2023 Hyundai Ioniq 6 Owner Complaints

The Ioniq 6 is supposed to be able to charge at 48 amps. I bought a new Ioniq 6 in early June 2023. June 12 I had the level 2 Juice Box 48 amp charger installed. At least twice (I think three times), it would stop charging after about twenty minutes — the charge port appears to be overheating in certain situations. Please have Hyundai either fix the port (or other hardware) and/or software. They may not advertise 48 amp charging when so many users are having overheating problems. They need to own this and be accountable. Precisely this happened on the Ioniq 6 to me: https://youtu.be/uXi33MtrJAU

7/8/2023

Car's onboard AC charger overheats, I can replicate every time upon charging Poses fire hazard Dealer will not confirm, but TSB's have been issued to reduce the charging current (car no longer charges as advertised at time of purchase) Inspection performed by Ioniq certified dealer Warning first appeared June 2, 2023

7/10/2023

Horn progressively not working. 2 components:high and low frequencies have died and the horn is kaput. Forty still under warranty in my case but seriously concerned for security while driving as this is sudden and unexpected!

7/27/2024

Horn stopped working 18 months into owning the car. Numerous other drivers report the same issue.

11/29/2024

My Ioniq6 slowed down to 20 mph for the second time tonight. No matter how hard I pressed on the accelerator the car would not speed up past 20 mph. A message on the dashboard said “Limit: 20 mph”. Eventually the car picked up speed then said “Limit: 43 mph”. (The speed limit on University Blvd at this point was 35 mph). I did not test that, as I was almost home. This happened around 7pm on Saturday, Nov 18, 2023. My wife was in the car with me and asked why I was driving so slowly. The first time this happened, a couple weeks ago, I don’t recall seeing a message on the dashboard. I fiddled with some of the controls on the steering wheel and it sped up. So I thought I had fixed it.

11/18/2023

Left the house, made it a few miles from the house. Loud pop from the rear seat, warning lights came up on the dash limited power and check electrical system. Was limited to 25mph to drive home. All recalls were done prior to failure. Last recall was done approx 2 weeks prior to failure. ICCU was diagnosed as the failure and was replaced.

6/3/2025

My Ioniq6 slowed down to 20 mph for the second time tonight. No matter how hard I pressed on the accelerator the car would not speed up past 20 mph. A message on the dashboard said “Limit: 20 mph”. Eventually the car picked up speed then said “Limit: 43 mph”. (The speed limit on University Blvd at this point was 35 mph). I did not test that, as I was almost home. This happened around 7pm on Saturday, Nov 18, 2023. My wife was in the car with me and asked why I was driving so slowly. The first time this happened, a couple weeks ago, I don’t recall seeing a message on the dashboard. I fiddled with some of the controls on the steering wheel and it sped up. So I thought I had fixed it.

11/18/2023

The dashboard error code (check vehicle power supply) also in the bluelink app the error code(DTC P1A9096). I was driving the car. It was 196 miles of range. The car suddenly went into turtle mode and then the car just died in the middle of the road. Luckily I was outside my residence. After waiting 4 hour for towing. I had it towed to the dealership.

12/12/2024

My Ioniq 6 Limited AWD experienced a phantom braking event in a covered parking lot with no cars or pedestrians anywhere near the front of my car. The car just stopped suddenly with a warning message "Emergency Braking", and it wouldn't allow me to proceed until I turned off the car and then turned it back on. Fortunately, there wasn't a car close behind me at the time, but it could have triggered a rear end collision. Prior to this phantom braking incident, but on the same short drive, I noticed that the car incorrectly showed a red line indicating that the driver's side of my car was extremely close to some object, even though visual inspection confirmed that there was nothing there.

12/24/2023

On the afternoon of February 12, 2024 (5:12pm), I was driving northbound on I-71 at highway speed, approximately 75mph. My Hyundai Ioniq 6 alerted me of a (non-existent) impending front-end collision, and within 1 second of the alert starting, the automatic emergency braking system activated. This resulted in the violent (and unexpected) braking of my car to around 25mph. There was no clear reason for the collision detection alert or the automatic emergency brake. The light was good and there was no significant weather. There were no vehicles immediately in front or behind me. (Nearest car in front was over a quarter mile away.) The force of the braking was sufficiently strong that I am still sore in my shoulder and back a week later. I am fortunate that there wasn't a car close behind me, as I likely would have been rear-ended due to the unexpected and abrupt nature of the braking. The vehicle was taken in for service (invoice attached) and "calibrated". Within 10 miles of getting back on the highway, warnings (but no braking) triggered again. (photo attached of one of the warnings). The vehicle is currently back at dealer service.

2/20/2024

My Ioniq6 slowed down to 20 mph for the second time tonight. No matter how hard I pressed on the accelerator the car would not speed up past 20 mph. A message on the dashboard said “Limit: 20 mph”. Eventually the car picked up speed then said “Limit: 43 mph”. (The speed limit on University Blvd at this point was 35 mph). I did not test that, as I was almost home. This happened around 7pm on Saturday, Nov 18, 2023. My wife was in the car with me and asked why I was driving so slowly. The first time this happened, a couple weeks ago, I don’t recall seeing a message on the dashboard. I fiddled with some of the controls on the steering wheel and it sped up. So I thought I had fixed it.

11/18/2023

While driving in the highway I took my foot off the accelerator and despite one pedal driving being on the car did not brake. I then tapped the brake. When I then pushed the accelerator to keep up with traffic, nothing happened. I checked the screen for warning lights. The car had none. The accelerator pedal was non responsive causing a huge safety issue for me and others on the road as the car was now just cruising as I was approaching a hill..I had to turn on my hazards and get over into the shoulder of the highway along the bridge at night. I stopped the car. There were still no warning lights on. I turned the car off and back on and the problem was no longer present.

