2018 Ford Expedition Owner Complaints

THE TRUCK WAS BEING BACKED INTO A PARKING SPOT ,THE TRUCKS TURNED OFF I PUSHED THE PEDAL TO START THE TRUCK TO BACK UP AND IT PROPELLED INTO THE WALL OF THE ESTABLISHMENT THAT I WAS GOING INTO TO EAT DINNER CAUSING A GREAT DEAL OF DAMAGE TO THE BUILDING AND MY VEHICLE. MY BIGGEST CONCERN IS THIS PROBLEM NOT BEING LOOKED INTO. I HAVE A FAMILY AND WE ALL RIDE IN THIS TRUCK I WOULD NEVER WANT TO PUT THERE LIVES IN DANGER KNOWING THAT THIS IS A PROBLEM GOING ON WITH THESE TRUCKS.

10/31/2018

ELECTRONIC DIAL SHIFTER WILL AUTOMATICALLY SWITCH FROM DRIVE TO PARK IF THE VEHICLE START STOP BUTTON IS DEPRESSED WHEN THE CAR IS RUNNING. THE PARKING BRAKE ALSO AUTOMATICALLY SWITCHES ON AT THE SAME TIME. CONSIDER WHAT WOULD HAPPEN IF A 2018 FORD EXPEDITION IS TRAVELING ON A FREEWAY IN TRAFFIC AND THE START STOP BUTTON WERE ACCIDENTALLY DEPRESSED. THE CAR WOULD SHIFT INTO PARK, THE PARKING BRAKE WOULD ENGAGE AND THE DRIVER WOULD DECELERATE RAPIDLY FROM 65 MPH TO A STOP WITH NO NOTICE, LIKELY BEING REAR ENDED BY TRAFFIC IE; A SEMI TRUCK AT HIGHWAY SPEED. THE ELECTRONIC SHIFTER SHOULD STAY IN THE SELECTED GEAR WHEN THE START STOP BUTTON IS DEPRESSED AS A CONVENTION SHIFTER WOULD, ELECTRIC OR MECHANICAL. I DETERMINED THIS AFTER GOING TO A CAR WASH, PUTTING THE CAR IN NEUTRAL THEN DEPRESSING THE STOP BUTTON TO SAVE FUEL. THE CARIMMEDIATELY SHIFTED FROM NEUTRAL TO PARK AND ENGAGED THE PARKING BRAKE. I TESTED THE DRIVE, START BUTTON OFF, IMMEDIATELY SWITCHES TO PARK ON A FLAT STREET AT ZERO SPEED. I REALIZED AS AN ENGINEER THAT IF THIS HAPPENED AT SPEED A FATAL ACCIDENT COULD OCCUR. FORD CAN REMOVE THIS RISK WITH A SOFTWARE UPDATE TO THE ELECTRONIC SHIFTING, LEAVING THE CAR IN THE SELECTED GEAR IF THE START STOP BUTTON IS DEPRESSED.

1/5/2019

2018 FORD EXPEDITION. CONSUMER WRITES IN REGARDS TO VEHICLE BEING SEVERELY UNDER POWERED HAVING ONLY A 6-CYLINDER ENGINE IN A VEHICLE SO LARGE. *LD *JS

5/16/2018

TL* THE CONTACT OWNS A 2018 FORD EXPEDITION. THE CONTACT STATED THAT THE VEHICLE FAILED TO SHUT OFF AND THE CONTACT DISCONNECTED THE BATTERY. ALSO, THE RUNNING BOARDS FAILED TO RETRACT AND THE STEERING WHEEL PULLED TO THE LEFT AND RIGHT. THE CONTACT STATED THAT THE DRIVE CONTROL MALFUNCTION SERVICE REQUESTED, HILL DESCENT FAULT, ELECTRONIC LIMITED SLIP DIFFERENTIAL, REDUCED TORQUE, DRIVE CONTROL, PRE COLLISION ASSIST NOT AVAILABLE, SERVICE ADVANCETRAC, AND TRACTION CONTROL WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO THOROUGHBRED FORD (8501 N BOARDWALK AVE, KANSAS CITY, MO 64154, (816) 505-1818) AND SEEKINS FORD LINCOLN (1625 SEEKINS FORD DR, FAIRBANKS, AK 99701, (907) 459-4000) WHERE IT WAS DIAGNOSED THAT THE STEERING SENSOR NEEDED TO BE RESET AND THE STEERING WHEEL NEEDED TO BE ADJUSTED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS CONTACTED AND PROVIDED CASE NUMBER: CAS21880081. NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS 500.

