck.

7/15/2024

The contact owns a 2023 Ford Explorer. The contact stated while driving 65 MPH, she heard an abnormal noise. The contact stated no warning light was illuminated. The contact stated she was able to park on the side of the road and noticed that the sunroof had shattered independently. The contact took the vehicle to the local dealer and was informed that the sunroof needed to be replaced. The vehicle was not repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 2,500.

4/21/2023

While on interstate at 70mph, the front sunroof exploded. Sounding like a gun going off.. was no vehicles in front of me to cause debris.. after pulling over to see what happened I could tell the glass was pushed up away from vehicle. Not only was this safety concern for me. But also the vehicles behind me that had to suddenly stop and avoid the flying glass..

8/30/2023

The contact owns a 2023 Ford Explorer. The contact stated that while driving at an undisclosed speed, the wheel well inner liner fell onto the tire. The wheel well liner was rubbing on the tire. The tires were rubbing with ice, mud, and snow in the wheel well. The vehicle was taken to the local dealer, where it was diagnosed that the bracket and bolts for the wheel well liner were missing. The vehicle was not repaired. The manufacturer was contacted and informed the contact that there was no repair coverage on the vehicle for the failure. The failure mileage was 4,000.

6/17/2024

The contact owns a 2023 Ford Explorer. The contact stated while driving at approximately 80 MPH, the driver's side exterior A-pillar trim dethatched from the vehicle. Additionally, upon inspection, it was discovered that the passenger’s side A-pillar trim was loosened and unsecured. The cause of the failure was not yet determined. The local dealer and manufacturer were contacted but no assistance was provided. The failure mileage was 60,000.

8/28/2024

I have had 4 Ford Explorers that have the same problem that Ford has not commented on when I complain. If the car is parked facing down a hill with less than 1/4 tank of gas it won't start. The design of the tank precludes gas from reaching the engine. Unable to start the car, it cannot be brought out of park and rolled to a flat location. This time I had more than 1/4 of a tank and the same problem occurred. This happened in my driveway but what if you're on a street with an incline?

2/5/2025

Recall 25V442 was not completed on this VIN but was completed on VIN [XXX] . This service was reported on the incorrect VIN. I have spoken to the dealership service manager and to Ford customer service and they will not correct this incorrect reporting. Attached files are for the service and recall work performed on VIN [XXX] but recorded as completed on VIN [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

10/23/2025

-PARKING BRAKE IS AUTO ENGAGED 100% OF THE TIME AT START or WHILE SHIFTING OUT OF PARK or SHIFTING BETWEEN GEARS. DRIVE or REVERSE -TO DISENGAGE THE PARK BRAKE YOU HAVE TO DEPRESS THE ACCELERATOR PEDAL. -PRESSURE ON THE ACCELERATOR TO DISENGAGE IS INCONNSISTENT EVERY TIME. -VEHICLE LURCHES UNCONTROLLABLY WHEN RELEASING THE VEHICLE OFF THE EMERGENCY PARKING BRAKE SETTING. -THE JOLT OF THE VEHICLE FROM THE DEPRESS PRESSURE IS SO SIGNIFICANT AND DANGEROUS CAUSING THE RISK TO HITTING ANY PARKED VEHICLE WHILE PARALLEL PARKING OR HITTING STRUCTURE/GARAGE WHEN PARKING, JOLTING INTO TRAFFIC FROM A STOPPED/PARKED POSITION or TO PEOPLE WALKING NEAR THE VEHICLE WHILE TRYING TO MANIPULATE THE VEHICLE. -WHEN THE AUTO HOLD FEATURE IS TURNED ON, IT CAN BE ASSUMED TO BE ENGAGED BY PRESSING THE BRAKE PEDAL but IF THE PEDAL ISN'T ENGAGED WITH ENOUGH FULL PRESSURE THE AUTO HOLD WILL NOT FULLY ACTIVATE. IN NOTIFICATION WHEN ON IS IN SMALL GREEN TEXT THAT CAN BE EASILY MISSED/CONFUSED WITH THE GREEN SYMBOL SIMILAR IN SIZE TO THE GREEN AUTO HEADLIGHT SETTING IN THE SAME ZONE. THIS CAN CAUSE SOMEONE TO BELIEVE AUTO HOLD IN ENGAGED WHEN USING PERIPHERIAL VISION FOR THE INDICATOR QUE WITHOUT DIRECTLY TAKING EYES OFF THE FORWARD CONDITION. THIS GIVES THE DRIVER A FALSE CONFIDENCE TO REMOVE THEIR FOOT FROM THE BRAKE AND HAVE THE VEHICLE CREEP FORWARD AND CAN LEAD TO ACCIDENT OR INJURY.

