2020 Ford Fusion Owner Complaints

THE TOUCHSCREEN DISPLAY IS NOT WORKING. IT TURNED COMPLETELY BLACK. I CANNOT CHANGE THE RADIO STATION. I SHUT OFF MY CAR AND TURNED IT BACK ON AND IT IS STILL NOT WORKING HAD TO HARD RESET THE SYSTEM CAR ALSO SHIFTS HARD IN AND OUT OF PARK AND REVERSE, MAKES A CLUNKING SOUND AND SHIFTS HARD IN FIRST AND SECOND

12/14/2020

I started my car and the engine was running very rough. The check engine light came on and I received a notification in the FordPass app of a powertrain control module detected an engine misfire. I was 108 miles from home in a snow storm. I drove to a hotel and spent the night. My husband picked me up the next morning. We towed it to the dealership where they found coolant had leaked into the spark plugs because of a warped cylinder head.

3/25/2022

There is Exhaust smell of rotten eggs that enter the cabin while driving and it happens almost every drive. I have brought the car to the dealer where they ran tests but found no problems. As soon as I got the car back it started producing the rotten egg smell again.

6/21/2022

Constantly with this specific vehicle, especially with the lane assist. The vehicle continuously jerks either left or right even within the green parameters of the lane, especially when doing a slight turn on the highway. When it is raining the vehicle smart as go offline an cannot read the lane or the vehicle in front of it. When I first purchased the vehicle after driving for less than a year I had to take the vehicle in because the engine was warped. Constantly when I’m the vehicle the Apple car play system would either freeze or the screen would go black.

9/20/2022

TL* THE CONTACT OWNS A 2020 FORD FUSION. THE CONTACT STATED THAT THE BACKUP CAMERA REMAINED ON WHILE DRIVING AT AN UNKNOWN SPEED. THE VEHICLE WAS TAKEN TO THE ROYAL OAK FORD DEALER, LOCATED AT: 27550 WOODWARD AVE, ROYAL OAK, MI 48067, WHERE THE SENSOR WAS REPLACED. THE CONTACT STATED THAT WHILE DRIVING HOME, THE VEHICLE HIT A POT HOLE, THE FRONT PASSENGER'S TIRE WENT FLAT. THERE WAS NOT SPARE TIRE. THE CONTACT'S HUSBAND PURCHASED A NEW TIRE, JACKED THE VEHICLE UP TO REPLACE THE TIRE. WHILE ON THE JACK, THE VEHICLE WENT IN REVERSE, ROLLED BACK AND FELL OFF THE JACK. THE VEHICLE WAS TAKEN TO THE SAME DEALER WHO STATED THAT THE VEHICLE WAS NOT EQUIPPED WITH A SPARE TIRE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES AND REFERRED THE CONTACT TO THE DEALER. THE CONTACT WAS TOLD TO TAKE THE VEHICLE TO A BODY SHOP TO REPLACE AN MUD GUARD THAT DETACHED. THE PART WAS NOT REPLACED. THE FAILURE MILEAGE WAS 4,051.

6/11/2020

AS I'M DRIVING MY RADIO SHUTS OFF AND WILL NOT POWER ON. THE VEHICLE WAS IN MOTION

9/1/2020

THERE WAS WHITE SMOKE COMING OUT OF THE HOOD AND THERE WAS A SMELL OF BURNED RUBBER. I HAD REACHED MY DESTINATION AND HAD JUST PARKED.

2/1/2021

TL* THE CONTACT RENTED A 2020 FORD FUSION FROM HERTZ CAR RENTAL. THE CONTACT STATED WHILE DRIVING 25 MPH ON A INCLINE HILL, A STRANGE SOUND OCCURRED AND THE VEHICLE STARTED TO SLOW DOWN. THE CONTACT DEPRESSED THE ACCELERATION PEDAL , HOWEVER THE VEHICLE STARTED TO ROLL BACKWARDS DOWN THE HILL CAUSING THE VEHICLE TO CRASH INTO TWO OTHER VEHICLES. NO WARNING LIGHTS WAS ILLUMINATED. THE AIR BAGS FAILED TO DEPLOY. THE VEHICLE WAS DAMAGED ON THE DRIVER SIDE DOOR AND THE BACK LIGHT WAS DENTED. THE CONTACT SUSTAINED WHIPLASH AND LOWER BACK PAIN; NO INJURIES SUSTAINED BY OTHER VEHICLE DRIVERS. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO THE A PARKING LOT AND THEN TOWED TO HERTZ CAR RENTAL LOT(625 SOUTH COLUMBUS AVE , MOUNT VERNON NY, 10550 914-665-1780). THE CONTACT STATED THE RENTAL COMPANY WAS APPRISING THE VEHICLE AND HAD NOT RECEIVED ANY UPDATES. THE FAILURE MILEAGE WAS 23,600. THE VIN WAS NOT AVAILABLE.

