2020 Ford F-350 Owner Complaints

SHIFTING FROM 2 TO 3RD GEAR WHILE LIGHTLY ACCELERATING, IT BANGS SO HARD I THINK TRANSMISSION FELL OUT. IF IT UNDER AGGRESSIVE ACCELERATION, IT'S SMOOTH

9/11/2020

WHILE NEGOTIATING STEEP GRADES (OVER 8 DEGREES) AT MODERATE SPEEDS (~30MPH) WITH THE ENGINE BRAKE IN AUTOMATIC A 3RD GEAR TO 2ND GEAR OR 2ND GEAR TO FIRST GEAR CHANGE IS PROCEEDED BY A SIGNIFICANT ACCELERATION BY AS MUCH AS 5MPH OR MORE THIS CAN BE SIMULATED ON LESS STEEP INCLINES BY ENGAGING THE ENGINE BRAKE AND MANUALLY SHIFTING FROM 3RD TO 2ND.. THERE WILL BE AN INCREASE IN SPEED THAT CAN BE QUITE SIGNIFICANT THERE IS A MINOR REDUCTION IN BRAKING WHEN THE TRUCK PERFORMS A 4TH TO 3RD DOWNSHIFT BUT IT DOESN'T CAUSE ACCELERATION TO THE DEGREE THAT THE 3RD AND 2ND SHIFTS DO. THE CIRCUMSTANCES UNDER WHICH AN ENGINE BRAKE WOULD BE USED ARE EXACTLY THOSE CIRCUMSTANCES WHERE AN UNINTENDED ACCELERATION OF ANY KIND IS MOST DANGEROUS, SUCH AS MOUNTAIN ROADS AND SWITCHBACKS WHILE TOWING HEAVY LOADS THE DEALER IS AWARE OF HOW TO REPRODUCE THIS EVENT AND HAS SEEN IT FIRST HAND WHILE ON A TEST DRIVE.

9/22/2020

STEERING RETURNABILTY OR "RETURN TO CENTER" IS IMPEDED BY ELECTRIC POWER STEERING ASSIST. ACCORDING TO FORD THE NEW ELECTRIC OVER HYDRAULIC SYSTEM INSTALLED ON SOME SUPER DUTY TRUCKS ASSISTS THE DRIVER DURING CROSS WIND OR HEAVY ROAD CROWN SITUATIONS. BUT WHEN THERE IS NO WIND OR ROAD CROWN THE SYSTEM CONTINUES TO "ASSIST" AND HOLDS THE STEERING COLUMN FROM IMMEDIATELY RETURNING TO CENTER. THIS VEHICLE IS NOT EQUIPPED WITH A "LANE KEEPING' OR "AUTO STEER" SYSTEM. UNDER CERTAIN CONDITIONS THE VEHICLE REQUIRES CONSTANT LEFT AND RIGHT INPUT TO MAINTAIN LANE.WHEN DRIVING BETWEEN 30 MPH AND 50 MPH THE VEHICLE WILL CONTINUE TO NAVIGATE TURNS AFTER THE STEERING WHEEL IS RELEASED. THIS CONSTANT INPUT IS VERY FATIGUING AND WHEN ROAD CONDITIONS ARE SLIPPERY, ICY OR ROUGH MAINTAINING LANE IS EXTREMELY DIFFICULT AT TIMES.

9/29/2020

BROUGHT THIS TRUCK ON NOVEMBER 5,2020. IT IS A FORD F-350 SUPER DUTY DUALLY . ON NOVEMBER 25,2020 THE POWER STEERING WENT OUT COULDN'T STEER TRUCK THEN WITHIN A FEW MINS. LOST THE BRAKES ON THE TRUCK. HAD TO HOLD BRAKES TO FLOOR TO GET TRUCK STOPPED BESIDE OF ROAD. LOOK LIKE LOST FLUID FROM POWER STEERING . WAS A GOOD THING ON A TWO LANE ROAD WITH LITTLE TRAFFIC. WAS ABOUT TO GET ON INTERSTATE HIGHWAY WHERE THIS WOULD HAVE BEEN BAD WITH ALL THAT TRAFFIC AND GOING SPEED LIMIT . WHY WOULD BRAKES GO OUT IF POWER STEERING QUIT?

