2023 Hyundai Santa Fe Owner Complaints

I bought a brand new 2023 Hyundai Santa Fe. Not even one month later the panoramic sunroof exploded while I was driving on the interstate at 75 mph. There were no warning lamps, messages or other signs that this would/could happen prior to the incident. I was not informed by the dealership that this could happen, but they were aware it could happen. I was told by the Sales Manager, “We wouldn’t sell the cars if we informed consumers”. I had the screen cover closed, so I was very fortunate because it could have caused a major accident on the interstate if it was open and glass exploded all over me and got in my eyes. Hopefully the vehicles behind me did not have any damage to their vehicles from the glass. I was not told if it is available for inspection. I was only told that it would be replaced. This problem is happening since 2012. There have been multiple class-action lawsuits with multiple car brands that have panoramic sunroofs.

4/19/2023

While traveling on state highway I heard a sudden, loud pop, similar to a gunshot sound. I looked everywhere and noticed that the sunroof was shattered. It is panoramic and was open. The rear, unopened section was completely shattered. Upon closer inspection there is a jagged hole about 1.5 inches in length in the sunroof. Although the rear part of the sunroof was intact, there were shards of glass scattered throughout the cabin.

5/8/2023

2023 Hyundia Santa Fe bought brand new from the dealership. During the course of the last month and a half the vehicle has done things with unknown origin. The panic alarm will randomly go off when the vehicle is turned off, no one is in it, or even near it. By locking the vehicle with the remote, the alarm will tend to go off about 20-30 seconds after the vehicle is locked and will sometimes not stop until the vehicle is restarted. The transmission will shift very roughly almost to the point that it feels like you are driving a manual transmission vehicle. The transmission lags in gears between 60-70 miles per hour and you feel a very rough back and forth shifting with in the transmission. Next the emergency break would engaging and then not releasing or reengaging when parked on a hill, flat service or anywhere. The break light on the dash would light up, blink, then it would go off, making it unknown if the emergency break was acting engaged or not. The dealership I purchased it from did replace the EMS module along with breaks and rotors on the vehicle. The auto shut off or the idle shut off will also randomly work, and not work. it will cut on and off even if the button is pressed to shut it off or prevent it from coming on. Now the air condition, along with the heat and heated seats has started to not work, randomly cut on, will not cut off etc. While driving i have had the heated seats turn on, along with the heat and not go off, nothing would cut off until the vehicle was physically turned off and restarted. No codes have ever been displayed or found by the dealership.

4/25/2023

Car was purchased January 21st had 3000 mile on it when service was needed for these issues. On march 23rd as I started driving my car wouldn't go above 30 mph, when pressing on the gas pedal the car wouldn't accelerate, the rpm gage would go to 4 but engine wouldn't make noise car wouldn't speed up. I put the car in park and back in drive with no improvement. I pulled off at a gas station restarted the car and it was fine. During this time the auto on off button was orange on the cluster which I had never seen it that color before. Was looked at by the dealer but wasn't reproducible. Not sure the cause, but safety was in jeopardy due to not being able to go with speed of traffic. Also a couple weeks after purchase brakes began to squeal, took car to dealer on march 28th was told brake pads were sanded and cleaned, upon leaving dealer brakes continued to squeal, car is now back at dealer, supposedly needing front rotors and pads replaced. Dealer won't drive car until rotors replaced. Safety was in jeopardy cause of possible brake failure and resulting accident.

5/9/2023

Driving at 25 mph and the vehicle alerted "shift to neutral" and came to a complete stop and stalled. Had no warning, couldn't even pull to side of road. Could not start again and had to be towed.

7/19/2023

May 5th 2023 my car was broken in to.The back passenger window was broken out and the steering column was tour out .The car was undrivable. The car was towed May 18th to Nalley Hyundai.I just got my car back today Aug 11. I understand Hyundai is suing TikTok I was given a number.She said when they go to court.When .

