2024 Ford Ranger Owner Complaints

I was in an area that had received snow and cold temperatures. I started my car to warm it up and began cleaning off the snow. The heat from the rear defroster caused my read window to shatter leaving glass mostly on the exterior of the truck bed but also in the back seat. This is a known problem with Ford model trucks and they refuse to repair the issue or replace my window.

12/10/2024

I flew down to Anchorage Alaska this brand new 024 FORD RANGER XL on [XXX] sight unseen and no test drive from KENDALL FORD Dealership. After buying the truck I started it, engaged 4 wheel drive and slippery/ icy setting. On the way back to Fairbanks the steering was hard to turn and got progressively harder the faster I drove and the colder it became. About half way home it became exhausting to steer requiring a lot of force to turn the steering wheel that actually resisted with real force being turned. I didn’t know the lane keeping would turn on with the cruise control but it did and resisted me even more. The roads became black ice and it was freezing rain. The phone charge port lost power, the dash blanked out, there was no radio and the rear power port I had switched to lost power and my phone died. I was driving about 30 to 40 mph on the 2 lane undivided snow covered black ice covered highway. In a curve in the road where the highway maintenance snow plows had stopped plowing I believe the truck mistook the snow line for the painted line and unexpectedly and surprisingly actually turned the steering wheel towards the double solid dividing centerline and I turned back into my lane. This slight movement caused the truck to totally slide out of control and cross the double solid dividing centerline and the truck went into opposite highway oncoming lane! Luckily there was no traffic coming the other way or it could have been a horrible accident. I hit the brakes and the truck actually stopped good, and then I got back into my lane and pulled over at the first chance. My phone was dead so I had no flashlight because I flew down I carried nothing but my coat. I tried to inspect the steering but it was all dark and below zero so I continued on towards Fairbanks another hundred miles to the North. The truck also had a bunch of other problems like refusing to start that can leave a person to freeze to death quickly in the Arctic below zero temperatures. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION AC

3/15/2025

When stopped or turning from a stop I will lose acceleration for 3-4 seconds at such time I will almost over accelerate when it does catch which I almost will lose control especially in icy weather. I have no codes have taken to dealership for repairs 4 times they can't find any issues. The issues appeared day 1 asked them to look at it they said it was fine.

2/24/2025

The contact owns a 2024 Ford Ranger. The contact stated that while attempting to leave a parking lot while on an incline, the transmission was shifted into drive(D); however, the vehicle began to slowly reverse. The contact quickly proceeded to depress the brake pedal and shift back to park(P). There was no warning light illuminated. The vehicle was taken to a local dealer where it was diagnosed, and the contact was informed that there was no failure found with the vehicle. The vehicle was not repaired. The contact referenced NHTSA Campaign Number: 25V164000 (POWER TRAIN); as a possible cause for the failure. The manufacturer was not notified of the failure. The approximate failure mileage was 2,000.

4/4/2025

2024 Ford Ranger Trucks made in Michigan between January 4, 2024 to July 15, 2024 do not include the load box reinforcement bracket. Without this bracket installed, if the owner were to place more than 88lbs onto one or both bed side rails the bed could crack, warp, bend, or break. If operators of this vehicle are not aware and do load the bed side rails over 88lbs, this could pose a safety issue to the driver or other drivers on the road around the vehicle. Ford has not notified all owners of affected vehicles, and in my case I found out my vehicle was affected out of sheer curiosity and reading forums with posts of other owners whose vehicles are also affected. Ford is currently not willing to address the issue without additional cost burden on the vehicle owner.

9/29/2024

I purchased a new 2024 Ford Ranger yesterday. As I was researching camper shells and truck racks I found that these common items cannot be installed without first installing a load bed reinforcement bracket kit to reinforce the truck bed to the bed side rails. Apparently, nothing can be attached to the side rail which weights more that 88 lbs or the truck bed could separate from the side rails. This is an design/engineering shortcoming from Ford as these are common after market add-ons for mid-sized trucks. Also, Ford is asking customers to pay for the reinforcement bracket and installation - which was quoted today at $1,600, and the Ford part is not currently available from the corporate US Ford website, and has not been available for several months.