11/26/2020

The contact stated owns a 2020 Ford F-350. The contact stated that the vehicle had been repaired under Manufacturer Campaign Number: 22E04 Reprogram PCM/TCM (Power Train) however, after the repair the fuel economy had become significantly lessened. Prior to the repair the fuel economy was 22 MPG however, after the recall repair the fuel economy was 13.5 MPG. The contact stated that while hauling a trailer, the fuel economy fell from 13.4 MPG to 6.5 MPG. While driving with the cruise control activated, the fuel economy fell from 25 MPG to 15 MPG. The vehicle was taken to the dealer where it was confirmed that the recall remedy could not be reversed. The vehicle was not diagnosed. The vehicle or repaired. The manufacturer was made aware of the failure. The contact was referred to the NHTSA Hotline to file a complaint. The approximate failure mileage was 59,000.

1/19/2024

The contact owns a 2020 Ford F-350. The contact stated while driving 70 MPH, the check engine warning light illuminated. The vehicle experienced reduced power and went into LIMP Mode. The contact was able to continue driving. The vehicle was taken to the dealer the following day. The dealer diagnosed the vehicle and determined that the Diesel Exhaust Fluid (DEF) tube assembly needed to be replaced. The dealer informed the contact that it was a common failure. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was approximately 55,000.

2/29/2024

VEHICLE RPM WILL NOT DROP WHEN TAKING FOOT OFF THE GAS AND IN GEAR. RPM STAYS AT 1100 AND VEHICLE SPEEDS UP ON ITS OWN. NO DIFFERENCE WITH ENGINE BRAKE ON OR OFF. SEEMS TO HAPPEN IN PARKING LOTS OR AT STOP LIGHTS WHEN MOVING AT SLOW SPEEDS 5 TO 10 MILES PER HOUR. VEHICLE WILL ACCELERATE UNLESS BRAKES ARE APPLIED. BRAKES HAVE TO BE APPLIED SOMETIMES VERY HARD TO GET VEHICLE TO STOP AND ENGINE RPM TO DROP. DOCUMENTED BY THE DEALER WITH NO FIX. FORD MOTOR COMPANY CONTACTED WITH NO FIX. THIS HAS OCCURRED MULTIPLE TIMES. *TR

5/28/2020

FIFTH WHEEL ANDERSEN ULTIMATE HITCH SYSTEM FAILED WHILE WE WERE HAULING OUR UNIT. HITCH BROKE AND SAFETY CHAINS ALSO BROKE. UNIT WAS BLOWN OFF THE TRUCK WHILE DRIVING ON THE HIGHWAY CAUSING THE BALL TO BREAK SHEAR OFF DETACHING FROM TRUCK. COMPANY IS NOT WANTING TO DEAL WITH OUR INCIDENT. CAUSED OUR FIFTH WHEEL TO DETACH ON THE HIGHWAY AND ROLLED OVER. WE WERE HAULING UNDER WEIGHT TO WHAT THERE HITCH RECOMMENDS TO STAND 24,000 LBS OF TORQUE. WERE JUST ASKING FOR SOME HELP. OUR NEW $84,000 UNIT IS A COMPLETE LOSS AND OUR TRUCK IS IN THE COLLISION SHOP BEING REPAIRED. THANK YOU*DT*DT CONSUMER STATED MECHANIC DID NOT FIND ANY DAMAGE.*JB*DT*JB*DT*JB*DT*JB

7/3/2020

The Ford is under a Customer Satisfaction Program 21B03, and Ford will not honor this for our vehicle, however our truck has the number one planetary and ring gear assembly that has gone out.

1/3/2022

The contact owned a 2020 Ford F-350. The contact stated that while driving approximately 80 mph when the vehicle started emitting a smoke odor. Shortly after smoke started coming from the vents of the vehicle. There were no warning lights. The contact attempted to depress the brake pedal to pull over however the brakes began to melt causing an extensive time before the brakes stopped the vehicle. The shifter then slipped when they attempted to maneuver the vehicle. The contact and passengers exited the vehicle. The vehicle then became engulfed in flames while the vehicle continued to run off into the field due to the brakes and shifter completely melting. The vehicle was deemed totaled and was towed. A police report was filed. There were no injuries and no medical attention was needed. The dealer was made aware of the failure and was not able to confirm any recalls. The manufacturer was made aware of the failure and transferred them to NHTSA Hotline. The approximate failure mileage was 20,050.