3/5/2021

The contact owns a 2020 Ford Fusion. The contact stated that their husband was coming to a stop light at approximately 5 mph, he attempted to stop the vehicle by depressing the brake pedal but the vehicle failed to respond. In order to avoid a crash, the driver veered to the right where they went over a curb, into a bush, and eventually came to a stop by crashing into a guard wire. The driver then drove the vehicle in a parking lot nearby and when attempting to stop the vehicle again, the vehicle failed to stop again. The driver had to place the vehicle in neutral and shut it off. There were no injuries reported. A police report was not filed. The contact took the vehicle to the dealer but the diagnosis was unknown. The vehicle had not been repaired as of yet. The manufacturer was made aware of the failure and opened a case and referred them to the NHTSA Hotline. The approximate failure mileage was unknown.

6/21/2022

I WAS BACKING OUT OF MY DRIVEWAY AND MY BRAKE PEDAL WENT TO THE FLOOR. I COULD NOT STOP AND HIT A VEHICLE BRHIND ME.

10/4/2022

After every fuel up on the vehicle since I bought it in October 2022 car was sluggish to start, it proceeded to get worse as weeks went by and car refused to turn on until multiple attempts. Days later as I was driving and came to a stop light the car was struggling to stay on. The check engine light finally turned on after a few months of struggling with being able to turn vehicle on after fill up. Upon taking it to the Ford dealership to inspect code P0496 AND P0456 were found. Upon further inspection I was quoted to need VMV and charcoal canister with reprograming to VMV totaling 1500 worth of repairs. After two days of waiting dealership advised that parts, primary charcoal canister are in back order as "this is a common problem with these cars". Telling me that there is no way of knowing when I will be able to get the parts. Being that my car is a 2020, I don't comprehend why this is even an issue and why is this not a recall.

8/9/2023

My 2020 Ford Fusion has experienced three separate flexplate failures, as well as transmission issues following the most recent repair. Failure #1: Occurred before I owned the vehicle (confirmed later in the vehicle’s history). The flexplate was replaced by a prior owner in 2022. Failure #2: [8/2023] – While I owned the vehicle, a loud rattling noise came from the engine area. My vehicle was towed to Foothill Ford, where it was purchased, and they replaced the flexplate. No power loss occurred. Failure #3: [5/2025] – The same rattling sound returned. I drove it to Green Ford, who confirmed the flexplate needed to be replaced, and they replaced it. No power loss occurred, but the noise was severe. After the third flexplate replacement, the transmission began slipping during acceleration. This issue did not exist before the repair, and Green Ford had told me the transmission was fine before they replaced the flexplate. Safety concern: Repeated flexplate failures and subsequent transmission slipping could cause loss of propulsion or difficulty maintaining speed if the problem occurs at highway speeds or in heavy traffic, creating a potential crash risk. I did lose power on the highway, but was able to pull safely off the shoulder and called a tow truck.

8/15/2025

2020 Fusion Compressor one, delivered from factory went out-repaired Compressor 2 just went out Needs 3rd compressor now in 3 years or 38,000-Pending I was very concerned each time the compressor went out (x2) I was on the highway when it ceased up and I lost the ability to effectively control the vehicle. I was put in an unsafe position with the ceasing up and with excessive heat buildup with smelling burning. This was very scary and was unsafe and this part should be investigated for potential to cause harm and injury to those in the car should it happen to anyone else. Limited control of car, notice no more Belt as well after i was able to stop. It appaired to in tiny pieces as small as bee bees all over the car. Not even recognizable as a belt. This has happed 2 times (this is not normal in 38,000 miles, having very limited control of car and breaking and steering and no power with smell of fire/burning.

7/12/2023

My vehicle was in service with my dealer for several months 3 separate occasions for powertrain issues which werent resolved and now the alignment in my steering wheel is really off. My spouse and I believe the PCM is messed up but have had no progress with our dealership and suspect them of committing consumer fraud and selling us a lemon. The vehicle in question is around 70,000 and started messing up at 60,000.