2/20/2024

The horn stopped working. I was not able to warn other drivers they were cutting me off. The problem has been confirmed by the dealer. The high pitch horn was replaced and the low pitch horn was ordered for replacement. There were no warning lights or blown fuses.

5/2/2024

The contact owns a 2023 Hyundai Ioniq6. The contact stated that while driving approximately 20-30 MPH and attempting to use the horn, the contact discovered that the horn was inoperable. There were no warning lights illuminated. The vehicle was taken to the local dealer where it was determined that the horn needed to be replaced. The vehicle was repaired, but the failure recurred. The dealer failed to pre-order the part for the repair. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 12,500.

10/21/2025

Headlights do not illuminate the road properly, there are dark spot in front of the car specially on the driver side. Making a turn there is ZERO visibility ( almost went into the median road ) because I do not see anything on the sides. The headlights do not " flood the road " Hyundai say this about the headlight and is very misleading. I drive a lot specially at night I am afraid to drive the car like that. A 2023 52k should not have these issues. BIG safety issues. To have a dealer check the car out I have to wait a month, so I am waiting. Please see the link below here is what Hyundai says about the " state of the art " headlights. Even driving in the city visibility is very bad. [XXX] . Thanks. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

12/19/2023

The contact owns a 2023 Hyundai Ioniq 6. The contact stated that while reversing, the brake lights interfered with the optics of the back-up camera. The inference caused the camera image to be distorted which affected the visibility while reversing. There was no warning light illuminated. The contact stated that the failure persisted. The vehicle was taken to the dealer to be diagnosed; however, the vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 3,518.

12/28/2023

On the afternoon of February 12, 2024 (5:12pm), I was driving northbound on I-71 at highway speed, approximately 75mph. My Hyundai Ioniq 6 alerted me of a (non-existent) impending front-end collision, and within 1 second of the alert starting, the automatic emergency braking system activated. This resulted in the violent (and unexpected) braking of my car to around 25mph. There was no clear reason for the collision detection alert or the automatic emergency brake. The light was good and there was no significant weather. There were no vehicles immediately in front or behind me. (Nearest car in front was over a quarter mile away.) The force of the braking was sufficiently strong that I am still sore in my shoulder and back a week later. I am fortunate that there wasn't a car close behind me, as I likely would have been rear-ended due to the unexpected and abrupt nature of the braking. The vehicle was taken in for service (invoice attached) and "calibrated". Within 10 miles of getting back on the highway, warnings (but no braking) triggered again. (photo attached of one of the warnings). The vehicle is currently back at dealer service.

2/20/2024

While driving in the highway I took my foot off the accelerator and despite one pedal driving being on the car did not brake. I then tapped the brake. When I then pushed the accelerator to keep up with traffic, nothing happened. I checked the screen for warning lights. The car had none. The accelerator pedal was non responsive causing a huge safety issue for me and others on the road as the car was now just cruising as I was approaching a hill..I had to turn on my hazards and get over into the shoulder of the highway along the bridge at night. I stopped the car. There were still no warning lights on. I turned the car off and back on and the problem was no longer present.

2/20/2024

The driver seat is causing back, glute and groin pain. The car has been driven for only 1.7k miles, but the seat cushions already have so much give that one can easily feel the frame under the seat when sitting or pressing down with an open hand. The back of the seat has so much give that it is possible to feel the plastic behind the seat back cushion. I will include photos, but unfortunately it is rather difficult to capture the issue in photos. The issue is constant and ongoing. Aside from causing pain that is requiring medication, the uncomfortable seating is distracting and experiencing numbness in your legs while driving are both clear a safety concern. The dealership, as well as Hyundai USA’s customer service, are refusing to take any action on these concerns. Instead they have given me the run around for 4 months saying I should contact customer service or the dealership, respectively. The dealer has inspected the car, but maintains that there is no issue. I would be happy to get the car assessed by somebody independent if NHTSA as suggestions in that regard. The issue first became apparent after driving the car for daily commutes shortly after taking possession of it.

3/22/2024

Subject: Safety Complaint – Sharp Upper Door Edge Causing Facial Injury (Hyundai IONIQ 6, 2023) Message: To whom it may concern, I would like to submit a safety complaint regarding my 2023 Hyundai IONIQ 6 (VIN: [XXX] ). On October 14, 2024, my wife suffered a facial injury caused by an extremely sharp upper edge of the front door. This occurred in our driveway at [XXX] . The injury happened when the front door stopped at its mid-detent position and the sharp, exposed upper edge made forceful contact with her forehead and the area next to her eye. She avoided a direct eye injury only due to quick reflex. This design presents a serious risk to passengers, especially those of shorter stature. I have photographic documentation showing the sharp door edge and the injury mechanism. Hyundai Motor America was informed, but they dismissed the case and advised us simply to “be more careful.” They offered a $150 virtual compensation card, which I did not use, because accepting it could be interpreted as accepting their proposed settlement. Hyundai insisted on dealer inspection, which is irrelevant because this is not a defect of a single unit — all vehicles of this model have the same door-edge geometry. I believe this is a safety-related design hazard affecting all Hyundai IONIQ 6 vehicles. I respectfully request that NHTSA review this case, as the risk of eye or facial injury is significant. Please let me know if you require additional information or photographs. Sincerely, [XXX] [XXX] Phone [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

11/28/2025