12/28/2024

I bought this ford ranger and got it last week and went to put a topper on it and you cant - the box rails only hold 80 pounds . You have to install new brackets Ford nose about this but makers buyer pay for it . please make ford do a recall on this before someone gets hurt . thank you

9/28/2024

I was in an area that had received snow and cold temperatures. I started my car to warm it up and began cleaning off the snow. The heat from the rear defroster caused my read window to shatter leaving glass mostly on the exterior of the truck bed but also in the back seat. This is a known problem with Ford model trucks and they refuse to repair the issue or replace my window.

12/10/2024

Air vent under steering wheel does not provide proper clearance for brake applications. Foot gets tangled/caught on vent. Had a few close calls during emergency situations. Problem gets worse with thicker sole shoes.

3/17/2025

Vehicle randomly upon start up, shows error codes on dash, of important Safety System Tech, including: Pre-collision Assist not available Service Advance Trac Auto Hold System Fault Antilock Brake Fault Service vehicle soon Vehicle warnings make Truck unsafe to drive.

6/29/2025

Vehicle displays “Steering Assist fault-Service required”. Failure of power steering while driving could result in loss of control of the vehicle. The earliest available appointment for the dealer to check the problem is 11/20/24.

10/24/2024

I flew down to Anchorage Alaska this brand new 024 FORD RANGER XL on [XXX] sight unseen and no test drive from KENDALL FORD Dealership. After buying the truck I started it, engaged 4 wheel drive and slippery/ icy setting. On the way back to Fairbanks the steering was hard to turn and got progressively harder the faster I drove and the colder it became. About half way home it became exhausting to steer requiring a lot of force to turn the steering wheel that actually resisted with real force being turned. I didn’t know the lane keeping would turn on with the cruise control but it did and resisted me even more. The roads became black ice and it was freezing rain. The phone charge port lost power, the dash blanked out, there was no radio and the rear power port I had switched to lost power and my phone died. I was driving about 30 to 40 mph on the 2 lane undivided snow covered black ice covered highway. In a curve in the road where the highway maintenance snow plows had stopped plowing I believe the truck mistook the snow line for the painted line and unexpectedly and surprisingly actually turned the steering wheel towards the double solid dividing centerline and I turned back into my lane. This slight movement caused the truck to totally slide out of control and cross the double solid dividing centerline and the truck went into opposite highway oncoming lane! Luckily there was no traffic coming the other way or it could have been a horrible accident. I hit the brakes and the truck actually stopped good, and then I got back into my lane and pulled over at the first chance. My phone was dead so I had no flashlight because I flew down I carried nothing but my coat. I tried to inspect the steering but it was all dark and below zero so I continued on towards Fairbanks another hundred miles to the North. The truck also had a bunch of other problems like refusing to start that can leave a person to freeze to death quickly in the Arctic below zero temperatures. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION AC

3/15/2025

The truck randomly loses power, sometimes after rounding a corner, getting into turn lane, or over a speedbump the accelerator is dead for 1-2 seconds and the truck does not move forward. It has left me in a precarious position in the middle of the road with on coming traffic.

8/20/2025

I purchased a Ford Ranger truck with an EPA/NHTSA fuel economy label stating 20 mpg city and 25 mpg highway, 22 mpg combined. In reality, despite proper maintenance, the vehicle achieves only 16.26 mpg combined and as low as 14.72 mpg in city. While I understand fuel economy varies, this discrepancy is significant and may pose safety concerns. I relied on accurate fuel economy estimates to plan trips and refueling. This overstated MPG has lead me to unexpected fuel depletion, and stranding me in an unsafe condition (ran out of gas on HWY 287). I request NHTSA review whether Ford’s labeling practices meet regulatory standards and whether corrective action is warranted. I have taken the Ford Ranger to two different dealerships. One, Ford Automation, Frisco, Texas, refused to investigate what might be the issue, as they stated that was normal for the Ford Ranger. The second dealership, Five Star Ford, Dallas, Texas, reported in their tests they were averaging 26.1 mpg, combined. They did not tell me how they arrived at that figure. Your site would not allow me to upload fuel receipts to prove my statements above.

12/1/2025

I was slowing down, foot off of throttle, to make a left turn. After completing turn and wanting to speed up, I had no throttle response for 2 or 3 seconds. Then all of a sudden back to normal. There was no accident. This has happened before, at least 3 times. Same/similar circumstances and result. I have not taken it to the dealer yet after reading other owners doing so and was not resolved.