6/19/2019

I BOUGHT THIS NEW EXPEDITION JUNE OF 2018. IT HAS PUT ITSELF INTO DEEP SLEEP MODE 8 TIMES. 06/11/18, 08/09/18, 08/19/18, 08/22/18 TWICE!, 10/13/18, 11/11/18, 02/06/19. EACH TIME IT HAD TO BE JUMPED WITH ANOTHER LARGE VEHICLE TO START IT UP. THE FIRST TIME WAS JUNE 11TH JUST DAYS AFTER I BOUGHT IT. WE TOOK IT IN AND THEY SAID NOTHING WAS WRONG. IT HAS BEEN IN THE SHOP 3 MORE TIMES SINCE THEN AND THEY "CAN'T FIND ANYTHING WRONG" THEY ARE NOW SAYING THEY WILL REPLACE THE BATTERY BUT I FEEL ITS SOMETHING WITH ALL THE NEW TECHNOLOGY IN THE CAR AND IT WILL STRAND ME AGAIN. I HAVE LUPUS AND IT HAS STRANDED ME IN 105 DEGREES AND FORD ROADSIDE ASSISTANCE SAID THE COULDN'T COME FOR 1 HOUR AND 45 MINUTES. I HAD TO HAVE A STRANGER TRY TO JUMP IT WITH A SMALL CAR AND IT WOULDN'T CHARGE, THEN A TUNDRA THAT THE MARINA MANAGER DROVE PULLED UP AND HE FINALLY GOT MY CAR GOING....I CAN;T DRIVE A CAR THAT HAS DONE THIS SO MANY TIMES AND THE FORD CORPORATION SAID IT DOESN'T QUALIFY FOR A REPLACEMENT. THEY WANT ME TO DRIVE AROUND WITH CABLES IN MY NEW $83K CAR AND DEPEND ON OTHERS TO HELP ME WHEN I AM STRANDED!! I AM DEALING WITH SERVICE DEPARTMENT OF AUTOMAX FORD IN KILLEEN TEXAS. THEY HAVE BEEN KIND BUT UNABLE TO HELP ME. THIS LAST OCCURRENCE WAS FEB. 6, 2019

2/9/2019

THE VEHICLE FAILED TO START 3 DIFFERENT TIMES. THE FIRST TIME WAS IMMEDIATELY AFTER PURCHASE OF THE VEHICLE - IT STARTED AFTER 30 MIN AND WAS TAKEN BACK TO THE DEALERSHIP. THEY REPLACED THE BATTERY AND NO ISSUES UNTIL 4 DAYS THEN IT OCCURRED AGAIN. THE VEHICLE WAS STOPPED AND PARKED OVERNIGHT AND WOULDN'T START THE NEXT MORNING. THE BATTERY HAD ENOUGH POWER - JUMP STARTING DIDN'T HELP. THE 3 TOW TRUCK WAS FINALLY CALLED INTO TOW THE VEHICLE TO THE FORD DEALERSHIP. THEY REPLACED THE IGNITION SWITCH AND THEN TOOK THE VEHICLE BACK UP TO THE PURCHASING DEALERSHIP. THEY DID A FULL REVIEW OF THE VEHICLE AND DIDN'T FIND ANY FURTHER PROBLEMS. THEN 4 WEEKS LATER IT HAPPENED AGAIN WHERE THE VEHICLE WOULD NOT START FOLLOWING SITTING FOR A COUPLE OF HOURS. AGAIN IT TOOK 4 TOW TRUCKS TO COME TO GET THE VEHICLE TO THE FORD DEALERSHIP. THE PROBLEM WAS THE VEHICLE WOULDN'T STAY IN NEUTRAL TO BE TOWED IT WOULD ALWAYS RETURN TO PARK. THE DEARSHIP THEN REPLACED THE STARTED AND SAID IT WAS THEN TAKEN CARE OF AND WON'T HAPPEN AGAIN. THE EVENTS WERE SEPT 4TH - PURCHASE VEHICLE - 1ST EPISODE, SEPT 8TH - 2ND EPISODE, NOVEMBER 19TH - 3RD EPISODE

2/18/2019

TOOK MY VEHICLE FOR OIL CHANGE AT A LOCAL MECHANIC. HE ADVISED ALL FOUR STRUTS ARE LEAKING. THE VEHICLE ONLY HAS 10,000 MILES ON IT. I WENT BACK TO FORD. THEY ADVISED THERE IS AN SS! BULLETIN AND THEY ARE ONLY SUPPOSED TO MONITOR THE ISSUE. A GOOGLE SEARCH SHOWS THIS HAS BEEN A PROBLEM WITH EXPEDITIONS FOR YEARS. WHY ISN'T FORD RESOLVING THIS AFTER ALL OF THESE YEARS AND FINDING A STRUT THAT WORKS PROPERLY?

4/2/2019

VEHICLE AS DELIVERED NEW FROM THE FACTORY HAD A VERY LOUD AND DISTINCT CLUNKING IN THE REAR SUSPENSION WHEN DRIVING. IT CLUNKS REPEATEDLY WITH EACH DOWNSHIFT OF THE 10 SPEED TRANSMISSION AND ONCE VERY HARD UPON ACCELERATION. IT WAS LATER DETERMINED THAT THE REAR DIFFERENTIAL RETAINER BUSHING HAD BEEN LEFT LOOSE AND NOT FULLY INSTALLED, ALLOWING THE WHOLE REAR SUSPENSION SYSTEM TO ROTATE WHEN IT SHOULD HAVE BEEN FIXED. THIS RESULTED IN PREMATURE TIRE WEAR AND APPARENT FLUID LOSS IN THE SHOCK ABSORBERS. THE END RESULT IS A VEHICLE THAT HAS A VERY HARSH RIDE.

