2022 Tesla Model S Owner Complaints

I own MSLR 2022, on the manual it says to open a rear door in the unlikely situation when no power, fold back the edge of the carpet below the rear seats to expose the mechanical release cable. Pull the mechanical release cable toward the center of the vehicle. I have a floor mat that covers the secret hole stated in the instructions as well. It adds an additional step. My concern is that in a circumstance when the car is on fire or submerged in water, the rear passengers may lack the knowledge or calmness to unlock the doors.

1/6/2022

While driving my car. 10s of error messages while on the Highway. Error messages were quite scary to the effect of “please pull over immediately and exit the vehicle” I ignored it the first time. Second time it occurred took a picture because tesla could not find the error the first time. Both times occur after super charging.

5/6/2022

During our first road trip with this auto, we traveled along I-76 and I-80 on clear days; after setting the "traffic-aware cruise control" (aka adaptive cruise control), the car would brake randomly and for no apparent reason (such as approaching a car ahead of us). This happened so frequently as to make the feature useless during much of the drive. At other times during our trip, the cruise control would seem to work for a while, then start with random braking. On two-lane highways, though it didn't seem to regard oncoming cars in the opposite lane as a hazard (that's good), it still engaged in random braking when no cars were anywhere in sight. Once again, we'd just turn off the feature, as it became more of a safety hazard than having any benefit. Certainly, any cars that might have been behind us would have been endangered by unexpected braking, and had road conditions been at all slippery, such as on ice, it could have been downright dangerous. I'd rather that Tesla reverted to a "traditional" cruise control, where we can set the speed and then be responsible for managing braking situations.

6/4/2022

I just completed a round trip from Minneapolis to Oregon. During cruise control, the vehicle frequently suddenly braked at highway speeds for no apparent reason. This was extremely dangerous a few times. I have put in a service request with Tesla.

7/15/2022

My Tesla plaid arrived with a yoke steering wheel. The sales associate told me that it's easy to get used to, and that it works well. I have driven the car for a couple weeks now and it is clearly a safety hazard. First off, it is difficult to steer, especially if you need to get out of a dangerous situation quickly. The yokes shape is extremely wide, and you have to reach hand over hand to turn. If you lose control on a icy road and need to keep the wheels facing in the direction that you wish to go, you will be unable to do so. Next, this yoke steering wheel has buttons for the horn and turn signals. I tried using my horn two days ago to tell someone in a parking lot that my car was close to theirs. I almost hit their car because the horn button was not working. Next, when I am steering, the turn signals and windshield wipers are accidentally triggered. This happens all the time. Furthermore, these issues do not make it safe to direct the vehicle under a high stress event. Having your windshield wipers triggered while trying to steer quickly is disorienting. It is only a matter of time till this steering wheel causes an accident on the roads.

1/13/2022

I have used the self driving feature of my 2022 Tesla Model S on several highway trips, most recently a round trip between Seattle and Palm Springs. The following problems with the Tesla self driving feature were noted. (My car has only the basic self driving feature, not the full self driving upgrade) 1. Random “phantom braking” where the car, without apparent reason, suddenly braked. 2. On several occasions the car abruptly swerved off toward an off ramp. I think this occurred when the white line marking the side of the road was interrupted by the off ramp where there was no painted line. 3. On several occasions when the turn signal was activated in order to change lines the car started to move over into the adjacent lane but abruptly swerved back to the original lane. I was able to maintain control but it was a frightening event. Due to the unpredictable nature of these events I greatly reduced my use of the fsd feature.

5/5/2022

Driving at 70 mph with Autopilot on, vehicle slams on brakes when approaching Semi Truck in oncoming lane. No vehicles in front or behind me. No known reason for this action. AutoSteer was not engaged.

3/31/2022

PHANTOM BRAKING: I was driving northbound on the I-5 highway south of Sacramento, California using cruise control and traveling at the 70 MPH speed limit on September 14, 2022. At approximately 2:50 p.m., I moved from the right lane into the left lane by using the turn signal to execute the lane change. Once in the left lane, the car immediately began violently applying the brakes. There was a car behind me that appeared as if it was going to rear end me. I pressed on the accelerator pedal which allowed me to regain control over the vehicle and avoid being hit by the vehicle behind me. The weather was clear and visibility was excellent. There was no apparent reason for the emergency braking system to become operative.