7/17/2023

The contact was purchasing a 2023 ford Explorer. The contact stated that while reviewing the purchase agreement, it was discovered that the vehicle was not equipped with fog lights. The contact was concerned that without fog lights his visibility to the roadway would be impaired while driving at night. The vehicle was not yet in the contacts possession therefore it was not diagnosed or repaired. The manufacturer was contacted about the issue and referred the contact to call the NHTSA Hotline. The contact has not experienced a failure as of yet.

10/30/2023

The rear camera on my Explorer shows a blue screen most of the time and this has become a serious safety issue. A few weeks ago while backing out of a parking spot I almost hit a pedestrian who came out of a double-parked car because the pedestrian was in my rear view mirrors blind spot. Luckily a passenger in my car saw them and alerted me. The remedy for this recall was supposed to be available after August 7th. I have tried multiple times to get my vehicle in for repair. I have complained to my Ford dealer and opened a case with Ford customer service. They each told me something different and I'm not sure what to do now.

11/25/2023

Loose carpet under front seat. Could cause carpet on driver side to buckle up causing gas peddle issues. Had ford dealer look at it but refused to remedy issue. This could cause issues like Lexus had years ago with gas peddle sticking.

12/13/2023

The lane assist system put the vehicle into a skid on snowy road with no markings on roadway. The vehicle is available to inspect but insurance company is pushing to pickup vehicle as it was totaled. The system put vehicle into a skid that resulted into going into the ditch and hitting a power pole. As far as we know nobody has looked into system failure we did report it to sheriff and insurance company. This is the first time the lane departure turned on a snow covered road

4/1/2024

I have had to re-install the seat multiple times in the last 2-3 weeks because it keeps coming loose in rear facing mode. I installed the seat in early to mid-March. I first noticed it was loose on 4/26/24. I had it installed with the seatbelt at that time. I re-installed with the seatbelt and continued checking it daily until I noticed it being loose again within about a week. I again re-installed with the seat belt so it was secure and moving less than 1 inch side to side and front to back and continued checking for excess movement. I attended a CPST training the week of 5/6/24 and had my seats looked at by an instructor who told me it was done correctly. For the sake of practice, I installed it with LATCH instead and had an instructor confirm it was correct. That was all on 5/9/24. On 5/13/24 I had to re-install it yet again as the latch had loosened. I used the seatbelt that time and submitted a complaint to Graco. Today, 5/15/24, I had to re-install twice, first with seatbelt and then with LATCH (around 6 pm) which at the time of this writing (8 pm) has held. The seat has repeatedly become loose after a proper install, putting my child at risk because of the seat moving more than one inch side to side which does not meet Graco or CPST installation requirements. The remedy supposedly provided by Graco to others is to use LATCH. However, in my situation that has not helped and in general that is not a long term solution since LATCH has weight limits. I’ve also heard from others that Graco just tells them their seatbelt or vehicle is incompatible and nothing can be done. From what I can tell, it’s a known issue that Graco hasn’t acknowledged.

5/15/2024

The contact owns a 2023 Ford Explorer. The contact stated while driving 70 MPH on the expressway in the center lane, the Forward Collision Avoidance system engaged, and the vehicle came to an abrupt stop and failed to restart. After several minutes the vehicle restarted, and the contact was able to continue driving. Additionally, while in a parking lot, the vehicle shut off and failed to restart. After several minutes, the vehicle restarted. The Forward Collision Avoidance warning light illuminated while driving with no other vehicle nearby. The contact called the local dealer, but the vehicle was not diagnosed or repaired. While driving at an undisclosed speed, the tailgate warning light illuminated. The contact checked the tailgate and attempted to close the tailgate. There contact was able to place her fingers between the tailgate. The contact depressed the release button, but the tailgate failed to respond. The contact climbed into the vehicle and pushed the tailgate closed, but the tailgate reopened. The tailgate came partially downward. After several attempts, the tailgate was closed. While her husband was driving, the cruise control was inoperable. The contact stated that all the buttons on the steering wheel were stuck. The vehicle was taken to the local dealer but was not diagnosed or repaired. The manufacturer was contacted, who opened a case and referred the contact to the NHTSA Hotline. The failure mileage was approximately 6,700.