5/16/2019

THE RETRACTABLE/AUTOMATIC RUNNING BOARD ON THE PASSENGER SIDE INTERMITTENTLY DROPS DOWN WHEN THE CAR IS IN PARK AND IN A STATIONARY POSITION FOR A PERIOD OF TIME. (IE. 2-3 HOURS AT REST) WHEN I RESTART THE VEHICLE AND OPEN/CLOSE THE DOORS, THEN SHUT OFF THE VEHICLE, THE RETRACTABLE RUNNING BOARDS WILL GO BACK UP WHERE THEY BELONG...MOST OF THE TIME. SEVERAL DAYS LATER, THE SAME THING HAPPENS AGAIN. I TOOK THE VEHICLE IN FOR SERVICE (CRONIN FORD - HARRISON, OHIO) IN THE FALL OF 2019 AND THEY REPLACED THE RETRACTABLE RUNNING BOARD MOTOR ON THE PASSENGER SIDE ONLY. IN MARCH OF 2020, IT STARTED TO HAPPEN AGAIN, AFTER THE VEHICLE IS AT REST FOR 2-3 HOURS. I AM PLANNING TO TAKE IT IN FOR SERVICE AGAIN, BUT I'M CONCERNED THAT THIS WILL BECOME A RECURRING PROBLEM WELL AFTER THE WARRANTY PERIOD IS OVER.

4/23/2020

THE VEHICLE HAS AN INTERMITTENT ELECTRICAL PROBLEM WHICH CAUSES A CROSS TRAFFIC SYSTEM FAULT, BLIND SPOT SYSTEM FAULT AND THE LIFTGATE OR LIFTGLASS TO INDICATE THAT IT IS AJAR. HEN THESE FAULT THE SAFETY SYSTEMS ARE INOPERATIVE AND POSE A SAFETY CONCERN. THIS OCCURS WHILE IN MOTION AT BOTH ON BOTH CITY STREETS AND AT HIGHWAY SPEEDS. *TR

5/11/2020

PURCHASED NEW 2018 EXPEDITION FX4 XLT WOTH CLASS IV TOWING PACKAGE AND OTHER OPTIONS RELYING ON FORD, ITS DEALERS, AND FORD'S PR, THAT VEHICLE COULD TOW TRAILERS UP TO CERTAIN WEIGHT. BUT, ONCE WENT TO PURCHASE TRAVEL TRAILER TO TOW, DISCOVER THAT FINE PRINT HARD TO FIND FORD DISCLOSURE HAD FAR LOWER TOWING LIMITS UNLESS PURCHASE ADDITIONAL EXPENSIVE TOWING OPTIONS. ALSO, VEHICLE LACKS TRAILER BRAKE CONTROLLER THAT IS REQUIRED IN MANY PLACES BY LAW AND NECESSARY TO TOW ALMOST ANYTHING SAFELY. IT IS POSSIBLE THAT BUYERS WILL NOT KNOW THE FOREGOING AND TOW RESULTING IN DANGEROUS RISKS AND POTENTIAL THIRD PERSON INJURIES/DEATHS IN CRASHES INVOLVING THE TOWING OF HEAVY TRAILERS WITH NO BRAKE CONTROLLERS.

8/10/2018

TODAY I EXPERIENCED A COMPLETE FAILURE OF THE BRAKES ON MY 2018 FORD EXPEDITION EL. THE BRAKE PEDAL WOULD NOT BUILD ANY PRESSURE WHICH ALMOST CAUSED AN ACCIDENT WITH MY CHILDREN IN THE VEHICLE. TO ANSWER THE SPECIFICS REQUESTED BY NHTSA, THE VEHICLE WAS BEING DRIVEN AT 45MPH OR LESS ON A CITY STREET AND THE PROBLEM STILL PERSISTED WHEN THE VEHICLE WAS STOPPED. THE ONLY WAY TO BUILD BRAKE PRESSURE WAS TO TURN THE VEHICLE OFF AND PUMP THE PEDAL. THIS VEHICLE IS LESS THAN 6 MONTHS OLD AND FOR HOW MUCH FORD CHARGES FOR A LIMITED EDITION EXPEDITION YOU EXPECT TO NOT HAVE YOUR BRAKES FAIL. THIS IS UNACCEPTABLE, FORD! THANK GOD NOBODY WAS KILLED BY THIS MANUFACTURING FLAW.

10/2/2018

RECENTLY I RENTED A FORD EXPEDITION. MUCH OF THE DRIVING WAS IN AN AROUND THE MOUNTAINS SURROUNDING YELLOWSTONE NATIONAL PARK. WHILE I FOUND THE VEHICLE EASY TO DRIVE THERE IS ONE GLARING SAFETY ISSUE CONCERNING THE ABILITY TO DOWNSHIFT. ONE MUST TAKE THEIR EYES OFF THE ROAD TO LOCATE THE + OR - BUTTONS ON THE CENTER CONSOLE TO CHANGE GEARS. THESE BUTTONS SHOULD BE LOCATED ON THE STEERING WHEEL. NOT ON THE CENTER CONSOLE.