2/6/2025

Pre-Collision Assist Not Available shows on dash every time when starting the car now. Started in October intermittently.

11/8/2021

If the car is parked in directly sunlight and I start the car a "Front camera temporarily unavailable" message will appear. It happens more when the outside temperature is warmer.

12/28/2022

I can hear the coolant sloshing around and gurgling while the vehicle is in park with the heat on. When I turn the heat off, the sloshing and gurgling goes away. It appears that I do not have a coolant leak.

12/11/2021

The contact owns a 2020 Ford Fusion. The contact stated the vehicle was started and the check engine warning light illuminated. The contact had taken the vehicle to an independent mechanic where it was diagnosed and determined that there was coolant intrusion into cylinder #2, and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not informed of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 68,000.

12/2/2024

TL* THE CONTACT OWNS A 2020 FORD FUSION. THE CONTACT STATED THAT THE BACKUP CAMERA REMAINED ON WHILE DRIVING AT AN UNKNOWN SPEED. THE VEHICLE WAS TAKEN TO THE ROYAL OAK FORD DEALER, LOCATED AT: 27550 WOODWARD AVE, ROYAL OAK, MI 48067, WHERE THE SENSOR WAS REPLACED. THE CONTACT STATED THAT WHILE DRIVING HOME, THE VEHICLE HIT A POT HOLE, THE FRONT PASSENGER'S TIRE WENT FLAT. THERE WAS NOT SPARE TIRE. THE CONTACT'S HUSBAND PURCHASED A NEW TIRE, JACKED THE VEHICLE UP TO REPLACE THE TIRE. WHILE ON THE JACK, THE VEHICLE WENT IN REVERSE, ROLLED BACK AND FELL OFF THE JACK. THE VEHICLE WAS TAKEN TO THE SAME DEALER WHO STATED THAT THE VEHICLE WAS NOT EQUIPPED WITH A SPARE TIRE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES AND REFERRED THE CONTACT TO THE DEALER. THE CONTACT WAS TOLD TO TAKE THE VEHICLE TO A BODY SHOP TO REPLACE AN MUD GUARD THAT DETACHED. THE PART WAS NOT REPLACED. THE FAILURE MILEAGE WAS 4,051.

6/11/2020

I purchased this vehicle on Mar 4 2020 at Al Spitzer Ford in Cuyahoga Falls, OH with only 11,800 miles.I am getting the run around with their service department. The vehicle does not have a hoodliner insulator installed. It's needed to control temperature, protect paint and reduce engine fires. This is Ford's way along with the dealership to cut costs. The vehicle is covered under warranty and is metallic black which will attract the heat

5/9/2022

The contact owns a 2020 Ford Fusion. The contact stated that after stopping to make a left turn; while in the middle of completing the turn, another vehicle approaching from the rear crashed into the driver’s side front and rear doors, dragging the vehicle for several feet before coming to a stop. The contact stated that the driver’s front and rear doors were completely destroyed however, none of the air bags deployed. The contact stated that she received some medical assistance at the scene but was then transported from the scene by an ambulance to the hospital. The contact sustained injuries to her ribs and bruises to her upper body. The contact was the only person injured in the crash. A police report was filed. The contact stated that the following day the vehicle was taken to the auto body shop by her uncle however, she was unsure if the vehicle was driven or towed. The contact stated that she was informed by her insurance provider that the doors needed to be replaced to repair the vehicle. The vehicle was not yet repaired. The contact was concerned that as severe as the crash was that the air bags did not deploy. The local dealer was contacted, and she was referred to the manufacturer for assistance. The manufacturer was contacted however, the contact stated that after being transferred several times and hung up on, she finally spoke with a representative however, she received no assistance from the representative. The manufacturer was informed of the failure. The failure mileage was 13,942.

1/31/2022

The driver steering wheel air bag moves to easily that could cause to eventually go off

3/27/2023

Car shifts into 1st gear when traveling at higher speeds (45+mph), causing a significant jerk and almost causing a rear end collision to myself. Car also loses power and jerks significantly hardwhen shifting to reverse and drive from Park. Afraid to travel over 45mph due to the downshifting.

12/15/2024

The steering cable is connected to the transmission hub, and the fitting that connects the two has a gasket that wears away and falls out. This is a recall with vehicles that are made from one of the two plants that assemble fusions, however my vehicle is not covered under the recall even though it is the very same issue as the recall from the other plant. it makes no sense, why is one assembly plant offering a recall for this issue while the other does not? For the same issue of the steering cable coming off the transmission, and not allowing the vehicle to go into gear. I have had to fix this car on the side of the highway before, it will not go into gear on the road. This is not safe at all. You cannot have vehicles just not going into gear while your driving down the highway, or road, street, etc.