9/21/2022

The contact owns a 2022 Tesla Model S. The contact stated that the shift bar became inoperable. The hazard warning activation switch was inoperable. The vehicle was taken to the local dealer where it was diagnosed that the control bar needed to be replaced. The vehicle was not repaired. The manufacturer was contacted but no further assistance was provided. The approximate failure mileage was 1,500.

3/9/2022

The contact owns a 2022 Tesla Model S. The contact stated while pulling out of the garage without the seat belt securely fastened, the audible seat belt reminder failed to engage. The contact stated that the vehicle was taken to a Tesla service center twice, where it was diagnosed that the software needed to be updated; however, the service center advised the contact that they were unable to update the software on his vehicle for unknown reasons. Additionally, a Tesla mobile technician came to the contact's residence to repair the failure but was unable to update the software. The vehicle was not repaired. The contact stated upon contacting the Tesla service center he had previously taken the vehicle to, to inquire whether a recall was associated to the failure, he was referred to the NHTSA.gov website. The contact became aware that the VIN was included in NHTSA Campaign Numbers: 22V045000 (Electrical System, Seat Belts) and 22V063000 (Electrical System, Forward Collision Avoidance). The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was approximately 400. Parts distribution disconnect.

3/11/2022

While on A/P cruising on the free way the car slow down and start braking on its own !!

7/20/2022

While driving with Traffic Aware Cruise Control engaged and set at 55 MPH the car did a hard break to an almost complete stop in the middle of the lane for no apparent reason. This occurred at least two times and both times there was no traffic in front of me. The road was a two lane highway. There was oncoming traffic and cars behind me but no cars in front of me. The breaking was so hard on both occasions and it startled me and caused me to veer off the road in the first instance . The car behind me had to break suddenly as well. After the second occurrence I disengaged the TACC as it seemed to be sensing the oncoming traffic

8/29/2022

I have used the self driving feature of my 2022 Tesla Model S on several highway trips, most recently a round trip between Seattle and Palm Springs. The following problems with the Tesla self driving feature were noted. (My car has only the basic self driving feature, not the full self driving upgrade) 1. Random “phantom braking” where the car, without apparent reason, suddenly braked. 2. On several occasions the car abruptly swerved off toward an off ramp. I think this occurred when the white line marking the side of the road was interrupted by the off ramp where there was no painted line. 3. On several occasions when the turn signal was activated in order to change lines the car started to move over into the adjacent lane but abruptly swerved back to the original lane. I was able to maintain control but it was a frightening event. Due to the unpredictable nature of these events I greatly reduced my use of the fsd feature.

5/5/2022

I just completed a round trip from Minneapolis to Oregon. During cruise control, the vehicle frequently suddenly braked at highway speeds for no apparent reason. This was extremely dangerous a few times. I have put in a service request with Tesla.

7/15/2022

Rear tires have alarming wear on the inside, where the inside sidewall meets the tread. This is identical to the other complaints that are logged on NHTSA about Michelin Pilot Sport 4S rear tires on Tesla Model S Plaid cars. Tires are: Michelin Pilot Sport 4S 295/30 ZR21 102Y XL BSW. Specifically, the right rear tires loses pressure and needs to be reinflated. The left rear tire, according to inspection, actually looked worse, but is not yet losing pressure. This is impossible to see or know about without removing the tire or putting the car on a lift, since it is on the is inside sidewall/tread of the rear tire. There is high danger of a blowout because of some type of defect (camber/suspension or tire) which cannot be seen by the consumer. I would have never known about this if the tire technician had not alerted me, and probably would have had a high-speed blowout.

12/19/2022

My car has 10K miles and rear wheels started to layer off. This is the same issue as many other reporting on the web. I tired to reach out to Tesla but they deny any responsibilities. Something needs to be done ASAP before people will get hurt. I am lucky that I noticed this issue.