8/30/2024

The contact owns a 2023 Ford Explorer. The contact stated while driving 70 MPH on the expressway in the center lane, the Forward Collision Avoidance system engaged, and the vehicle came to an abrupt stop and failed to restart. After several minutes the vehicle restarted, and the contact was able to continue driving. Additionally, while in a parking lot, the vehicle shut off and failed to restart. After several minutes, the vehicle restarted. The Forward Collision Avoidance warning light illuminated while driving with no other vehicle nearby. The contact called the local dealer, but the vehicle was not diagnosed or repaired. While driving at an undisclosed speed, the tailgate warning light illuminated. The contact checked the tailgate and attempted to close the tailgate. There contact was able to place her fingers between the tailgate. The contact depressed the release button, but the tailgate failed to respond. The contact climbed into the vehicle and pushed the tailgate closed, but the tailgate reopened. The tailgate came partially downward. After several attempts, the tailgate was closed. While her husband was driving, the cruise control was inoperable. The contact stated that all the buttons on the steering wheel were stuck. The vehicle was taken to the local dealer but was not diagnosed or repaired. The manufacturer was contacted, who opened a case and referred the contact to the NHTSA Hotline. The failure mileage was approximately 6,700.

8/30/2024

At a stop light and all of the power in the vehicle went out and Explorer would not start. Hazards would not turn on and doors (besides driver door) would not unlock. Got out of the vehicle to try the fob and white smoke came billowing out from engine. Fire department and police were called. No warning lights or messages were seen on vehicle. Vehicle only has 10K miles on it. Vehicle was taken to dealership for diagnostics.

9/10/2024

The contact owns a 2023 Ford Explorer. The contact stated while driving approximately 65 MPH, road debris was kicked up by the vehicle ahead and cracked the windshield. The contact stated that the windshield was replaced by a glass repair shop. The contact stated that on another occasion while driving on the highway, road debris was again kicked up onto the windshield, and the windshield cracked. The contact asked the glass repair shop if the windshield was replaced with an OEM windshield and was informed that the windshield was an OEM part. The contact stated that while looking at the windshield from the left or right side, and at a right angle of light, there was a wavy imperfection running from the left to the right and in the middle of the windshield. The contact stated that the windshield had been replaced five times. The manufacturer was informed of the failure. The failure mileage was approximately 21,000.

9/17/2024

The driver side windows control buttons are breaking off for no apparent reason. Ford refused to fix faulty windows controls which could cause harm to a person attempting to roll windows up or down. Two buttons have broke off within a matter of a week and are in the shape of a W which could lead to injury. A 3rd button appears damaged as well.

9/21/2024

While driving on a two lane, rural road at dusk, with adaptive cruise control turned on, the car suddenly applied the brakes (hard) and a red warning briefly appeared on the dashboard. (It was on too brief to read.) The brakes were released quite quickly, but the vehicle had slowed approximately 20 MPH. There was no other traffic on the road at the time. No animals were crossing the road when the incident occurred. The weather was clear and visibility was good. Although it was dusk, the landscape was clearly visible without headlights. This is a rental vehicle and I have not used cruise control since the incident. NOTE: Had another vehicle been driving behind my vehicle, it could have rear ended it. This is a rental vehicle. Rented from Enterprise in Woodland CA. The registered owner is EAN Holdings LLC of Tulsa.

12/9/2024

While driving on a two lane, rural road at dusk, with adaptive cruise control turned on, the car suddenly applied the brakes (hard) and a red warning briefly appeared on the dashboard. (It was on too brief to read.) The brakes were released quite quickly, but the vehicle had slowed approximately 20 MPH. There was no other traffic on the road at the time. No animals were crossing the road when the incident occurred. The weather was clear and visibility was good. Although it was dusk, the landscape was clearly visible without headlights. This is a rental vehicle and I have not used cruise control since the incident. NOTE: Had another vehicle been driving behind my vehicle, it could have rear ended it. This is a rental vehicle. Rented from Enterprise in Woodland CA. The registered owner is EAN Holdings LLC of Tulsa.