6/8/2022

I PURCHASED THIS TRUCK ON 09/23/20. AT DELIVERY THE STEERING WHEEL WAS NOT ALIGNED CORRECTLY AND HAD TO BE ADJUSTED. TRUCK HAS HAD A CONSTANT VIBRATION THAT IS FELT THRU THE STEERING AND BODY. THE VIBRATION INCREASES WITH SPEED. AT 1031 MILES A REPAIR ATTEMPT WAS MADE THAT WAS UNSUCCESSFUL, AT 3225 MILES AGAIN A FAILED ATTEMPT WAS MADE AT CORRECTING, AT 3735 ANOTHER FILED ATTEMPT. AT 8156 ANOTHER FAILED ATTEMPT. AND AGAIN AT 8934 ANOTHER MORE EXTENSIVE REPAIR ATTEMPT WAS MADE WITH NO POSITIVE RESULTS. I WILL UPLOAD ALL REPAIR WORK ORDERS. THERE IS A SERIOUS PROBLEM IN THE DRIVETRAIN OF THE VEHICLE THAT FORD AS OF YET HAS BEEN UNABLE TO CORRECT. THE VIBRATION IS CONSTANT AND AT HIGHWAY SPEED HAS MADE PEOPLE CAR SICK. I AM FEARFUL THAT THERE IS A FAILING COMPONENT IN THE TRUCK THAT WHEN IT FINALLY BREAKS WILL CAUSE A SERIOUS ACCIDENT. THEY HAVE USED A VCMM VIBRATION ANALIZER THAT LISTED A HOST OF POTENTIAL PROBLEMS AND IN THEIR WORDS THE RESULTS WERE MISLEADING. THIS IS A HEAVY DUTY TRUCK THAT I FEAR TOWING MY TRAILERS WITH BECAUSE THEY CAN'T TELL ME WHY IT HAS THE VIBRATION. I ALMOST BELIEVE THAT THEY KNOW THE PROBLEM AND WON'T DISCLOSE IT TO ME. THE MOST CONCERNING STATEMENT MADE IN THE REPAIR ATTEMPT IS THAT THEY COMPARED MY TRUCK TO AN INSTOCK UNIT AND IT DRIVE COMPARABLE.

3/8/2021

VEHICLE HIT A ROUGH SPOT IN THE HIGHWAY AND THE STEERING WHEEL STARTED VIOLENTLY SHAKING CAUSING ME TO NOT BE ABLE TO CONTROL THE VEHICLE, BRAKES WERE USED TO SLOW THE VEHICLE AND THE ISSUE STOPPED. COMMONLY CALLED THE DEATH WOBBLE

3/17/2021

WHILE TRAVELING VEHICLE IN MOTION ELECTRIC TAILGATE SPONTANEOUSLY RELEASED DAMAGING THE TAILGATE AND TOW VEHICLE ON 8/8/2020, 8/20/2020 AND 9/3/2020. TAILGATE RELEASED ON SEVERAL OCCASIONS WHILE TOWING ON CITY STREETS AND HIGHWAY.

9/4/2020

BROUGHT A NEW FORD SUPER DUTY F-350 DUALLY ON NOVEMBER 5,2020. ON NOVEMBER 6 2020, THE PASSENGER DOOR CAUGHT BEHIND THE FRONT FENDER, CAUSING THE PASSENGER TO NOT BE ABLE TO OPEN DOOR. WHEN WE GOT DOOR OPEN , NOTICE THAT THE PASSENGER DOOR WAS OUT OF LINE AND HAD DROPPED DOWN. THE FRONT FENDER WAS OUT OF LINE WITH THE DOOR AND HOOD. WHEN DOOR STUCK IT CAUSED A DENT IN DOOR AND FENDER ALSO CHIPPED PAINT OFF. THE ISSUE IS IF PASSENGER HAD TO EXIT DOOR IN EMERGENCY WITHOUT A LOT OF FORCE IT MAY NOT OPEN PROPERLY OR FAST ENOUGH BECAUSE OF BODY PARTS WAY OUT OF LINE. IF A PERSON WAS TRYING TO OPEN DOOR FROM OUTSIDE AND IT HUNG IT COULD CAUSE THAT PERSON TO LOOSE GRIP OF DOOR SUDDENLY AND MAKE THEM FALL TO GROUND CAUSING INJURIES TO THEM. TRUCK WAS NOT IN MOTION WHEN THIS OCCURRED AND PARKED IN GRAVEL DRIVEWAY.