8/11/2023

2023 Hyundia Santa Fe bought brand new from the dealership. During the course of the last month and a half the vehicle has done things with unknown origin. The panic alarm will randomly go off when the vehicle is turned off, no one is in it, or even near it. By locking the vehicle with the remote, the alarm will tend to go off about 20-30 seconds after the vehicle is locked and will sometimes not stop until the vehicle is restarted. The transmission will shift very roughly almost to the point that it feels like you are driving a manual transmission vehicle. The transmission lags in gears between 60-70 miles per hour and you feel a very rough back and forth shifting with in the transmission. Next the emergency break would engaging and then not releasing or reengaging when parked on a hill, flat service or anywhere. The break light on the dash would light up, blink, then it would go off, making it unknown if the emergency break was acting engaged or not. The dealership I purchased it from did replace the EMS module along with breaks and rotors on the vehicle. The auto shut off or the idle shut off will also randomly work, and not work. it will cut on and off even if the button is pressed to shut it off or prevent it from coming on. Now the air condition, along with the heat and heated seats has started to not work, randomly cut on, will not cut off etc. While driving i have had the heated seats turn on, along with the heat and not go off, nothing would cut off until the vehicle was physically turned off and restarted. No codes have ever been displayed or found by the dealership.

4/25/2023

Driving at 25 mph and the vehicle alerted "shift to neutral" and came to a complete stop and stalled. Had no warning, couldn't even pull to side of road. Could not start again and had to be towed.

7/19/2023

All lights that come on when you first start the vehicle stay on. ABS, forward collision, rear collision, side mirror check, down hill brake, etc. The brakes and brake pedal would lock up when attempting to brake. Pedal stays locked but the wheels didn’t seem too. Brake system wouldn’t respond to pumping the brakes the pedal stayed frozen. It could have caused me a serious accident.

4/2/2023

2023 Hyundia Santa Fe bought brand new from the dealership. During the course of the last month and a half the vehicle has done things with unknown origin. The panic alarm will randomly go off when the vehicle is turned off, no one is in it, or even near it. By locking the vehicle with the remote, the alarm will tend to go off about 20-30 seconds after the vehicle is locked and will sometimes not stop until the vehicle is restarted. The transmission will shift very roughly almost to the point that it feels like you are driving a manual transmission vehicle. The transmission lags in gears between 60-70 miles per hour and you feel a very rough back and forth shifting with in the transmission. Next the emergency break would engaging and then not releasing or reengaging when parked on a hill, flat service or anywhere. The break light on the dash would light up, blink, then it would go off, making it unknown if the emergency break was acting engaged or not. The dealership I purchased it from did replace the EMS module along with breaks and rotors on the vehicle. The auto shut off or the idle shut off will also randomly work, and not work. it will cut on and off even if the button is pressed to shut it off or prevent it from coming on. Now the air condition, along with the heat and heated seats has started to not work, randomly cut on, will not cut off etc. While driving i have had the heated seats turn on, along with the heat and not go off, nothing would cut off until the vehicle was physically turned off and restarted. No codes have ever been displayed or found by the dealership.

4/25/2023

I purchased this SUV new and noticed an issue with the automatic intermittent wipers. The dealership has replaced the windshield sensor and issue is now unreliable at best. Service department told me to simply wipe the sensor off or pour water onto the sensor to get the wipers to work. That seems to work for about 3 wipes and then stops again. Also, the driver seat changes position by itself while driving, and the advanced cruise control failed to provide any braking and almost caused me to rear end a stopped car in freeway traffic. Additionally the advanced braking system does not work at all... I had the salesman check the settings and they are turned on, but do not provide any braking function. The alert system does provide a warning if a car turns a corner in front of me, but fails to take any action.