12/9/2024

The contact owns a 2023 Ford Explorer. The contact stated that while driving at various speeds, there was an abnormal rattling and popping sound coming from the passenger's side. The contact also stated that the steering wheel would veer to the left or right directions independently while driving. No warning lights were illuminated. The vehicle was taken to a local dealer where it was diagnosed that the front passenger's strut needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The approximate failure mileage was 10,000.

1/8/2025

The contact owns a 2023 Ford Explorer. The contact stated while driving 27 MPH, a vehicle abruptly exited a parking lot without adhering to oncoming traffic. While attempting to avoid striking the vehicle, the contact activated the parking brake. The contact stated that after releasing the parking brake, the contact became aware that the parking brake handle became loosened and appeared to have disconnected from the socket. The contact later became aware that the parking brake had become inoperable. The vehicle was taken to a dealer, and it was confirmed that the parking brake was inoperable and needed to be repaired. The contact was informed that the repair was not covered under warranty and the contact was provided an estimate for the repair. The manufacturer was notified of the failure, and the contact was provided a case number. The contact was later referred to the NHTSA Hotline to file a complaint. The vehicle was not repaired. The failure mileage was approximately 20,000.

1/14/2025

Around 20,000 miles, I took my vehicle to the dealer due to rattling and knocking in the front right wheel well and it was discovered the stabilizer arm was cracked. Received the vehicle back, and approximately 1000 miles later, there is rattling at the front driver and passenger wheel well and squeaking going down the road. The sounds coming from vehicle are that of a 40-year-old vehicle.

3/17/2025

Error codes such as blind spots detection with traffic and a couple other codes that is stored in view status area in oasis

5/1/2025

The contact owns a 2023 Ford Explorer. The contact stated while driving 75 MPH on the interstate, the vehicle lost motive power. The contact stated that while depressing the accelerator pedal, the vehicle responded as intended. No warning light was illuminated. A dealer was contacted. The vehicle was taken to a dealer however, the dealer was unable to retrieve a diagnostic trouble code, and informed the contact that there was no failure. No assistance was provided. The vehicle was not repaired. The manufacturer was notified of the failure, and informed the contact that the repair would have to be out-of-pocket with the possibility of being reimbursed. The contact related the failure to NHTSA Campaign Number: 25V455000 (FUEL SYSTEM, GASOLINE); however, the VIN was not included in the recall. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was 17,000.

7/10/2025

The contact owns a 2023 Ford Explorer. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. No warning lights were illuminated. The vehicle was taken to an independent mechanic; however, a diagnostic test was not performed. The dealer was made aware of the failure. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact stated that the vehicle had been scheduled for a diagnostic test. The manufacturer was made aware of the failure but provided no assistance. The contact was informed that the repair was not covered under recall. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 44,100.

7/15/2025

drivers side second row captain seat makes ticking noise under the seat. if I put weight on seat it stops. it is intermittent. Im concerned it might be electrical. I have a video but unable to download. I can send if there is an email to send to.

8/6/2025

The contact owns a 2023 Ford Explorer. The contact stated that while operating the vehicle, the engine was misfiring, and the vehicle hesitated while accelerating. The vehicle was taken to the local dealer, who replaced the spark plug,s but the failure persisted. Later, while driving, the vehicle went into LIMP Mode and was towed to the dealer, who diagnosed the vehicle and determined that the coolant hose had failed, and the hose was replaced. Shortly after retrieving the vehicle the misfire continued with the check engine warning light illuminated. The vehicle was taken back to the dealer, and the head gaskets were replaced. The vehicle continued to experience failures, and the fuel injector and the crankshaft position sensor were replaced. The contact stated that later, while driving at an undisclosed speed, the vehicle stalled in the middle of the road. The vehicle was towed back to the dealer, who diagnosed that the engine rod bearings had failed, and the engine needed to be replaced. The vehicle was not yet repaired. The contact also experienced electrical failures with the seat heaters and the mirrors. The cause of the failure was not yet determined. The manufacturer was notified of the failure. The failure mileage was 35,682.

11/12/2025