8/26/2025

while driving between 5-10 MPH on a dry, smooth paved road, the transmission began cycling through 4WD modes and began shifting from normal mode to 4WD Sand mode, i was able to pull over and park, but the transmission continued shifting and fully transitioned to 4WD mode. This is the second time it has occurred, the first time the transmission fully switched 4WD and i was barely able to pull off the road to reset it. after first issue, dealership noted the following "3131 confirmed concern. pulled codes with FDRS and found P05D3 in ABS module. Referred to workshop manual and run pinpoint test AH for concern. AH1 yes. AH2 had me reconfigure ABS module with As-Built data rerun self test. No codes returned and system operating correctly at this time." There multiple online forums with owners having the same problem. https://www.ranger6g.com/forum/threads/24-rr-shifted-while-driving.18956/ Truck will be going to dealership for assessment again.

10/16/2025

I purchased a new 2024 Ford Ranger yesterday. As I was researching camper shells and truck racks I found that these common items cannot be installed without first installing a load bed reinforcement bracket kit to reinforce the truck bed to the bed side rails. Apparently, nothing can be attached to the side rail which weights more that 88 lbs or the truck bed could separate from the side rails. This is an design/engineering shortcoming from Ford as these are common after market add-ons for mid-sized trucks. Also, Ford is asking customers to pay for the reinforcement bracket and installation - which was quoted today at $1,600, and the Ford part is not currently available from the corporate US Ford website, and has not been available for several months.

12/28/2024

There is a fluid leak in the shock absorber. The truck has less than 3k miles

7/8/2025

I flew down to Anchorage Alaska this brand new 024 FORD RANGER XL on [XXX] sight unseen and no test drive from KENDALL FORD Dealership. After buying the truck I started it, engaged 4 wheel drive and slippery/ icy setting. On the way back to Fairbanks the steering was hard to turn and got progressively harder the faster I drove and the colder it became. About half way home it became exhausting to steer requiring a lot of force to turn the steering wheel that actually resisted with real force being turned. I didn’t know the lane keeping would turn on with the cruise control but it did and resisted me even more. The roads became black ice and it was freezing rain. The phone charge port lost power, the dash blanked out, there was no radio and the rear power port I had switched to lost power and my phone died. I was driving about 30 to 40 mph on the 2 lane undivided snow covered black ice covered highway. In a curve in the road where the highway maintenance snow plows had stopped plowing I believe the truck mistook the snow line for the painted line and unexpectedly and surprisingly actually turned the steering wheel towards the double solid dividing centerline and I turned back into my lane. This slight movement caused the truck to totally slide out of control and cross the double solid dividing centerline and the truck went into opposite highway oncoming lane! Luckily there was no traffic coming the other way or it could have been a horrible accident. I hit the brakes and the truck actually stopped good, and then I got back into my lane and pulled over at the first chance. My phone was dead so I had no flashlight because I flew down I carried nothing but my coat. I tried to inspect the steering but it was all dark and below zero so I continued on towards Fairbanks another hundred miles to the North. The truck also had a bunch of other problems like refusing to start that can leave a person to freeze to death quickly in the Arctic below zero temperatures. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION AC

3/15/2025

Certain buttons don't work on the steering wheel. Usually temporary. Sometime the center console won't load at start up. The lane keeping system and speed control don't follow the instructions in the setup menu.

6/13/2025

There used to be no sufficient clearance between the drivers knee airbag and the brake pedal. I wear steel toe boots for work and my foot just barely fits between the brake pedal and the airbag box. Several times it’s gotten hung up and I had trouble getting to the brake. In a panic situation the could be disastrous. I’ve checked in other model trucks and there is plenty of clearance.

3/17/2025

Why hasn't Ford found replacement parts for this airbag defect. I don't feel safe driving a car that may cause more injury to my person if I'm in an accident. This should fixed immediately. Or I would like to return my vehicle for full refund or get a new one with out safety issues.

9/1/2025

The contact owns a 2024 Ford Ranger. The contact stated while driving 50 MPH, the brake pedal was depressed and the front driver’s side wheel locked up, causing the vehicle to pull to the left. The vehicle was towed to an independent mechanic to be diagnosed. The contact was informed that there was a part missing from the wheel. The contact was informed that the wheel needed to be replaced. The manufacturer was notified of the failure and a case was opened. The failure mileage was 6,000.

9/17/2024

The rear seats in the 2024/2025 Ford Raptor Ranger are connected to the rear of the cab via a single latch. The single latch does not always latch. I noticed it had failed to properly latch the next day when I was installing my car seats. I figured it was user error, but than I re-tested it and struggled to properly latch it. The danger is the rear portion of the seat could suddenly fold forward during a hard break or accident, resulting in serious injury to rear passengers.