11/26/2020

Emissions control system has "failed" 5 times. Check engine light illuminated. Each time: P0420 DTC code: "Catalyst System Efficiency Below Threshold (Bank 1). Manufacturer is unable to fix. Vehicle will go into "Limp Mode" stranding owners/passengers.

2/13/2024

Ford sent me a recall for my 2020 F350 powerstroke saying they are trying to come up with a computer programming to fix faulty fuel pump in my truck which could lead to loss of power and crashing especially while pulling heavy loads. This is a mechanical issue. It has nothing to do with a software update which they claim they do not have but will try to get. There is no fix for this at the time. There actually is a fix. S&s makes a DCR fuel pump specifically to replace these fuel pumps because these fuel pumps can blow up and ruin the entire vehicle as the vehicles with these fuel pumps are extremely expensive.. the maker of this DCR pump for a 2020 F350 6.7 l powerstroke diesel has found the mechanical problem internal to the existing fuel pumps engineering and has designed a new one. I'm sure Ford can pay for these to be put in their vehicles or design one that is similar but these are already being made, sold and installed. Ford says they do not have a remedy for this at this time but there is one and it is this DCR pump. I saved my entire life and have people working in this truck in my family in this truck since couldn't be a serious safety issue and potentially cause death. I think Ford should be having these aftermarket units put in free of charge as all safety recalls are installed free of charge. Anyways, I wanted to write to see if this would be possible or if Ford can be pushed into doing the right thing and installing these in their vehicle. They are about $2,000 and probably around $1,000 to install, but you're talking about losing a $ $70 to $100,000 vehicle and a life. I think it's worth it

1/19/2025

NHTSA ID NUMBER 10172952. THIS NOTIFICATION IS NOT BEING APPLIED TO ALL FORD SUPER DUTY TRUCKS THAT HAVE THE ULTIMATE TRAILER TOW CAMERA SYSTEM W/PRO TRAILER BACKUP ASSIST. WHEN REVIEWING ANY RECALLS ON MY TRUCK, THIS YAW SYSTEM SENSOR REQUIRED TO MAKE THE PRO TRAILER ASSIST WORK THAT IS ESSENTIAL FOR TOWING 5TH WHEEL AND GOOSENECK TRAILERS WAS NOT INCLUDED WITH THE TRUCK. FORD HAS NOT BEEN SUPPLYING THIS ITEM. THE OWNERS MANUAL SPECIFICALLY REQUIRES THIS ITEM FOR OPERATION. I KNOW THIS MEMO IS OUT THERE BUT IS NOT BEING APPLIED TO THE PROPER VEHICLES. MY DEALER IS WORKING ON THIS, BUT WAS ONLY AWARE OF THE PROBLEM AFTER THE MEMO WAS FOUND AND I DISTRIBUTED IT. THE FAILURE IS, FORD NEEDS TO LIST THIS MISSING ITEM UNDER ALL VEHICLES THAT HAVE THIS OPTION. FORD DOES NOT HAVE THIS ITEM AVAILABLE AND COULD NOT BE FOUND IN THEIR PARTS DATA BASE. FORD IN ESSENCE CREATED FRAUD BY SELLING THIS OPTION WITHOUT PARTS REQUIRED TO MAKE IT WORK. I COULD NOT ATTACHE PICTURES, FILES ARE TO LARGE.

7/24/2020

WHILE TRAVELING VEHICLE IN MOTION ELECTRIC TAILGATE SPONTANEOUSLY RELEASED DAMAGING THE TAILGATE AND TOW VEHICLE ON 8/8/2020, 8/20/2020 AND 9/3/2020. TAILGATE RELEASED ON SEVERAL OCCASIONS WHILE TOWING ON CITY STREETS AND HIGHWAY.