12/23/2022

I bought this Lemon on 1/14/2023. The front collision detection doesn't brake to avoid collision. The Emergency brake will engage on it's own, and it has to be manually disengaged. The parking assist feature will automatically disengage and is unable to engage it. The middle seat in the back seat headrest obstructs a major portion of the rear window, obstructing the driver's view. It is not the headrest pictured in the Owner's Manual. It has been in the shop twice. It has been in the shop for 10 days and counting of the 34 days I have owned this lemon of a vehicle. The car was taken to the dealer for repairs but consumer was told the vehicle functioned properly. The consumer stated the car was still malfunctioning so vehicle was taken back to dealer for repairs and still being assessed.

2/21/2023

Forward collision warning system engaged unexpectedly, braked hard to the point of smelling burnt tires. No collision imminent. Normal driving conditions. On a second occasion, stopped at a traffic light, the vehicle suddenly warned of foward parking collision. Front camera engaged and yellow warning showed

9/3/2022

I bought this Lemon on 1/14/2023. The front collision detection doesn't brake to avoid collision. The Emergency brake will engage on it's own, and it has to be manually disengaged. The parking assist feature will automatically disengage and is unable to engage it. The middle seat in the back seat headrest obstructs a major portion of the rear window, obstructing the driver's view. It is not the headrest pictured in the Owner's Manual. It has been in the shop twice. It has been in the shop for 10 days and counting of the 34 days I have owned this lemon of a vehicle. The car was taken to the dealer for repairs but consumer was told the vehicle functioned properly. The consumer stated the car was still malfunctioning so vehicle was taken back to dealer for repairs and still being assessed.

2/21/2023

I purchased this SUV new and noticed an issue with the automatic intermittent wipers. The dealership has replaced the windshield sensor and issue is now unreliable at best. Service department told me to simply wipe the sensor off or pour water onto the sensor to get the wipers to work. That seems to work for about 3 wipes and then stops again. Also, the driver seat changes position by itself while driving, and the advanced cruise control failed to provide any braking and almost caused me to rear end a stopped car in freeway traffic. Additionally the advanced braking system does not work at all... I had the salesman check the settings and they are turned on, but do not provide any braking function. The alert system does provide a warning if a car turns a corner in front of me, but fails to take any action.

12/23/2022

Driving on highway with cruise control selected to 80 mph. Left signal is applied to travel to left lane to pass a semi trailer. When the vehicle is half way into the left lane, the automatic system applies hard braking even though the semi trailer has not been detected as too close. Vehicle slowed to 74 to 75 mph before cruise control was turned off. Vehicle behavior is a total surprise to vehicles following since the braking is unexpected on a clear road. Repeated the symptoms several times. This braking does not occur if the vehicle ahead in the right hand lane is an automobile. This only occurs if it is a large vehicle such as a semi. Moving quickly or slowly to the passing lane affects the total time the braking is applied. The slower the movement, the longer the braking is applied. Repeated this behavior at 75 mph and 70 mph with similar results.

6/2/2023

I purchased this SUV new and noticed an issue with the automatic intermittent wipers. The dealership has replaced the windshield sensor and issue is now unreliable at best. Service department told me to simply wipe the sensor off or pour water onto the sensor to get the wipers to work. That seems to work for about 3 wipes and then stops again. Also, the driver seat changes position by itself while driving, and the advanced cruise control failed to provide any braking and almost caused me to rear end a stopped car in freeway traffic. Additionally the advanced braking system does not work at all... I had the salesman check the settings and they are turned on, but do not provide any braking function. The alert system does provide a warning if a car turns a corner in front of me, but fails to take any action.

12/23/2022

Windshield cracks

2/26/2023

Stopped at left turn lane light. Light turns green and vehicle engine revolutions increase as I press on gas pedal but car does not move. Cars behind me lean on their horns and take evasive maneuvers to go around me. Car finally goes very slowly and transmission disengages in middle of left turn leaving vehicle in middle of intersection with oncoming traffic. Luckily everyone stopped and vehicle very slowly moved through the intersection to side of road. Vehicle is brand new and in my possession less than 48 hours. Vehicle is at dealership for troubleshooting.