8/5/2018

ELECTRONIC DIAL SHIFTER WILL AUTOMATICALLY SWITCH FROM DRIVE TO PARK IF THE VEHICLE START STOP BUTTON IS DEPRESSED WHEN THE CAR IS RUNNING. THE PARKING BRAKE ALSO AUTOMATICALLY SWITCHES ON AT THE SAME TIME. CONSIDER WHAT WOULD HAPPEN IF A 2018 FORD EXPEDITION IS TRAVELING ON A FREEWAY IN TRAFFIC AND THE START STOP BUTTON WERE ACCIDENTALLY DEPRESSED. THE CAR WOULD SHIFT INTO PARK, THE PARKING BRAKE WOULD ENGAGE AND THE DRIVER WOULD DECELERATE RAPIDLY FROM 65 MPH TO A STOP WITH NO NOTICE, LIKELY BEING REAR ENDED BY TRAFFIC IE; A SEMI TRUCK AT HIGHWAY SPEED. THE ELECTRONIC SHIFTER SHOULD STAY IN THE SELECTED GEAR WHEN THE START STOP BUTTON IS DEPRESSED AS A CONVENTION SHIFTER WOULD, ELECTRIC OR MECHANICAL. I DETERMINED THIS AFTER GOING TO A CAR WASH, PUTTING THE CAR IN NEUTRAL THEN DEPRESSING THE STOP BUTTON TO SAVE FUEL. THE CARIMMEDIATELY SHIFTED FROM NEUTRAL TO PARK AND ENGAGED THE PARKING BRAKE. I TESTED THE DRIVE, START BUTTON OFF, IMMEDIATELY SWITCHES TO PARK ON A FLAT STREET AT ZERO SPEED. I REALIZED AS AN ENGINEER THAT IF THIS HAPPENED AT SPEED A FATAL ACCIDENT COULD OCCUR. FORD CAN REMOVE THIS RISK WITH A SOFTWARE UPDATE TO THE ELECTRONIC SHIFTING, LEAVING THE CAR IN THE SELECTED GEAR IF THE START STOP BUTTON IS DEPRESSED.

1/5/2019

THE HEADLIGHTS ON THIS VEHICLE ARE ABSOLUTELY THE WORST OF ANY CAR I'VE EVER DRIVEN. DID NIGHT DRIVING YESTERDAY; THE PERIPHERAL LIGHTING WAS VIRTUALLY NON-EXISTENT, AND I COULDN'T EVEN SEE MY DRIVEWAY FROM THE ROAD. THERE IS NO MENTION ON THE WINDOW STICKER ABOUT WHAT TYPE OF LIGHT FIXTURES THE CAR HAS. I FEEL EXTREMELY UNSAFE WHEN DRIVING THIS VEHICLE AT NIGHT, AND WILL LIMIT THIS EXPOSURE WHEN I CAN. TOTALLY UNSAFE IN THE DARK OF NIGHT. THE ROAD TO OUR PLACE IS UNLIGHTED AND KINDA COUNTRY . . . COULDN'T SEE THE DRIVEWAY AT 10MPH WITH THE TURN SIGNAL FLASHING

8/26/2018

THE LOW BEAM HEADLIGHTS SHINE VERY LOW AND NOT FAR ENOUGH AHEAD OF THE VEHICLE. THEY ARE ALSO VERY DIM.

9/1/2018

I WAS BACKING UP AND THE TRUCK TOOK OFF WITHOUT MY FOOT ON THE GAS PEDAL. I HAVE ABOUT 15K IN DAMAGE TO MY VEHICLE. I HAVE FOUND A FEW OTHERS THAT HAVE HAD THE SAME PROBLEM

5/1/2019

THE REAR WINDOW DEFROST CONNECTORS DETACHED FROM THE REAR WINDOW, WHICH MEANS THE REAR WINDOW DEFROST DOES NOT WORK AT ALL. ON TWO SEPARATE OCCASIONS, THE REAR WINDOW DEFROST SOLDER HAS DETACHED. THE FIRST TIME WAS THE DRIVER SIDE. I TOOK IT IN, AND OUR LOCAL DEALERSHIP FIXED IT WITH A GLUE-ON REPAIR KIT. THE SECOND TIME IT WAS THE PASSENGER SIDE. IT IS CURRENTLY IN WARRANTY JAIL AGAIN AT OUR LOCAL DEALERSHIP SO THEY CAN ATTEMPT TO FIX IT.

1/22/2020

The Fuel filler assembly on our 2018 Ford Expedition broke while filling the vehicle with fuel, causing the entire fuel filler assembly to pop out of the side of the vehicle. The parts appear to be made of weak plastic and/or may be caused by poor design execution. The concern is that this defect could cause fuel to leak out of the assembly and/or the broken parts may render the vehicle unable to be filled with fuel and leave the driver stranded. The vehicle was taken to the dealer who confirmed the issue and ordered replacement parts.

6/30/2021

Car doesn’t let me pump fuel at gas station and overfills even when the tank is empty. Gas leaks from the bottom of the car. Weird suction noise comes from the fuel filler neck. I was doing research and found that many people have this same problem with my car and there’s a recall for this but for the 2015-2016 models and not the 2017. It’s a recall on the evap system suction pump and code is 20Y6.

6/29/2022

VEHICLE FRONT DRIVER SIDE TIRE/RIM/CYLINDER HAS A POPPING SOUND. IT POPS AS IF THE CALIBER OR BRAKES HAVE SOMETHING BROKE OR DIRT IN IT. I CAN HEAR THIS WHEN DRIVING SLOW AND WHEN IN REVERSE BACKING UP. ONLY HEAR SOUND WHEN DRIVING. BROUGHT THIS TO THE ATTENTION OF THE DEALERSHIP WHEN I PURCHASE THE VEHICLE, TOOK BACK TO DEALERSHIP TWICE AND THEY COULD NOT FIND OR FIX THIS PROBLEM.