9/4/2020

BROUGHT THIS TRUCK ON NOVEMBER 5,2020. IT IS A FORD F-350 SUPER DUTY DUALLY . ON NOVEMBER 25,2020 THE POWER STEERING WENT OUT COULDN'T STEER TRUCK THEN WITHIN A FEW MINS. LOST THE BRAKES ON THE TRUCK. HAD TO HOLD BRAKES TO FLOOR TO GET TRUCK STOPPED BESIDE OF ROAD. LOOK LIKE LOST FLUID FROM POWER STEERING . WAS A GOOD THING ON A TWO LANE ROAD WITH LITTLE TRAFFIC. WAS ABOUT TO GET ON INTERSTATE HIGHWAY WHERE THIS WOULD HAVE BEEN BAD WITH ALL THAT TRAFFIC AND GOING SPEED LIMIT . WHY WOULD BRAKES GO OUT IF POWER STEERING QUIT?

11/26/2020

ON 3 OCCASIONS SINCE I BOUGHT THE PU NEW ON JULY 24TH, 2020 I EXPERIENCED WHAT THE FORD DEALER NOW CALLS DEATH WOBBLE. THE FIRST TIME HAPPENED ON SEPT 2ND WHILE DRIVING DOWN HILL PULLING MY TRAILER AT ABOUT 50MPH. WHEN I STEPPED ON THE BRAKE THE STEERING WHEEL AND BRAKE PEDAL STARTED TO SHAKE VIOLENTLY. I HAD LITTLE CONTROL UNTIL MY SPEED DROPPED. I TOOK THE PU TO THE DEALER SEPT 16TH. THEY SAID THEY COULD FIND NO PROBLEM AND STATED IF THEIR AGENT COULD NOT EXPERIENCE THE PROBLEM WHILE DRIVING THE PU THEY COULD NOT FIX IT. ON THE SECOND TIME I WAS DRIVING THE PU EMPTY AT HIGHWAY SPEED AND AGAIN WHILE BRAKING THE STEERING AND BRAKES SHOOK VIOLENTLY. UP TO THIS POINT I WAS THINKING THE BRAKES WERE THE PROBLEM. I STARTED TRACKING THE BRAKE TEMPERATURE WHICH SHOWED A LARGE VARIETY OF TEMPS FOR SIMILAR DRIVING CONDITIONS. I PROVIDED THE NUMBERS TO THE DEALER. I WAS TOLD A FEW DAYS LATER ON OCT 29TH THAT THE TEMPS WERE NORMAL AND MY DRIVING STYLE NEEDED TO BE ADJUSTED FOR A VEHICLE OF THIS TYPE. ON THE THIRD TIME NOV 15TH I WAS AGAIN PULLING THE TRAILER BUT THIS TIME AT 40MPH IN WET AND SNOWY CONDITIONS WHEN I STEPPED ON THE BRAKE I EXPERIENCED THE SHAKING TO THE POINT OF LOSING CONTROL. WHEN I TOOK THE PU TO THE DEALER WITH JUST 8000 MILES ON THE TRUCK THEY AGAIN SAID THEY COULD DO NOTHING WITHOUT THEIR AGENT SEEING THE PROBLEM THEMSELVES. BUT THIS TIME ON THE PAPERWORK THEY DESCRIBED THE PROBLEM AS 'DEATH WOBBLE'. I CHECKED THE NHTSA SITE FINDING SEVERAL COMPLAINTS SIMILAR TO MINE. THE INTERNET IS ALSO LOADED WITH COMPLAINTS AND POSSIBLE FIXES SINCE FORD WON'T OR CAN'T FIX THE PROBLEM. FORD CLEARLY KNOWS THIS PROBLEM EXISTS BECAUSE THEY HAVE PUT A NAME TO THE PROBLEM BUT THEY ARE DOING NOTHING ON MY PU (AND MANY OTHERS) TO FIX THE PROBLEM.