4/18/2023

Several times lately of extended crank. Saturday evening, car had been parked for 4 hours, did remote start and had extended crank of about 2 seconds. Car ran for about 3 minutes before we left. We left home and hit main road, tried to accelerate and vehicle seemed to go into limp mode. Would keep cutting the fuel out if tried to accelerate even above 40 mph. No check engine light came on. Put in neutral, could not get above about 3500 rpm. Vehicle was in smart mode where decides which mode to be in (normal, fuel economy or sport), when would try to accelerate it would try to change to sport as it knew power was not there. Was on a 6 lane highway and could not get up to speed. Finally was able to pull to side of road, shut engine off, waited a few seconds, restarted and issue went away, still no check engine light. I have contacted my local dealer, they said they have seen on another vehicle, was not sure of outcome, having service manager call me. Lots of complaints online forums of similar issues.

6/24/2024

Driving on highway with cruise control selected to 80 mph. Left signal is applied to travel to left lane to pass a semi trailer. When the vehicle is half way into the left lane, the automatic system applies hard braking even though the semi trailer has not been detected as too close. Vehicle slowed to 74 to 75 mph before cruise control was turned off. Vehicle behavior is a total surprise to vehicles following since the braking is unexpected on a clear road. Repeated the symptoms several times. This braking does not occur if the vehicle ahead in the right hand lane is an automobile. This only occurs if it is a large vehicle such as a semi. Moving quickly or slowly to the passing lane affects the total time the braking is applied. The slower the movement, the longer the braking is applied. Repeated this behavior at 75 mph and 70 mph with similar results.

6/2/2023

Over the last Tom th, I have encountered some pretty scary issues with my brand new Santa Fe purchased in April. Last week, while driving, after I turned on adaptive cruise control, the system alerted me that “smart crusade control conditions weren’t met” and kept trying to engage the front left brake — this occurred three days in a row. After turning off the smart cruise control and entering residential roads, the front left brake tried to engage in a manner that seemed consistent with ABS issue. I brought car in two days later to Dublin Hyundai and they said they couldn’t find anything wrong with it. I picked the car up yesterday morning and then last night while driving on the highway, it alerted me that I need to “check highway drive assist system” and a warning light came up. After about 5 minutes, the car jerked me incredibly hard to the left on the freeway and then athe light turned off. Then two days ago, I was driving my car on the highway the car randomly said “emergency braking system activated” twice, while going 70 on the freeway in the middle of nowhere. This was while driving safely and no cars nearby either time. I looked online and it appears this is a problem that’s occurred in many Santa Fe’s, so there is clearly an issue with manufacturing (which I’m assuming is the same case as the previous issues I’ve run into).

7/6/2023

4/27/23 - Panoramic sunroof exploded going over a bridge. Front glass panel only. No advance warning. Shade was closed and no glass entered cockpit. Local PD responded and saw no evidence of impact or criminal activity. Vehicle is at local dealership for warranty repairs.

4/28/2023

Sunroof exploded at highway speed glass was contained by interior fabric. Sounded like tire or gun shot . Was able to stop but frightened. Took to dealer and left it. Car has less than 3500 miles on it.

3/15/2024

I bought this Lemon on 1/14/2023. The front collision detection doesn't brake to avoid collision. The Emergency brake will engage on it's own, and it has to be manually disengaged. The parking assist feature will automatically disengage and is unable to engage it. The middle seat in the back seat headrest obstructs a major portion of the rear window, obstructing the driver's view. It is not the headrest pictured in the Owner's Manual. It has been in the shop twice. It has been in the shop for 10 days and counting of the 34 days I have owned this lemon of a vehicle. The car was taken to the dealer for repairs but consumer was told the vehicle functioned properly. The consumer stated the car was still malfunctioning so vehicle was taken back to dealer for repairs and still being assessed.