2/14/2023

The contact owns a 2022 Tesla Model S. The contact stated while pulling out of the garage without the seat belt securely fastened, the audible seat belt reminder failed to engage. The contact stated that the vehicle was taken to a Tesla service center twice, where it was diagnosed that the software needed to be updated; however, the service center advised the contact that they were unable to update the software on his vehicle for unknown reasons. Additionally, a Tesla mobile technician came to the contact's residence to repair the failure but was unable to update the software. The vehicle was not repaired. The contact stated upon contacting the Tesla service center he had previously taken the vehicle to, to inquire whether a recall was associated to the failure, he was referred to the NHTSA.gov website. The contact became aware that the VIN was included in NHTSA Campaign Numbers: 22V045000 (Electrical System, Seat Belts) and 22V063000 (Electrical System, Forward Collision Avoidance). The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was approximately 400. Parts distribution disconnect.

3/11/2022

The drivers seatbelt unlatches by itself, without pressing the release button. Effectively, the drivers side seatbelt is unusable. Tesla has repeatedly refused to correct the problem.

9/11/2023

The Left headlight does not work and the airbag compartment is protruding out at a weird angle. This has been like this since delivery.

4/28/2022

Steering Yoke Safety Issue: Tesla Model S Plaid cars come with a steering yoke instead of steering wheel. The steering yoke’s horn, turn signal, high beam, voice assistant, windshield wiper, and cruise control LED indicators that identify these buttons become invisible due to sun glare when the sun is behind or to the left of the driver. The glossy surface of the yoke combined with the weak LED lights of the indicators make the yoke unusable for honking the horn, make it impossible to find the horn, turn signal, windshield wiper, and other buttons, effectively making these features unusable. At a minimum, these critical safety buttons being invisible and having no tactile way to finding them during sunny days causes a significant distraction away from looking at the road. In the attached photo, you will see the effect of sun glare on the yoke while driving. This design flaw in the steering yoke/wheel puts my safety and the safety of others at risk because of inability to use the horn, windshield wipers, voice assistant, high beams, and turn signals when the sun or any other bright light causes yoke glare. Furthermore, the lack of tactile indication of where the buttons are, because they are only indicated/separated by lighting (LEDs) causes the driver to have to divert attention away from the road and onto the steering yoke to find the controls, or push parts of the yoke randomly until the correct function button is found. This is a serious safety issue which can be resolved by using a different material for the steering yoke indicator buttons, by having tactile separators/notches where the yoke buttons are so the user can find where to press during sunny days.

5/20/2022

Distortion within windshield glass. Appears as if looking through magnifying glass. Causes driver distraction. Appears to be manufactured this way.

11/11/2022

On November 1, I terminated my 3 year lease on a 2019 Tesla S for a new lease on a 2022 Tesla Model S. I was very happy with my original lease. During this week of driving I learned of the many changes that were made for this new model. So far most of them are only a matter of adjusting to these new/modified features. But some of them are definitely a safety hazard. This is the deletion of the left stalk on the steering wheel to indicate a planned change of direction and blink the appropriate turn signals. It is replaced by two “touch” buttons on the left side of the steering wheel, one for a left turn indicated by a left arrow and one below it for a right turn. Possibly one may memorize their location but until they are memorized the driver will have to take his/her eyes off the road for the few seconds to it takes to find the button. Neither of these buttons feel different by touch compared to the nearby surface. They can only be selected by looking at them. Of course if the steering wheel is not in its default position such as when the driver is making a turn, he/she has to take the eyes off the road for a few seconds. At 60 mph the car travels about 440 feet in 5 seconds. I looked up the Massachusetts Drivers Manual, on the web, about the use of the directional signals. I copied those sections below. After each section, if appropriate, I made a comment on how this affects the driving of the new Tesla https://www.mass.gov/doc/drivers-manual Commonwealth of Massachusetts Sharing the Road A User’s Manual for Public Ways p. 30 Signal properly before changing lanes p.98 Rotary Traffic Rules Traffic travels counter-clockwise in a rotary. Always yield the right-of-way to vehicles already in the rotary (unless told differently by signs or police officers) and to pedestrians. Use your turn signals in the same way as any other intersection. Travel through the rotary and, when you are ready to exit, use your right turn signal. (Comment) A few times a week I dri