12/26/2020

The contact owns a 2020 Ford F-350. The contact received notification of NHTSA Campaign Number: 22V250000 (Visibility) however, the part to do the recall repair was not yet available. The contact stated that while driving at an undisclosed speed, the driver's side windshield wiper made an abnormal sound before the wiper arm detached. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 18,877. VIN tool confirms parts not available.

6/3/2022

The contact owns a 2020 Ford F-350. The contact received notification of NHTSA Campaign Number: 22V250000 (Visibility) however, the part to do the recall repair was not yet available. The dealer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. VIN tool confirms parts not available.

6/6/2022

My truck starting shaking really bad while driving after 45 miles per hour. I went to the repair shop today and they told me it was the death wobble. Could have lost control of truck as it was very terrifying.

8/30/2022

Our 2020 Ford F-350 experienced a catastrophic mechanical failure while in motion. The driveline disconnected, the rear axle locked up, and the transmission bellhousing was destroyed—leaving the truck completely immobile and blocking traffic. This occurred with no prior warning and posed a significant crash risk. At the time, Ford Safety Recall 22S22 (related to a known defect in the transmission’s output planetary four assembly) was open and had not yet been completed. The symptoms and failure we experienced match the failure scenario described in Ford's own bulletin for 22S22: driveline separation, internal transmission damage, and loss of control or Park function. Ford has denied coverage, stating the failure was due to a "loose pinion flange nut" and unrelated to the recall. However, they have not provided any inspection documentation, photos, or evidence that the recalled components were properly inspected or ruled out as the root cause. We have repeatedly requested this documentation from both Ford and the dealership, but neither has provided it. We are concerned that the failure was caused by the exact defect identified in Recall 22S22, and that Ford is failing to take responsibility or follow full recall procedures—including post-failure inspection and transparency. We are requesting that NHTSA investigate this case as a potential mishandling of a known safety defect and failure to comply with recall responsibilities.

7/8/2025

The contact owns a 2020 Ford F-350. The contact stated that when the front passenger’s side door was locked, the door could not be opened from outside the vehicle. The contact state that the door could only be unlocked by using the interior door lock mechanism. The vehicle was taken to the local dealer who was unable to duplicate the failure. After retrieving the vehicle, the failure continued to occur. The contact was later informed by the dealer that the door actuator was likely the cause of the failure and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 34,000.

11/22/2022

The contact owns a 2020 Ford F-350. The contact stated that door latches on both sides of the truck have failed to properly secure the doors. The contact stated that the doors on both sides of the vehicle would shake while driving at various speeds. The dealer was notified of the failure and was informed that there were no recalls on the vehicle and was out of warranty. The manufacturer was notified of the failure and was referred to the NHTSA Hotline for assistance. The vehicle had yet to be repaired. The failure mileage was unknown.

10/10/2023

right side headlight always had condensation and much more condensation than the left side, however, Ford and dealer always said that it was for ventilation. after a rain, the right headlight light was always on, even when the car was off, and after that the right signal and lamp will not turn on anymore. Dealer did changed the whole headlight assembly, however, the issue still there.

11/27/2022

The contact owns a 2020 Ford F-350. The contact stated that her son became aware that the white bulbs in the third brake light had two burned holes and cracks inside. The vehicle had not yet been taken to an independent mechanic or local dealer to be diagnosed or repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The approximate failure mileage was 57,000.

5/16/2023

2020 FORD F-350. CONSUMER WRITES IN REGARD TO TRANSMISSION ISSUES. THE GEARS WERE SLIPPING AND THE ENGINE WAS REVVING WITHOUT STEPPING ON THE GAS PEDAL.

12/16/2022

The contact owns a 2020 Ford F-350. The contact stated while driving 60-65 MPH, the transmission was slipping and unintendedly downshifting. The contact stated that upon driving from a complete stop, the vehicle stalled with the transmission stuck in 10th gear, nearly causing a crash. The contact stated that the vehicle responded as needed upon depressing the accelerator pedal a second time. The contact stated that the failure recurred while driving. The power train malfunction warning light was illuminated. The vehicle was taken to the dealer, who informed the contact that the earliest appointment for a diagnostic test would be approximately 6 weeks. The vehicle was not diagnosed nor repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 25,500.