1/30/2025

The manufacturer is using the wrong material for the parts on my car. Currently, the right-side lower control bushing is bulging out because a steel bushing was used instead of the aluminum one specified on the website. This issue is causing my car to pull to the right, making steering difficult. I've also experienced the same problem on the left side in the past. I request a recall to fix this and ensure the safety of all drivers on the road.

2/21/2025

At approximately 99,900 miles, my 2020 Ford Fusion began experiencing serious transmission issues, including rough shifting, hesitation, jerking, and difficulty accelerating, especially at low speeds or while merging onto highways. These symptoms created an unsafe driving situation, particularly in traffic and intersections. I took the vehicle to multiple repair shops to have the issue diagnosed. This process caused my mileage to go slightly over the 100,000-mile recall coverage limit for transmission repair assistance, but I have full documentation showing that the transmission problem clearly began while the vehicle was still under the limit. I later discovered that Ford had issued a recall or Customer Satisfaction Program (CSP) related to known transmission issues on this model. The CSP is 22N12, however, I never received any notice from Ford by mail, phone, or email about this recall or warranty extension. I was unaware it existed until after my car began to fail. Despite being under the recall threshold when the issue began, and having proof, Ford has so far refused to fully cover the cost of the repair, only offering partial assistance due to the slight overage in mileage. This is a serious safety defect. My vehicle hesitates or fails to shift properly at critical times, putting myself and others at risk of collision. I was not informed of the recall, and now I'm being financially penalized for Ford’s delay and lack of notification. I cannot afford this out-of-pocket expense, and I believe it is unfair and unreasonable to place this burden on consumers, especially when safety is involved. I respectfully request that NHTSA review this matter and urge Ford to take full financial responsibility for the recall repair. This defect is not due to misuse or wear-and-tear, but is acknowledged by Ford as a manufacturer issue I have an open case with Ford Corporate in which they have failed to get back to me about the issue. Case number ([XXX]) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (

6/16/2025

WHEEL BEARING HAD TO BE REPLACED, HEARD SOUND WHILE IN MOTION AND SLOWED DOWN CAR. CAR ONE YEAR OLD AND LESS THEN 30K MILES

1/27/2021

Constantly with this specific vehicle, especially with the lane assist. The vehicle continuously jerks either left or right even within the green parameters of the lane, especially when doing a slight turn on the highway. When it is raining the vehicle smart as go offline an cannot read the lane or the vehicle in front of it. When I first purchased the vehicle after driving for less than a year I had to take the vehicle in because the engine was warped. Constantly when I’m the vehicle the Apple car play system would either freeze or the screen would go black.

9/20/2022

APIM is faulty per the ford dealer ship. (Rusty Eck Ford) They state that it is a known issue but there has not been a recall. This affects the SYNC, navigation, instrument panel, connectivity to ford connect app, etc. In order for some things to be used temporarily, it has to be hard reset on the console. Nothing leading up to the issue.

10/11/2023

I have had 2 transmissions within the last year, making this the third Transmission on my vehicle. I had to have another common issue with the car replaced, which is a purge valve. My ABS light goes off often causing difficulty to steer the car and warning lights are activated showing that the safety features are not available. Lastly, there is a crack in the engine block caused by coolant in the spark plug due to overheating. This engine issue is one with the engines that Ford is aware of but I do NOT see a recall. The engine is blown due to this design and the warranties do NOT cover it. Case number [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

3/19/2025

Constantly with this specific vehicle, especially with the lane assist. The vehicle continuously jerks either left or right even within the green parameters of the lane, especially when doing a slight turn on the highway. When it is raining the vehicle smart as go offline an cannot read the lane or the vehicle in front of it. When I first purchased the vehicle after driving for less than a year I had to take the vehicle in because the engine was warped. Constantly when I’m the vehicle the Apple car play system would either freeze or the screen would go black.