11/14/2022

Malfunctioning system: AUTOPILOT, Self Driving. The vehicle is available for inspection. We were put at RISK following having several 'NEAR MISS' incidents. None of which resulted in an accident. The 2022 Model S PLAID with less than 2,929 current miles as of this entry, while being driven in daylight & evening hours on major freeways and interstate roads in Central & Southern California while using the "AUTOPILOT" FULL SELF DRIVING (FSD) has multiple times for NO APPARENT REASON & WITHOUT WARNING suddenly 'PANIC' BRAKED the vehicle from freeway speeds to less than 30 MPH. In one instance this caused the late model vehicle following us to take immediate evasive action and swerve into the adjacent lane without warning and then the vehicle HONKED continuously at us while passing us to our left. On each of the occasions I have had to OVERRIDE the Autopilot by pressing on the accelerator pedal as soon as I realized what was happening! On other occasions when in 'AUTOPILOT' self-driving mode, the vehicle has attempted to change lanes to exit the highway without awareness of how close the vehicle was to the end of the exit lane. Again I had to OVERRIDE the Autopilot by turning the yoke back into the lane to avoid running into barriers. I had believed that because this is a 'BETA' version that these conditions were being worked on and would be corrected with a software update. I have had numerous software updates installed. The current Version is 2022.44.30.10. For this reason, I have not reported these incidents to the manufacturer or made an appointment with the Local Tesla Service Center. The problems continue even with the current software update. Until recently, I was unaware of others having these same issues or that significant injury, death, damage, have occurred. However, since being made aware of this problem, I chose to report my experiences. I will follow-up and make an appointment with the manufacturer to have the vehicle inspected.

1/22/2023

Dangerous Phantom Braking: this has occurred many times including very dangerous situations in high speed interstate hwy settings. The car will slam on the brakes for no apparent reason often with cars following closely behind. I have completely stopped using “full self driving” as it is a death trap and people will certainly die because of its use.

6/12/2023

The OEM Michelin rear tire used on the 2021 and 2022+ Tesla Model S has a serious safety defect which results in extreme wear/tread separation at the inner sidewall/tread junction. Numerous defective tires are shown on this thread, among others: https://teslamotorsclub.com/tmc/threads/plaid-21%E2%80%9Drear-tire-woes-factory-defect.269394/ Both Tesla and Michelin report the tires are nationwide backorder (likely due to the number of tire failures in the field). Thus far, Tesla and Michelin have taken NO action on proactive tire replacements, despite repeated requests. (Perhaps they are awaiting accidents with fatalities first?) Please take action to secure a recall as this defect is extremely difficult to note as the tire tread separation occurs most often at the inner sidewall of the rear tires, a nearly impossible area to inspect.

10/11/2022

Rear tires have alarming wear on the inside, where the inside sidewall meets the tread. This is identical to the other complaints that are logged on NHTSA about Michelin Pilot Sport 4S rear tires on Tesla Model S Plaid cars. Tires are: Michelin Pilot Sport 4S 295/30 ZR21 102Y XL BSW. Specifically, the right rear tires loses pressure and needs to be reinflated. The left rear tire, according to inspection, actually looked worse, but is not yet losing pressure. This is impossible to see or know about without removing the tire or putting the car on a lift, since it is on the is inside sidewall/tread of the rear tire. There is high danger of a blowout because of some type of defect (camber/suspension or tire) which cannot be seen by the consumer. I would have never known about this if the tire technician had not alerted me, and probably would have had a high-speed blowout.

12/19/2022

1. When I was driving, the left rear door suddenly opened by itself. 2. It would cause car accident, injures and even death. 3. I haven't go to the service center yet, because it's very hard to make a timely appointment with Tesla. 4. No. 5. No.

1/13/2023

Windshield cracked after preheating the car and pulling out of driveway in cold weather. Saw and heard the crack happen. Found hundreds of other complaints online of owners reporting similar issues. Brought into Tesla dealer and they claim it was from an external windshield chip that then spread although no external chip was present. They seemed very knowledgeable about this issue and trained to try to not cover this under warranty.