9/12/2019

The aluminum caps on the lug nuts swell making them impossible to remove with the standard lug wrench. Rather than equipping the vehicles with quality single piece lug nuts instead they are cheap lugs nuts with flimsy caps that are prone to early and premature failure. When I got a flat tire I was unable to remove the lug nuts with the standard lug wrench provided. What should have been a straightforward 1/2 hour tire change ended up being an over 4 hour ordeal on the side of the road. The only way to remove the lugs nuts was with a damaged lug extractor tool which I did not have at the time. The only way to get the tire changed was pay for a tow and then have all 24 lug nuts removed and replaced with better quality single piece nuts at a specialty shop at my expense.

11/13/2021

The contact owns a 2018 Ford Expedition. The contact stated while starting the vehicle to pull out of a parking lot, he heard an abnormal sound coming from the vehicle. There was no warning light illuminated. The contact was able to drive home safely. The vehicle was taken to the dealer to be diagnosed. The contact was informed that the cam-phaser needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 77,000.

6/8/2022

The contact owns a 2018 Ford Expedition. The contact stated that on various occasions after starting the vehicle, a loud rattling noise was heard. The check engine warning light was illuminated. The vehicle was taken to a local dealer, where it was diagnosed that the cam phaser needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and the contact was advised to file a complaint with the NHTSA Hotline. The approximate failure mileage was 89,000.

5/3/2023

AFTER CALLING 3 FORD DEALERS AROUND KANSAS CITY MO. THEY ALL TOLD ME THAT FORD DOES NOT HAVE SEAT BELT EXTENSION FOR 2018 EXPEDITION.

8/22/2018

TAKATA RECALL. ON 4/29/19 THE 2ND ROW MIDDLE SEAT BELT WAS REPLACED AFTER HAVING BEEN IN THE SHOP 2X FOR DIAGNOSIS. IT WOULD NOT RELEASE OUT TO BUCKLE. IT KEPT SNAGGING ON ITSELF INSIDE. ON 6/11/19 THE VEHICLE WAS TAKEN IN TO BE DIAGNOSED FOR BAD STRUT. TURNS OUT 3 OF THE 4 WERE BAD AND NEED REPLACED. THE DEALERSHIP WOULD NOT REPLACE THE 4TH STRUT EVEN THOUGH SHE STATED ITS BEEN A BIG PROBLEM LATELY. ALSO THE LIFT GATE WAS INSPECTED AS IT OPENS AND CLOSES ON ITS OWN PERIODICALLY. THEY COULD NOT GET THE LIFT GATE TO RECREATE THE PROBLEM AND SINCE THE VEHICLE DIDNT THROW A CODE FOR IT THEY CANT DO ANYTHING ABOUT IT. I HAVE AN APPOINTMENT FOR 6/19/19 TO HAVE THE 3 STRUTS REPLACED AND THE LIFT GATE CHECKED AGAIN.

6/14/2019

THE AIR BAG WARNING LIGHT IS ON WHICH MAY CAUSE THE AIRBAGS NOT TO FUNCTION PROPERLY. WE HAVE NOT HAD AN ACCIDENT TO CAUSE THE AIR BAG LIGHT ON THE DASHBOARD TURN ON. WE ARE TAKING IT TO THE DEALERSHIP LATER IN THE MONTH TO FIND OUT THE EXACT CAUSE OF THIS MALFUNCTION. BUT THE POTENTIAL OF AN ACCIDENT AND THE AIR BASS FAILING TO DEPLOY IS IN THE BACK OF MY MIND. PLEASE LOOK INTO THIS MATTER NOW SO IT PREVENTS ANY FUTURE FAMILIES BEING AFFECTED.

1/27/2019

WAS HIT BY A VEHICLE WHILE MAKING A LEFT HAND TURN ON A CITY STREET. TRIED TO STOP THE CAR. BREAKS WOULD NOT WORK AND JUST WENT TO THE FLOOR BOARD. VEHICLE SPED UP. JUMPED 2 CURBS AND HAD TO THROW THE CAR IN PARK IN ORDER TO STOP. AIR BAGS DID NOT DEPLOY.

7/18/2020

FOLLOWING COMPUTER ISSUES THAT CAUSED THE FOLLOWING: BAD STEERING SENSOR (PLAY IN THE STEERING), TRACTION CONTROL WARNING, HILL DECENT WARNING, RUNNING BOARDS NOT WORKING, FORD SYNC FREEZING: RADIO, TEMP, BACK UP CAMERAS, PHONE NOT WORKING. MONITOR TURNS OFF AND ON WHILE DRIVING. MONITOR WILL NOT TURN OFF WHEN CAR PARKED.