9/20/2022

RANDOMLY 'SERVICE ADVANCE TRAC', 'PRE-COLLISION ASSIST NOT AVAILABLE', LANE ASSIST NOT AVAILABLE', POWER ASSIST STEERING NOT AVAILABLE', HILL ASSIST NOT AVAILABLE', WARNING LIGHTS APPEAR. WHEN THEY DO I COMPLETELY LOSE POWER STEERING. WHICH IS EXTREMELY DANGEROUS WHILE DRIVING. MOST THE TIME I CAN TURN OFF AND RESTART THE CAR AND IT GOES AWAY. HOWEVER, NOW IT HAS BECOME MORE FREQUENT AND HAS STARTED LOSING COMPLETE POWER OF THE CAR TURNING OFF WHILE DRIVING. I ALMOST DIED ON THE INTERSTATE. FORD DEALERSHIPS ONLY RECOMMENDATION WAS A NEW CIRCUIT BOARD THAT WAS LIKE $5K, MORE THAN THE CAR IS WORTH. THEY SAID IT WAS SOMETHING COMMON WITH THE FORD FUSIONS, THATS WHY THEY WERE QUIT BEING MADE. I RESEARCHED AND IT IS A COMMON ISSUE, BUT NO RECALLS HAVE BEEN MADE???!!???

7/24/2025

Pre-Collision Assist Not Available shows on dash every time when starting the car now. Started in October intermittently.

11/8/2021

The contact owns a 2020 Ford Fusion. The contact stated while driving 68 MPH, the vehicle started to stall. The vehicle was taken to the dealer and the contact was informed that the vehicle was not wired correctly. The vehicle was repaired but the failure reoccurred. The manufacturer was contacted but offered no assistance. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was 30,000.

8/30/2022

Issues with Ford Sync Infotainment system have been occurring for over a year now, with the latest being on May 25th. Backup camera stays on when in drive, and then turns to a blue or black screen that says contact dealer. GPS will fail randomly and will show my vehicle driving off roads and not following the route I am driving. A/C will randomly stop working and show a Fan Speed of 0 no matter how many times you try to increase the fan speed, then once you are able to adjust the fan speed after restarting the car it will only blow very hot air at any temperature setting except in Max A/C. Which even in Max A/C the air coming out is not very cold. The backup camera staying on is dangerous you are not able to control any other functions of your vehicle because the vehicle believes its still in reverse, and at night when the screen is bright blue it impairs visibility. The GPS failure does not allow for proper navigation when traveling. The A/C issue is dangerous during the summer time when you are unable to cool your vehicle with passengers, especially young children from the over 100F temperatures you can experience during the summer. The dealership has seen the A/C issue, and I have videos of the backup camera and GPS issues. Dealership has inspected the vehicle and has been unable to diagnose the issue. They have reset and updated the software, but issues are still intermittent. Multiple calls with Ford and they are unable to provide additional assistance without there being any fault codes or the issue being present. When the A/C issue was present at the dealership, they were unable to diagnose the issue and Ford did not respond back to customer service inquiries to know who at Ford to contact for additional support. No warning signs about the issues. Will just happen randomly at times with no advance warning of anything happening. Most of the time the issues happen after starting the vehicle, but A/C and GPS issues have occurred during middle of a drive.

7/7/2023

The contact owns a 2022 Ford Fusion. The contact stated that on several occasions while in reverse, the proximity warning alert did not sound as designed. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was unknown.

10/5/2023

The contact owns a 2020 Ford Fusion. The contact stated while driving approximately 55 MPH, the contact became aware that the vehicle was losing motive power. The contact stated that the RPM was fluctuating. The contact stated that the check engine warning light was illuminated. The contact stated that the vehicle stalled but was able to be restarted. The contact stated that the failure had occurred three other times. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the tube assembly fuel vapor separator (9D289) needed to be replaced. The vehicle had not been repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 102,495.

11/7/2023

The contact owns a 2020 Ford Fusion. The contact stated while driving at an undisclosed speed, the contact heard an abnormal knocking sound coming from the engine compartment. The vehicle was taken to the dealer and diagnosed with a failed flex plate and torque converter. The contact was informed that the flex plate and the torque converter needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 63,000.

11/14/2023

The contact owns a 2020 Ford Fusion. The contact stated while driving approximately 60 MPH, the vehicle changed lanes independently. The vehicle was steered to the side of the road. The vehicle was taken to a dealer where it was diagnosed that the steering control module was informing the steering wheel to turn to the left while the vehicle was to the right and vice-versa. The contact was informed that the steering control module needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 66,620.

1/5/2024

The contact owns a 2020 Ford Fusion. The contact stated that on several occasions while driving at various speeds, the gear was shifted, and the vehicle reverted to park. The vehicle was restarted approximately five to ten times on all but one occasion, and the vehicle failed to start. The vehicle was towed to a dealer where it was diagnosed that the shifter cable bushing needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was approximately 93,200.