2/21/2023

My car won’t shift on the highway and all of a sudden I can’t drive more than 40mph. It also has not wanted to let me press on the gas and make it go as I’m driving bc Its jerking 4 or 5 times before it’ll register and go. Also, not too long ago, I was in a parking lot and went to leave and my car never notified me that there was a huge pillar next to me and I crashed into it, it was in my blind spot and couldn’t see it. My car has had many many other issues in which I can’t list, but I truly bought a lemon.

4/15/2025

Driving at 25 mph and the vehicle alerted "shift to neutral" and came to a complete stop and stalled. Had no warning, couldn't even pull to side of road. Could not start again and had to be towed.

7/19/2023

May 5th 2023 my car was broken in to.The back passenger window was broken out and the steering column was tour out .The car was undrivable. The car was towed May 18th to Nalley Hyundai.I just got my car back today Aug 11. I understand Hyundai is suing TikTok I was given a number.She said when they go to court.When .

8/11/2023

Tire inside sidewall blew out on rear right tire. No curb, no pothole. 40mph speed

6/19/2024

Driving up steep hill to my mom’s house car would not drive up, as it hesitated I pressed gas pedal to no avail. I turned off car, got out & nothing was blocking me. Turned car back on & accelerated, this time it went forward.

7/21/2024

The seat belt in the middle seat of the second row did not work. And it was not fastened. So when braking, my child was thrown toward the center console. I think it's a big safety issue if the seat belt doesn't work.

11/5/2024

Driver and passenger seatbelts not always latching or becoming unlached while driving

9/26/2025

Stopped at left turn lane light. Light turns green and vehicle engine revolutions increase as I press on gas pedal but car does not move. Cars behind me lean on their horns and take evasive maneuvers to go around me. Car finally goes very slowly and transmission disengages in middle of left turn leaving vehicle in middle of intersection with oncoming traffic. Luckily everyone stopped and vehicle very slowly moved through the intersection to side of road. Vehicle is brand new and in my possession less than 48 hours. Vehicle is at dealership for troubleshooting.

4/18/2023

See attached document for complaint

4/10/2024

I was recently involved in a front side swipe accident where a person ran a red light and hit me while I was passing through an intersection. The impact was all in the front of the vehicle where the air bag had deployed. The air bag caught on fire within seconds after it had deployed. Thankfully I was conscious to where I was able to unbuckle my seat belt quickly and someone came to my aid quickly enough to where I was able to exit the vehicle safely.

7/8/2023

I had adaptive cruise control on and debris hit my windshield and I went into the rumble strip and eventually into the guard rail where the car essentially pingponged from there until it eventually stopped when the metal hit the front. It appears the emergency brake did not activate and the lane keep did not activate. My air bags did not deploy.

3/20/2025

when driving in the rain, the driver side (left) blind spot is not functional. When the right turn signal is used, the camera shows the right side of the car and the triangle on the right mirror lights up if there is vehicle in the blind spot. In the rain, the camera lens is as clear as when it is not raining. when the left turn signal is used, due to poor aerodynamics, there is a large drop of water on camera lens which prevents driver from seeing the blind spot on the left side. The large drop of water is displayed on the dash instead of the left side of the vehicle.

7/23/2023

Vehicle does not detect motorcycles in the blind spot. I did not look over my shoulder and began moving left with a turn signal when I glimpsed a motorcycle next to my vehicle. The motorcycle quickly swerved to the left and I returned to the right lane.

2/2/2024

Sunroof exploded while traveling at highway speeds causing glass to fall into the cabin. No impact from rocks, just exploded out of nowhere. Massive loud explosions sound

12/28/2023

The contact owns a 2023 Hyundai Santa Fe. The contact stated while driving 70 MPH, the panoramic sunroof exploded. The panoramic sunroof glass and the shades were closed. No warning light was illuminated. The vehicle was taken to the dealer. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 9,100.