2/6/2023

The gear shifter is unreliable without visually checking the gears on screen. It may or may not register the shift during selection. When merging from residential traffic to a main road turning right, the driver has to pull forward to check the incoming traffic. In ideal situation, if the other vehicles are approaching at speed, the driver would want shift in to reverse and backup from hanging over main road and back to the residential alley. However the inconsistencies of the gear selector make it dangerous during those occasions. The car could fail to register the shift, or cannot shift fast enough to reverse. It poses significant risks to the driver and other vehicles on the road. A front/rear cross traffic alert or a better mechanism to shift into reverse should be implemented. The mounted secondary gear selector in the center console does not light up during this cases, it it still require a visual check when defeat the purpose during emergency.

1/5/2023

When slightly pressing the accelerator while at speeds between approximately 35-70 MPH, there appears to be a vibration felt in the front of the car. It can be felt in the yoke and the pedal. It could affect the driver's ability to break or turn the wheel in emergency. It appears more than 60% of the owner of the same model and year has detected a similar shaking in the yoke and pedal, yet the manufacture delays to resolve it. https://teslamotorsclub.com/tmc/threads/poll-vibration-felt-when-slightly-accelerating-refresh-mode-s-plaid-or-lr.236933/

1/18/2023

My car has 10K miles and rear wheels started to layer off. This is the same issue as many other reporting on the web. I tired to reach out to Tesla but they deny any responsibilities. Something needs to be done ASAP before people will get hurt. I am lucky that I noticed this issue.

2/14/2023

Tire separation on the inside rear tires. I purchased my car new and had continued slight loss of air pressure at 12,000 miles. I inspected the rear tires and found one of the tires and begun to split open (at the seam where tread adheres to the tire), the other tire once sprayed with soap water had tiny pin hole leaks all the way around the same seam. I had tires replaced and filed a tire warranty claim. The original tires were Michelin Pilot Sport 4S and the tires I replaced them with were the same. Now at 30,343 miles the same problem occurred, both tires show separation around the inside seam with the tread still remaining. If left uncorrected/addressed the tires would eventually blow out driving.

2/10/2024

The Left headlight does not work and the airbag compartment is protruding out at a weird angle. This has been like this since delivery.

4/28/2022

Today I parked my car front of my house after couple ours I heard the voice and when I come close to my car I see the airbag is deployed I want you know the car doesn’t have any impact any accident when the airbag is deployed the car was off

10/31/2023

I have used the self driving feature of my 2022 Tesla Model S on several highway trips, most recently a round trip between Seattle and Palm Springs. The following problems with the Tesla self driving feature were noted. (My car has only the basic self driving feature, not the full self driving upgrade) 1. Random “phantom braking” where the car, without apparent reason, suddenly braked. 2. On several occasions the car abruptly swerved off toward an off ramp. I think this occurred when the white line marking the side of the road was interrupted by the off ramp where there was no painted line. 3. On several occasions when the turn signal was activated in order to change lines the car started to move over into the adjacent lane but abruptly swerved back to the original lane. I was able to maintain control but it was a frightening event. Due to the unpredictable nature of these events I greatly reduced my use of the fsd feature.

5/5/2022

The update that you required for Auto Steer has made the car undrivable. I get a written and audible warning IMMEDIATELY when I engage Auto Steer. Literally within 2 seconds. I always keep my hands on the wheel, lightly, while I drive on the highway. Anything short of a death grip on the wheel causes the warning to go off. However, the nag feature (after the changes you required) goes off constantly. Honestly, it's very distracting. If I look at the radio to change the channel, the warning goes off. You need to undo the changes you required. It makes Auto Steer less safe, not more.

2/17/2024

Factory oem tire separated on the driver side rear. This could have ended badly had i not noticed the difference in handling of the vehicle. It appears the rear camber of the vehicle causes strain on the inner side of the tire and there is zero calibration that can be made to help fix this. Tesla told me it’s a Michelin issue and Michelin says it’s a Tesla suspension issue.