2/7/2024

The entire media display gets stuck off or will freeze up, when I place the vehicle in reverse the rear camera comes on but parking assist, the rear sensors and cross traffic sensors won't work. Once I place the car in drive the display will either stay all blue or shut completely off. I cannot adjust the climate control, use GPS, or use the media. I have to shut the car off and then after about 10 minutes there is a bunch of clicking noise under the dash and after it stops clicking I can restart the car, the display will sometimes begin to work and if it dossent then I have to shut off the car again and go through the motions again. It has started to be more and more frequently, at first it was maybe once a week and now it is happening at every start.

4/26/2024

The entire media display gets stuck off or will freeze up, when I place the vehicle in reverse the rear camera comes on but parking assist, the rear sensors and cross traffic sensors won't work. Once I place the car in drive the display will either stay all blue or shut completely off. I cannot adjust the climate control, use GPS, or use the media. I have to shut the car off and then after about 10 minutes there is a bunch of clicking noise under the dash and after it stops clicking I can restart the car, the display will sometimes begin to work and if it dossent then I have to shut off the car again and go through the motions again. It has started to be more and more frequently, at first it was maybe once a week and now it is happening at every start.

4/26/2024

The contact owns a 2020 Ford Fusion. The contact stated that the hood latch was no longer functioning and the hood was not able to be raised. The contact stated that he had taken the vehicle to an independent mechanic who was unable to repair the failure. The manufacturer was informed of the failure and referred to the NHTSA Hotline. The failure mileage was approximately 103,000.

10/15/2024

The contact owns a 2020 Ford Fusion. The contact stated while driving at an undisclosed speed, the front passenger's side low beam headlight failed to illuminate as needed. Upon inspecting the vehicle, the contact noticed that the front passenger's side low beam headlight assembly wiring harness was burnt, and there was light smoke coming from the wiring harness. The vehicle was taken to the local dealer, where it was diagnosed that the low beam headlight assembly needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 53,000.

11/27/2024

The contact owns a 2020 Ford Fusion. The contact stated that while the vehicle was at the car wash, water entered through the closed sunroof. The vehicle was taken to an independent mechanic, who determined that the sunroof drain needed to be cleaned. The sunroof drain was cleaned, but the failure persisted. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 20V260000 (Visibility); however, the VIN was not included in the recall. The manufacturer was made aware of the failure and instructed the contact to take the vehicle to the dealer to have the sunroof replaced. The failure mileage was approximately 80,000.

1/14/2025

The contact owns a 2020 Ford Fusion. The contact stated while driving 70 MPH, the vehicle started pulling and veering to the right, while driving on uneven pavement. The power steering assist warning light illuminated while driving over 35 MPH. On another occasion, the steering wheel failed to respond, and the vehicle spun out and the vehicle came to a stop in the right lane. The vehicle was taken to a tire shop where it was diagnosed with rack and pinion failure, and the vehicle was aligned. The vehicle was repaired; however, the failure persisted. The contact then took the vehicle to an independent mechanic who diagnosed the vehicle with a steering assist sensor fault. The brakes were calibrated; however, when the contact depressed the brake pedal, the brakes failed to respond, and the contact stopped depressing on the accelerator pedal to have the vehicle slow down to stop the vehicle. The dealer was not made aware of the failure. The vehicle was not repaired for the most recent failure. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 87,361.

3/20/2025

The contact owns a 2020 Ford Fusion. The contact stated that upon starting the vehicle, the vehicle hesitated while responding. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power, with an abnormally loud vibration coming from the engine. There was no warning light illuminated. The vehicle was taken to a local dealer, where the vehicle was diagnosed, and the contact was informed that either the flywheel or the flex plate was faulty and needed to be replaced. The vehicle was not repaired. The contact referenced Customer Satisfaction Program: 22N12 as the possible cause for the failure. The manufacturer was notified of the failure. The approximate failure mileage was 103,000.

4/24/2025

The contact owns a 2020 Ford Fusion. The contact stated that while making a turn in either left or right direction, the Traction Control warning light had displayed, and the vehicle had reduced speed independently. During failure, the contact lost control of the vehicle and crashed into a mailbox. During the crash, no injuries were reported. No police report was filed and the vehicle was driven home. The cause of the failure was not determined. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 81,000.

6/11/2025