6/12/2019

TL* THE CONTACT OWNS A 2018 FORD EXPEDITION. THE CONTACT STATED THAT THE VEHICLE FAILED TO SHUT OFF AND THE CONTACT DISCONNECTED THE BATTERY. ALSO, THE RUNNING BOARDS FAILED TO RETRACT AND THE STEERING WHEEL PULLED TO THE LEFT AND RIGHT. THE CONTACT STATED THAT THE DRIVE CONTROL MALFUNCTION SERVICE REQUESTED, HILL DESCENT FAULT, ELECTRONIC LIMITED SLIP DIFFERENTIAL, REDUCED TORQUE, DRIVE CONTROL, PRE COLLISION ASSIST NOT AVAILABLE, SERVICE ADVANCETRAC, AND TRACTION CONTROL WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO THOROUGHBRED FORD (8501 N BOARDWALK AVE, KANSAS CITY, MO 64154, (816) 505-1818) AND SEEKINS FORD LINCOLN (1625 SEEKINS FORD DR, FAIRBANKS, AK 99701, (907) 459-4000) WHERE IT WAS DIAGNOSED THAT THE STEERING SENSOR NEEDED TO BE RESET AND THE STEERING WHEEL NEEDED TO BE ADJUSTED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS CONTACTED AND PROVIDED CASE NUMBER: CAS21880081. NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS 500.

6/19/2019

TL* THE CONTACT OWNS A 2018 FORD EXPEDITION. WHILE DRIVING 40 MPH, THE AIR CONDITIONING VENTS WERE NOT FUNCTIONING. THE VEHICLE WAS TAKEN TO O. C. WELCH FORD LINCOLN (LOCATED AT 4920 INDEPENDENCE BLVD, HARDEEVILLE, SC 29927, (843) 288-0100) WHERE IT WAS DIAGNOSED THAT THE FRONT AND REAR EVAPORATORS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 36,730. *AS

9/19/2019

THE SIDE-VIEW MIRRORS ON THE 2018 FORD EXPEDITION PLATINUM ARE DEFECTIVE. WHEN ADJUSTING THE MIRROR TO A PRE-PROGRAMMED NUMBER, THE MIRRORS WILL START TO ADJUST THEMSELVES AND UNFORTUNATELY WILL GET STUCK IN AN ENDLESS LOOP OF MOVING, CLICKING, MOVING, CLICKING, ETC... THE MIRROR FAILS TO ADJUST TO THE PROPER LOCATION AND THE MIRROR MOTOR CAN'T BE STOPPED UNTIL THE KEY IS REMOVED FROM THE IGNITION AND THE ELECTRICAL SYSTEM IS COMPLETELY SHUT OFF (I.E. OPENING AND CLOSING THE DRIVER-SIDE DOOR. I'M SURE IF THE MOTOR ON THE MIRROR WAS ALLOWED TO CONTINUE TO ADJUST ITSELF IN AN ENDLESS LOOP, IT COULD POSE A FIRE HAZARD (NOT TO MENTION THE FUNCTION ITSELF IS FAULTY). THIS ISSUE APPEARS TO BE SOMETHING MANY OTHERS ON FORUMS ARE STARTING TO COMPLAIN ABOUT. FORD IS AWARE OF THE ISSUE AND HAS NOT OFFERED TO RESOLVE IT FOR ANY OF ITS CUSTOMERS. THIS ISSUE CAN OCCUR WHILE THE VEHICLE IS MOVING OR STATIONARY.

10/30/2019

Drivers door would not close. Took 10 months for the new door latch to get shipped to my local Ford dealer . They charged us $ 708.00 to do the repair .

2/10/2022

The door opened while driving due to the latch on the rear passenger door popped open. The door now will not stay latched closed. It just continues to stay open. My daughter could have fallen out of the car while we were driving because of this.

4/4/2022

Panoramic sunroof stuck in open position. Will not close without multiple failed attempts. When closing the sunroof makes a cracking and grinding noise. This issue has been identified by Ford, however my VIN does not currently fall under the open recall. Therefore, Ford will not cover the repair. Details of existing recall are below… Ford TSB 18-2374 Some 2015-2019 F-150, 2017-2019 F-Super Duty, 2018-2019 Expedition/Navigator vehicles equipped with a vista roof opening panel may exhibit a binding/sticking, glass stuck open or closed, noisy operation including chatter, rattling, or grinding. This may be due to the glass brackets cracking and/or breaking apart. The glass panel brackets are serviceable separately from the frame assembly and require the roof opening panel glass to be moved to the vent position. Follow the Service Procedure steps to correct the condition.

1/11/2023

The contact owns a 2018 Ford Expedition. The contact stated that while driving at an undisclosed speed and attempting to stop the vehicle, water started to enter through the instrument panel. No warning lights were illuminated. The vehicle was taken to the dealer where it was diagnosed that the tracks on the moon roof had failed and needed to be replaced; however, the moon roof was re-sealed as a temporary fix. The vehicle was repaired. The contact was concerned that the failure would reoccur. The manufacturer was notified of the failure and the contact was informed that half the cos would be covered. The failure mileage was approximately 51,271.

4/10/2023

The contact’s daughter owns a 2018 Ford Expedition. The contact stated that she noticed that her daughter’s vehicle made an abnormal sound at start up. No warning light was illuminated. The vehicle was taken to the dealer where it was diagnosed that the cam phaser had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and offered to pay half the cost for the repair. The failure mileage was approximately 70,000.