11/26/2024

2024 Ranger Raptor built in December of 2024 with 1,750 miles on it. The rubber trim around the sliding rear window appears to have melted from the in glass defroster overheating. It is now duct taped to keep water from leaking into the cab.

4/16/2025

The contact owns a 2024 Ford Ranger. The contact stated that while driving 30 MPH, the alert of a sensor was displayed. The contact stated that the message that the sensor was not working, and the front center sensor was not available, was displayed. The contact stated that the brakes independently activated whenever the sensor alert was displayed, causing the vehicle to stop unexpectedly without a vehicle or object being nearby. The vehicle was taken to the dealer twice, and the contact was informed that the Ford engineers were working on the issue. The code was cleared, and the air and sensors were not working. The contact was informed that there was no fix for the issue. The contact was unable to use adaptive cruise control, and the vehicle was parked. The contact was unable to use the features. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 30.

4/17/2025

The contact owns a 2024 Ford Ranger. The contact stated that while driving at various speeds, the contact had trouble seeing out of the windshield and became aware that the front windshield was distorted. The vehicle was taken to the local dealer where a warranty claim was submitted, and it was determined that the windshield needed to be replaced. The windshield was replaced but the failure recurred. The vehicle was taken to another local dealer, Gosch Ford Temecula-Service Dept (26895 Ynez Rd, Temecula, CA 92591); where it was determined that a windshield replacement was needed. The windshield was replaced; however, the failure persisted. The dealer checked other years, makes, and models, and became aware that the vehicles had the same distorted windshields. The manufacturer was contacted and referred the contact to the dealer for assistance. The failure mileage was approximately 1,000.

5/20/2025

Certain buttons don't work on the steering wheel. Usually temporary. Sometime the center console won't load at start up. The lane keeping system and speed control don't follow the instructions in the setup menu.

6/13/2025

Vehicle randomly upon start up, shows error codes on dash, of important Safety System Tech, including: Pre-collision Assist not available Service Advance Trac Auto Hold System Fault Antilock Brake Fault Service vehicle soon Vehicle warnings make Truck unsafe to drive.

6/29/2025

Vehicle randomly upon start up, shows error codes on dash, of important Safety System Tech, including: Pre-collision Assist not available Service Advance Trac Auto Hold System Fault Antilock Brake Fault Service vehicle soon Vehicle warnings make Truck unsafe to drive.

6/29/2025

The contact owns a 2024 Ford Ranger. The contact stated that while trying to purchase a diamond back bed cover, upon further investigation, it was found that the vehicle was missing the load box reinforcement bracket. The missing bracket might cause the structural performance of the bed to fail. The vehicle was taken to the dealer; however, the vehicle was not inspected or repaired. The manufacturer was made aware of the failure. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 10,000.

7/21/2025

When truck was new at 400 miles Abs traction controll rear collision and all braking erro codes were displayed on dash. Brought to dealer had a bad wheel speed sensor in rear. At that time I asked about large amount of rear brakes dust on vehicle like if the brakes were dragging. Technician said just poor oem pads. Now at 14k miles rear pads at 6mm thickness back wheels are always covered in brake dust. I was at dealer asked if there is anything they could do regarding initial build quality. Dealer said no there is no fault just poorly made pads. As a consumer ths is less then except able of a vehicle to almost need new rear brakes at 14k miles. Delaer should be replacing these pads on there behalf not the customer.

8/10/2025

When truck was new at 400 miles Abs traction controll rear collision and all braking erro codes were displayed on dash. Brought to dealer had a bad wheel speed sensor in rear. At that time I asked about large amount of rear brakes dust on vehicle like if the brakes were dragging. Technician said just poor oem pads. Now at 14k miles rear pads at 6mm thickness back wheels are always covered in brake dust. I was at dealer asked if there is anything they could do regarding initial build quality. Dealer said no there is no fault just poorly made pads. As a consumer ths is less then except able of a vehicle to almost need new rear brakes at 14k miles. Delaer should be replacing these pads on there behalf not the customer.

8/10/2025

The truck randomly loses power, sometimes after rounding a corner, getting into turn lane, or over a speedbump the accelerator is dead for 1-2 seconds and the truck does not move forward. It has left me in a precarious position in the middle of the road with on coming traffic.

8/20/2025