3/5/2024

Incident: I have been almost rear ended numerous, numerous times despite having my turn signal on an appropriate distance from my turning point. Safety Issue: The rear signal lights are small and are only located on the bumper. The location of these signal lights are way too low for most driver's to even notice them! The signal lights also look like reflectors on the rear bumper especially in broad day light, making the detection of a signal even more difficult! I do like the Santa Fe, it is my second one, but had I known that the turn signal lights were located where they are, I would have NEVER purchased this vehicle as the risk of getting rear ended is too high.

2/16/2024

My wife was parking the car at carport, all of sudden unintended acceleration happened and hit through the wall. The damage on the car was $12478.57 and damaged the wall and storage on both sides of carport. My wife is scared to drive this car.

6/11/2025

I've been driving in Arizona on southbound [XXX] just south of [XXX] and noticed an issue that is very odd. I have a 2023 Hyundai Santa Fe that has Highway Driving Assist that does both speed control and distance from the vehicle ahead of me and Lane Keeping Assist. After I pass [XXX], but before an overpass for [XXX], my vehicle, if those systems are on, goes haywire and all those safety systems turn off. I have experienced it on at least 3 of the lanes on that stretch. It happens both early in the am and later regardless of sun. It doesn't happen on northbound. As more cars have these features, this interference should be looked in to. I have not experienced this on any other of our highways. Here's a link to the the rough location. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

5/3/2024

Currently have 518 Diagnostic History Codes (DTC)in memory. Additionally, I have 3 Active DTC’s. The codes are: DTC C160C87 DTC System CHASSIS DTC Sub System LKAS, and DTC C160C87 DTC System CHASSIS DTC Sub System SCC, and DTC C163881 DTC system CHASSIS DTC Sub System SCC FIRST OCCURRENCE: during actual assembly in Montgomery, AL plant. I have asked three Hyundai Service dealers for help. All have tried. Noting noted that contributes to the issues above. At first, my dealer replaced the front camera. Was told it was a heating issue. I have contacted Hyundai BLUELINK service for help. An information report was filed, TWICE. The first report I received feedback that Hyundai’s engineers had corrected the issue. On the following day, the codes returned. A second concern was filed with Hyundai BLUELINK. Hyundai Motor America Case#: [XXX] to wit: “Thank you for contacting Hyundai Motor America. We are in receipt of your e-mail and one of our representatives will get back to you shortly. Sincerely, Hyundai Motor America” Is my vehicle going to fail and cause me injury while operating it on an Interstate highway? This is quite concerning as I drive my car. All I want from Hyundai is to get this issue repaired. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

10/23/2024

The contact owns a 2023 Hyundai Santa Fe. The contact stated that the horn was inoperable. The lower horn sound had dissipated. Then shortly after the higher horn stopped working. There was no sound when the horn pad was depressed. There were no warning lights illuminated. The vehicle was taken to the local dealer who informed the contact about the cost for the repair, but the vehicle was not diagnosed or repaired. The manufacturer was contacted, opened a case, but no additional assistance was provided. The failure mileage was approximately 72,000.

9/6/2024

The contact owns a 2023 Hyundai Santa Fe. The contact stated while driving at approximately 55 MPH, the horn was inoperative. No warning light was illuminated. The vehicle was taken to a dealer where it was diagnosed and determined that the horn needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 7,600.