8/7/2023

The contact owns a 2018 Ford Expedition. The contact stated that when the vehicle was started, there was a grinding sound coming from the front of the vehicle. The contact stated that the sound was more evident at the initial start-up. The contact took the vehicle to the dealer who diagnosed that the cam phasers had failed and needed to be replaced. The vehicle had not been repaired. The contact was informed that the failure was a known failure. The manufacturer had been made aware of the failure. The approximate failure mileage was 46,000.

12/7/2023

The contact owns a 2018 Ford Expedition. The contact stated while driving 75 MPH, the vehicle started sputtering and unintendedly decelerated to 20 MPH. The contact was able to continue driving; however, the vehicle failed to exceed 20 MPH. The vehicle was taken to the dealer, where the fuel pump was replaced; however, the failure persisted. The vehicle was taken back to the dealer, where the fuel pump and the Variable Valve Timing (VVT) Solenoid were replaced; however, the failure recurred increasingly, and the vehicle lost motive power on several occasions. The contact veered to the side of the road and restarted the vehicle after several attempts and continued driving. The vehicle was taken to the dealer, where the fuel pump and the fuel pressure rail were replaced; however, the check engine warning light became illuminated. The contact's husband replaced the O2 sensors, the catalytic converter, and the fuel pump stand; however, the failure persisted. The contact stated that the vehicle shuddered while idling in the parking lot and then lost power. The contact was able to restart the vehicle after several attempts; however, the failure recurred while driving to the residence. The vehicle was taken to a second dealer, Tri-State Ford (1900 Interstate 40 Access Rd, Amarillo, TX 79103), where it was diagnosed that a relay in the wiring harness box had failed, and the wiring harness box needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 46,000.

9/7/2023

The contact owns a 2018 Ford Expedition. The contact stated that while driving 45 MPH, the vehicle lost motive power inadvertently. The contact was able to pull to the side of the road. The contact was able to restart the vehicle after several attempts; however, the vehicle sputtered while restarting. The contact was able to continue driving. The contact stated that the failure had been recurring while driving. The check engine warning light was illuminated. The vehicle was taken to the dealer, where it was diagnosed that the fuel pump needed to be replaced. The contact related the failure to NHTSA Campaign Number: 18V392000 (Fuel System, Gasoline); however, the VIN was not included. Additionally, the dealer informed the contact that oil was leaking from the timing valve cover and the front struts. The dealer also informed the contact that the transmission lines were leaking. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 64,500.

1/17/2024

CPSC: THE PURPORTED PURPOSE OF FORD'S 'PROJECTOR' HEADLIGHT DESIGN WAS TO INCREASE LUMENS WHILE DECREASING POWER CONSUMPTION. INSTEAD OF THE HEADLIGHT (AS WITH 'NORMAL' LOW-BEAM HEADLIGHTS) BEING AIMED AWAY FROM ONCOMING VEHICLES AND DISPLAYING THE ENTIRE ROAD AHEAD, THE HEADLIGHT ROAD VISIBILITY (AS VIEWED BY THE DRIVER THROUGH THE WINDSHIELD) HAS A DISTINCT, HORIZONTAL LINE ABOVE WHICH IS ABSOLUTELY DARK AND BELOW IS LIT. *DT *JS *TT

7/2/2018

TL* THE CONTACT OWNS A 2018 FORD EXPEDITION. THE CONTACT STATED THAT ALL OF THE SHOCK ABSORBERS WERE DEFECTIVE AND CAUSED THE REAR OF THE VEHICLE TO BOUNCE WHEN DRIVING OVER A POTHOLE. THE VEHICLE'S REAR WOULD ALSO BOUNCE SIDEWAYS WHEN MAKING TURNS. THE VEHICLE WAS TAKEN TO HIXSON FORD OF ALEXANDRIA (2506 S MACARTHUR DR, ALEXANDRIA, LA 71301, (318) 448-0871) WHERE THE REAR SHOCKS WERE REPLACED WITH NEW ONES UNDER THE WARRANTY. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 6. *JS

3/21/2019

FOLLOWING COMPUTER ISSUES THAT CAUSED THE FOLLOWING: BAD STEERING SENSOR (PLAY IN THE STEERING), TRACTION CONTROL WARNING, HILL DECENT WARNING, RUNNING BOARDS NOT WORKING, FORD SYNC FREEZING: RADIO, TEMP, BACK UP CAMERAS, PHONE NOT WORKING. MONITOR TURNS OFF AND ON WHILE DRIVING. MONITOR WILL NOT TURN OFF WHEN CAR PARKED.

6/12/2019

FORD EXPEDITION WAS TRAVELLING AT 50-60KM/HR WHILE PASSING AN EMERGENCY VEHICLE ON A HIGHWAY. THE EXPEDITION WAS STRUCK FROM BEHIND BY A UTILITY VAN TRAVELLING AROUND 110KM/HR. BOTH FRONT SEATS SLID FORWARD AND ALSO RECLINED ON IMPACT. THIS CAUSED BOTH FRONT PASSENGERS TO SUSTAIN BRUISING ON THEIR CALF'S DUE TO THE SEATS SLIDING FORWARD AND WHIPLASH FROM BOTH FRONT SEATS RECLINING. BOTH FRONT SEATS TRAPPED CHILDREN IN THEIR CAR SEATS IN THE 2ND ROW FORM BEING RECLINED. NO AIR BAGS DEPLOYED IN THE ACCIDENT AS WELL!