9/28/2022

The contact owns a 2022 Tesla Model S equipped with Michelin tires, Tire Line: Pilot Sport 4S Tires, Tire Size: 295/30/ZR21, DOT Number: 4M5203DX4321. The contact stated that while driving at various speeds, TPMS warning light was illuminated. The contact took the vehicle to an independent mechanic where it was discovered that the tread inside both rear tires had severely worn to the extent that the wires inside both tires were exposed. The contact was informed that the failure could have led to a severe tire blowout. The mechanic also informed him that the failure was caused by a vehicle misalignment. The manufacturer was notified of the failure and the contact was informed that a diagnostic test was needed to determine the cause of the failure. The tires were not replaced. The failure mileage was approximately 10,000.

10/14/2022

Tire sidewall delaminated above the DOT markings. Vehicle purchased new, with only 8500 miles. No tires impacts and tire pressure maintained within recommended PSI (automatically remotely monitored by vehicle). Second rear tire to fail within last 500 miles of driving - failed in exact same way, and exact same place -delaminated above the DOT markings.

9/12/2023

Tire sidewall delaminated above the DOT markings. Vehicle purchased new, with only 8500 miles. No tires impacts and tire pressure maintained within recommended PSI (automatically remotely monitored by vehicle). Second rear tire to fail within last 500 miles of driving - failed in exact same way, and exact same place -delaminated above the DOT markings. 295/30ZR21 Michelin Pilot Sport 4 S T2 Acoustic

9/12/2023

The manual door release on the front passenger side of my car was released automatically without anyone in the seat. I was the only one in the car. I was making a turn off of an exit and went over the seam between the bridge and the street. After I went over the seam, the front passenger door manual release was triggered and opened the door. I was able to pull over the close the door immediately after. This is a route I take daily for work and haven't had this problem before. This is a safety issue should someone been sitting in that seat or if there was a car to the right of me and the door fully opened outward. This could result in someone potentially falling out of the car or an accident if someone hit the door if it had swung out. I have tried to reproduce the problem and it has not done it since 3/13/2025 at 4:27pm when the original incident occurred. I did receive an error on the screen stating the manual release button was triggered when I went over the bump. I have tried to book an appointment with Tesla to investigate, but the earliest appointment they had available was April 1, 2025.

3/17/2025

Driver door does not unlock after a trip, with passengers inside the vehicle. Driver is unable to exit the vehicle from the driver door. This has happened a couple times now, a Tesla mechanic stopped by after the first time, but didn’t find any issue. It’s happening again.

6/12/2025

The 3 rear-looking cameras display 3 images to the center display, when the car is in reverse. I rely on them as I pull my car into the narrow opening of my garage stall at home. The opening is for a single car, & has pillars on either side, allowing 8-9", total, clearance with mirrors folded. Even with mirrors extended, I have limited visibility to the clearance of the sides of the car, as they pass the pillars. The repeater cameras, in the front fenders, are a great support to see the garage as I back into my garage. However, the UI, immediately upon selecting 'Reverse' while near the home garage, conceals 50% of these side images from view with a pop-up rectangular user interface (UI) -- ruining any advantage I have to see the rear as I pass these obstacles. As a result, I have to dismiss the pop-up UI & avoid triggering the controls within it, by making a sliding motion on the center display, with my fingers applied to the UI. This is a problem because: 1) the UI displays the option to trigger one of my 3 garage doors, each of which have an associated homelink rectangular button. This is useless when the garage is already open. 2) I'm in reverse, so I'm trying to back-in to the garage in one motion. Adding an extra steps, by clearing this obscuring UI distracts. 3) With tight clearances added problems are: trash might lie outside the garage; items can be left in my garage stall; people could be nearby. Distractions mess this up. Tesla likely fails: a) that the garage could already be activated to be open (or even opening) -- & therefore, tends to prompt the user multiple times, while parking; b) that 3 homelink garages are at the home. They didn't budget screen real-estate to show the homelink buttons without obscuring the backup display-screens assigned to each of the 3 rear-ward facing cameras; c) that a driver prefers to back-in to the parking space, relying on views of the 3 cameras to avoid obstacles. Tesla counted on people to forward to park.