1/7/2025

2023 HYUNDAI SANTA FE- Consumer states: I saw the notice on TV regarding a recall on my specific vehicle for the trailer hitch issue. I immediately contacted my local Hyundai dealership and scheduled an appointment. The Service Department concluded that my vehicle was included in the recall, I was told that they had not yet received a recommendation from Hyundai on a remedy for this fire hazard. My invoice indicates "your vehicle does have a Genuine Hyundai Towing hitch and 4-pin harness installed, there is currently no remedy available however you can continue driving the vehicle, but it is recommended that you park the vehicle outside until a remedy has been performed.April, 2023, I called the Hyundai Corporate Office and was assigned a case manager, Rohan. I suggested that Hyundai buy back the vehicle, with 5000 miles on it, because if I cannot tow my boat, it's useless to me, and also because I cannot park the vehicle in my heated 3 car attached garage. Rohan said he would try to find a local business to install a new hitch. I would have pay for it and submit the bill to Hyundai for reimbursement. The next time I heard from Rohan, he instructed me to find a local business to install the hitch. I did contact a couple local businesses and they all indicated that they wanted nothing to do with the Hyundai recall. My question to Rohan was, if he thought a private business could do the fix, why hadn't Hyundai come up with a timely fix, given the potential devastation that the outcome could have if a fire did occur. At the end of April, 2023, Rohan stopped accepting and responding to my calls. I believe that Hyundai has failed to timely remedy the towing hitch issue which, according to Hyundai, may ignite a fire even with the ignition turned off. Hyundai has known that these issues existed well before it was announced on TV in March, 2023 but did not officially notify the owners of the vehicles until the end of May, 2023. It is very unnerving driving this vehicle knowing this is the one that could catch fire anywhe

6/26/2023

The contact owns a 2023 Hyundai Santa Fe. The contact stated that while driving approximately 35 MPH, the downhill assist, traction control, auto stop, blind spot, and ABS warning lights illuminated. The contact was able to pull over and called the local dealer and was informed that the vehicle was safe to drive. While driving at an undisclosed speed, the brakes independently activated. The vehicle was taken to the local dealer, where it was diagnosed that the wheel speed sensor needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 2,000.

7/27/2023

The contact owns a 2023 Hyundai Santa Fe. The contact stated that while driving approximately 35 MPH, the downhill assist, traction control, auto stop, blind spot, and ABS warning lights illuminated. The contact was able to pull over and called the local dealer and was informed that the vehicle was safe to drive. While driving at an undisclosed speed, the brakes independently activated. The vehicle was taken to the local dealer, where it was diagnosed that the wheel speed sensor needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 2,000.

7/27/2023

The contact owns a 2023 Hyundai Santa Fe. The contact stated that on two separate occasions while driving at approximately 65 MPH, the vehicle decelerated. The check engine warning light illuminated, and a message displayed on the infotainment screen indicating “Engine System Emergency, Take Vehicle to the Nearest Dealer”. The contact was able to veer the vehicle into a parking lot where it was idled. The vehicle was then taken to the dealer where the contact was informed that no appointments were available; however, the technician used a code reader that retrieved message: “5 Volts drop to the ECM”. The contact stated that the technician then pressed the START/STOP button to restart the vehicle and reset the check engine warning light. The contact stated that he was able to drive the vehicle back to his location where he parked the vehicle. The following day he restarted the vehicle however, the failure recurred. The dealer was notified of the failure and the contact was advised that if the check engine warning light was not illuminated there was no need to have the vehicle diagnosed. The vehicle was not repaired. The manufacturer was notified of the failure, but no further assistance was provided. The failure mileage was approximately 1,108.

10/16/2023

The contact owns a 2023 Hyundai Santa Fe. The contact stated that while driving at night with the low beam headlights illuminated, there was a dark shadow present in the top section of the illuminated light field causing a visibility hazard to the driver. The vehicle was taken to the local dealer who confirmed the issue was present but informed the contact that the headlights were operating as intended. The manufacturer was made aware of the issue. The failure mileage was 10.

11/17/2023

The contact owns a 2023 Hyundai Santa Fe. The contact stated while driving at various speeds, the Forward Collision Avoidance system erroneously activated, causing the braking system to activate and the vehicle to veer to the left. The contact stated that the failure was intermittent. The vehicle was taken to the local dealer on several occasions due to the failure however, a cause for the failure was not determined. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 1,000.