12/1/2020

FORD EXPEDITION WAS TRAVELLING AT 50-60KM/HR WHILE PASSING AN EMERGENCY VEHICLE ON A HIGHWAY. THE EXPEDITION WAS STRUCK FROM BEHIND BY A UTILITY VAN TRAVELLING AROUND 110KM/HR. BOTH FRONT SEATS SLID FORWARD AND ALSO RECLINED ON IMPACT. THIS CAUSED BOTH FRONT PASSENGERS TO SUSTAIN BRUISING ON THEIR CALF'S DUE TO THE SEATS SLIDING FORWARD AND WHIPLASH FROM BOTH FRONT SEATS RECLINING. BOTH FRONT SEATS TRAPPED CHILDREN IN THEIR CAR SEATS IN THE 2ND ROW FORM BEING RECLINED. NO AIR BAGS DEPLOYED IN THE ACCIDENT AS WELL!

12/1/2020

The contact owns a 2018 Ford Expedition. The contact stated that the retractable running board failed to open or close intermittently. The contact stated that while stepping on the running board to exit the driver's side door, the running board inadvertently started to close. The contact stated that his foot was caught, and he had to struggle to remove his foot. The contact stated that he sustained no injuries. The vehicle was not taken to an independent mechanic or dealer for diagnosis or repairs. The contact also stated that there were electrical issues with the side view mirrors automatically adjusting without warning. The manufacturer was notified of the mirror failure and advised the contact to call the local dealer. The manufacturer was not made aware of the running board failure. The failure mileage was approximately 50,000.

8/30/2021

The contact owns a 2018 Ford Expedition. The contact stated that the retractable running board failed to open or close intermittently. The contact stated that while stepping on the running board to exit the driver's side door, the running board inadvertently started to close. The contact stated that his foot was caught, and he had to struggle to remove his foot. The contact stated that he sustained no injuries. The vehicle was not taken to an independent mechanic or dealer for diagnosis or repairs. The contact also stated that there were electrical issues with the side view mirrors automatically adjusting without warning. The manufacturer was notified of the mirror failure and advised the contact to call the local dealer. The manufacturer was not made aware of the running board failure. The failure mileage was approximately 50,000.

8/30/2021

Swollen lug nuts.

11/12/2021

Drivers door would not close. Took 10 months for the new door latch to get shipped to my local Ford dealer . They charged us $ 708.00 to do the repair .

2/10/2022

Air conditioning unit has failed and after further investigation there is metal found in compressor which forces a full replacement of the AC unit. After further investigation (online forums and discussion with dealerships) this is not uncommon. The compressors are faulty and for a 5 year old car to find metal and replace air conditioning issues multiple times in past few years.

6/30/2022

The contact owns a 2018 Ford Expedition. The contact stated while driving 65 MPH and attempting to change lanes, he depressed the accelerator to overtake the other vehicles and the accelerator became stuck. The contact stated that the cruise control had been activated while attempting to make the lane change. The contact stated that he removed his foot from the accelerator pedal however, the vehicle remained accelerating to almost 100 MPH. The contact tapped the accelerator pedal to release the stuck pedal however, the accelerator pedal failed to respond. The contact placed his foot underneath the pedal and physically released the pedal. The contact stated that the accelerator pedal responded and the vehicle slowed. The contact stated that the check engine warning light was illuminated. The contact stated he checked the vehicle service app on his phone and stated that the app showed two catalytic converter warnings had been displayed. The contact had taken the vehicle to a local dealer where it was not yet diagnosed or repaired. The manufacturer had been informed of the failure. The failure mileage was 65,647.

9/12/2022

The contact owns a 2018 Ford Expedition. The contact stated while starting the vehicle, he heard a loud noise coming from the vehicle. The vehicle was taken to the dealer and the contact was informed that the cam phaser needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and informed of the failure however, no assistance was provided. The failure mileage was 83,000.

9/27/2022

The contact owns a 2018 Ford Expedition. The contact stated that while starting the vehicle and driving at an undisclosed speed, the vehicle made rattling sounds. The vehicle was taken to the dealer where it was diagnosed that the failure was related to Customer Satisfaction Program: 21N08 (PCM Reprogram Due To Engine Shudder) and that the cam phaser also needed to be replaced. However, the dealer informed the contact that the manufacturer declined the repair due to the vehicle's salvage title. The manufacturer was made aware of the failure and declined the replacement part due to the salvage title. The failure mileage was approximately 48,000.

10/13/2022

The rear doors don’t unlock frequently. They won’t open from inside or outside often and require repeated unlocking of locks. The manual lock pulls on top of panel are too recessed to grab and pull. The drivers door never comes up at all.

2/6/2023

The contact owns a 2018 Ford Expedition. The contact stated that he had taken the vehicle to the dealer on four separate occasions due to moisture leaking from the panoramic sunroof. Due to the failure, the roof headliner needed to be replaced a second time. The contact stated that the panoramic sunroof had never been used and had remained covered. The manufacturer had been notified of the failure and referred him to the NHTSA Hotline. The vehicle was not repaired. The failure mileage was approximately 20,000.

7/12/2023