3/9/2022

Inner tire tread only wears significantly to the point of failure. This may be a factory alignment issue or other but is noted in many forums. I was losing air quickly and based on research saw this was a common issue with these specific cars. The tread appears fine at 8000 miles but when removing the wheel from the car you can notice the inner surface only is worn to the point of failure with the inner belt showing is parts. I was able to remove the wheel and see the issue before experiencing a blowout while driving.

10/27/2022

1) Lower drivers knee airbag panel improperly installed. Photos available. 2) This could cause malfunction of the airbag in an accident 3) No response from Tesla service when reported in the Tesla App, and in person. 4) No, but I have photos and the EPC identifies the parts in question. 5) Loose trim panel made the problem apparent, noted at delivery. Noted loose and broken lower dash trim panel under the steering Yoke. Upon investigation, noted the panel was designed to be held in place by 4 circular magnets, two on the panel and two on the lower dash support. However, in this case, a 10mm high strength steel bolt with a torque stripe was inserted into the mating magnet on the lower dash structure. The strength of the magnet was such that the bolt was apparently fully seated. The problem was, where did this bolt belong? It was found the adjacent lower panel was the knee airbag panel was designed to be secured by two 10mm bolts, and one was missing! The errant bolt was placed into the proper hole and torqued per the SM. The passenger side panels and bolts were found to be properly installed, and torque striped. I believe the placement of the Yoke makes it difficult for assembly personnel to ensure the airbag bolt is placed into the proper hole, and the magnet keeps the bolt in position when it is incorrectly placed. The problem is this leaves the lower knee airbag secured by a single bolt, and that is a potential safety concern. Please contact me for photos and supporting documents.

2/23/2023

Vehicle became immovable due to sudden rear motor failure. Vehicle came to a complete stop in moving lanes of traffic with minimal warning to react.

9/10/2023

Tesla Vision is the ADAS sensor system in the car which relies exclusively on video cameras with no LIDAR or ultrasonic sensors to measure distance. It is highly inaccurate and prone to failure. It consistently reports false warnings and fails to identify actual threats.

9/20/2023

Tesla Vision is the ADAS sensor system in the car which relies exclusively on video cameras with no LIDAR or ultrasonic sensors to measure distance. It is highly inaccurate and prone to failure. It consistently reports false warnings and fails to identify actual threats.

9/20/2023

The contact owns a 2022 Tesla Model S. The contact stated that while reversing in her driveway, the front driver's side camera did not indicate there was a gate in the viewing area. The driver crashed into a metal gate on her property. The front bumper was damaged. There was no beeping sound while approaching the object. There were no warning lights illuminated. There were no reported injuries. The vehicle was taken to a body shop, where it was diagnosed that the bumper needed to be replaced. The rear bumper was damaged while at the body shop. The mechanic stated that the clips were missing. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The contact removed the USB and was unable to locate the incident. The manufacturer was contacted, who referred her to an approved body shop. The approximate mileage was 11,544.

1/30/2024

The driver side rear view mirror vibrates at most speeds in a way that renders it useless. This is a well described issue. Tesla is aware of it but refuses to fix it. It renders the mirror useless at some speeds.

1/27/2025

The contact owns a 2022 Tesla Model S. The contact stated while the vehicle was parked and occupied, the message “Electrical System Power Reduce - Vehicle will Shut down” was displayed. The contact stated the vehicle had stopped charging and turned off once removed from the charger. The contact stated that the message “Climate Keeper Unavailable Due to System Fault” was displayed. The vehicle was towed to the dealer where it was diagnosed and determined that the battery needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 47,000.

4/15/2025

Driver door does not unlock after a trip, with passengers inside the vehicle. Driver is unable to exit the vehicle from the driver door. This has happened a couple times now, a Tesla mechanic stopped by after the first time, but didn’t find any issue. It’s happening again.

6/12/2025

The front right door top hinge bolts fell out. Believe the bottom one is broke off. Also have vehicle has a seat belt warning alarm indicated. There is a vehicle appointment scheduled for the Thursday August 14, 2025. Did not notice any warning signs. The door separated in the parking lot of a food establishment.

8/11/2025