11/29/2023

Windshield started to crack after 150 miles on the car from driver side spreading across whole line of sight. No visible or audible rock hit the windshield

12/16/2023

The harness does not stay tight on the child’s chest. The harness was adjusted to the correct fit, when pulled to check the tightness the harness does not stay taught. It releases without pushing the release button

3/30/2024

The harness does not stay tight on the child’s chest. The harness was adjusted to the correct fit, when pulled to check the tightness the harness does not stay taught. It releases without pushing the release button

3/30/2024

I've been driving in Arizona on southbound [XXX] just south of [XXX] and noticed an issue that is very odd. I have a 2023 Hyundai Santa Fe that has Highway Driving Assist that does both speed control and distance from the vehicle ahead of me and Lane Keeping Assist. After I pass [XXX], but before an overpass for [XXX], my vehicle, if those systems are on, goes haywire and all those safety systems turn off. I have experienced it on at least 3 of the lanes on that stretch. It happens both early in the am and later regardless of sun. It doesn't happen on northbound. As more cars have these features, this interference should be looked in to. I have not experienced this on any other of our highways. Here's a link to the the rough location. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

5/3/2024

The contact owns a 2023 Hyundai Santa Fe. The contact stated that the vehicle was overheating while driving. Additionally, the contact stated that upon noticing that coolant was leaking onto the ground, he opened the hood and discovered that coolant was leaking from the radiator. There was no warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed that a foreign object had struck the radiator, causing coolant to leak into the engine compartment. The dealer informed the contact that a failure caused by a foreign object was not covered under warranty. The vehicle was not repaired. The contact stated that upon examining pictures of the failure provided by the dealer, he noticed that there were rocks stuck in and near the radiator. The contact determined that the large gaps of the front grill were allowing foreign objects to strike the radiator. The manufacturer was notified of the failure and a case was opened; however, the case was later closed. The failure mileage was approximately 11,591.

5/7/2024

The contact owns a 2023 Hyundai Santa Fe. The contact stated that the vehicle was overheating while driving. Additionally, the contact stated that upon noticing that coolant was leaking onto the ground, he opened the hood and discovered that coolant was leaking from the radiator. There was no warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed that a foreign object had struck the radiator, causing coolant to leak into the engine compartment. The dealer informed the contact that a failure caused by a foreign object was not covered under warranty. The vehicle was not repaired. The contact stated that upon examining pictures of the failure provided by the dealer, he noticed that there were rocks stuck in and near the radiator. The contact determined that the large gaps of the front grill were allowing foreign objects to strike the radiator. The manufacturer was notified of the failure and a case was opened; however, the case was later closed. The failure mileage was approximately 11,591.

5/7/2024

I was driving at around 11 a.m. on a city road at about 30 miles per hour when front passenger tire suddenly popped and car began to swerve almost colliding with vehicle in adjacent lane. The TPMS alert showed up on dashboard after the tire popped. There were no potholes or any objects that the car hit. The car along with tires had been inspected during routine maintenance at the dealer five days prior to this incident and no issues were found on tires or any lights on the dashboard. There were also no symptoms leading up to the tire suddenly popping. I contacted the manufacturer who referred me to an authorized center. After submitting the claim at the authorized center, they provided a replacement 255/45R20 at 50 percent discount.

5/24/2024

The contact owns a 2023 Hyundai Santa Fe. The contact stated that while his wife was driving at approximately 65 MPH and depressing the brake pedal to slow for a vehicle that had passed and switched into the lane she was driving, the vehicle was shuddering. The contact stated that as soon as she had stopped depressing the brake pedal the shuddering ceased. The contact stated there was no warning light illuminated. The contact stated that the shuddering when the brake pedal was depressed was intermittent but was recurring at various speeds while slowing down. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the brake pads and rotors needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was 18,756.

10/24/2024

The contact owns a 2023 Hyundai Santa Fe. The contact stated that while his wife was driving at approximately 65 MPH and depressing the brake pedal to slow for a vehicle that had passed and switched into the lane she was driving, the vehicle was shuddering. The contact stated that as soon as she had stopped depressing the brake pedal the shuddering ceased. The contact stated there was no warning light illuminated. The contact stated that the shuddering when the brake pedal was depressed was intermittent but was recurring at various speeds while slowing down. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the brake pads and rotors needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was 18,756.

10/24/2024