6/30/2023

The contact owns a 2020 Ford F-350. The contact stated that while driving at various speeds, the transmission was shifting hard between gears. No warning lights were illuminated. The vehicle was previously serviced at a local dealer under Ford Customer Satisfaction Program: 21B03 to replace the No. 1 planetary and ring gear assembly. The vehicle was repaired; however, the contact stated that the failure persisted, and that the vehicle was jerking while shifting between gears. The contact had received notification of NHTSA Campaign Number: 22V256000 (Power Train) and 22V644000 (Back Over Prevention); however, the parts to do the recall repair were unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted and confirmed that parts were not yet available. The manufacturer was contacted and was unable to confirm when parts would be available. The contact was advised to file a complaint with the NHTSA Hotline. The approximate failure mileage was 9,000.

3/8/2023

The contact owns a 2020 Ford F-350. The contact stated while starting the vehicle, the rearview camera became inoperable. The contact stated that the rearview camera image did not display properly and was very blurry. The vehicle was taken to an independent mechanic where it was diagnosed that the printed circuit board for the backup camera failed and needed to be replaced. The dealer was contacted. The vehicle was not diagnosed or repaired. The dealer referred the contact to the manufacturer for assistance. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The approximate failure mileage was 146,913.

12/17/2024

The local dealer (Corwin Ford Reno) and Ford have not resolved the wiper recall issue in a timely manner. The driver-side wiper consistently stalls mid-stroke rendering the vehicle unsafe and unusable during bad or unpredictable weather. I have made multiple attempts since I received notice of the recall to schedule an appointment to have the issue repaired, but the dealership has yet to return a single call.

3/21/2023

Routinely have issues with the wiper arms not returning to resting locations or not working intermittingly while in use. Known issue that has gone completely unresolved. Have been contacting dealership for over a year and logged support issue with Ford Corporate with minimal response and leaving the issue unaddressed. I will attach the support correspondence (or lack there of).

5/8/2023

THE VEHICLE UPON STARTING WILL GIVE TWO WARNINGS: PRE COLLISION NOT AVAILABLE AND STEER ASSIST FAULT SERVICE REQUIRED. THIS DOES NOT HAPPEN ALL THE TIME I TURN VEHICLE OFF AND IT RESETS. I WILL NOT THIS MESSAGE FOR AWHILE AND THEN WILL OCCUR AGAIN I HAVE ALSO NOTICE THAT MY THROTTLE APPEARS TO RAISE ON ITS OWN WHILE DRIVING. THE TAIL GATE ALSO JUST OPENS ON ITS OWN.

1/24/2021

Computer-dash info screens and drive modes. I am unable to change or check onboard dash info upon starting vehicle. Dash does not hold settings one day to the next. Unable to get into or change settings such as trailer settings-so can’t change braking effort-dangerous when hauling 20,000# trailer! Cannot put truck in tow mode or any other mode-defaults to slippery road mode. Again dangerous. Says hill start assist, hill descent assist and pre-collision assist is unavailable . This is all very potentially dangerous especially when hauling! Dealer cannot find problem. After truck is driven a while settings can be re-entered-truck has to be turned off first. Unable to load video of start up.

1/31/2025

The Ford is under a Customer Satisfaction Program 21B03, and Ford will not honor this for our vehicle, however our truck has the number one planetary and ring gear assembly that has gone out.

1/3/2022

Vehicle started not going into gear then all a sudden takes off unexpectedly super fast. It almost caused me hitting a person walking.

6/27/2023

The contact owns a 2020 Ford F-350. The contact stated that the grill, 350 emblem, and driver’s side mirror had melted. There were no warning lights illuminated. The vehicle was taken to the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 200.

4/12/2024

The contact owns a 2020 Ford F-350. The contact stated while driving approximately 45-50 MPH, the passenger's side rearview mirror turned inward unintendedly, which prevented the driver from seeing the roadway. The contact stated that the mirror failed to remain in the correct position, which required the front passenger's side seat occupant to manually hold the rearview mirror at the correct angle for the driver to see the roadway. The dealer was notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and a case was filed. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was unknown.

7/31/2025

TL* THE CONTACT OWNS A 2020 FORD F-350. THE CONTACT STATED THAT THE TAILGATE FAILED TO REMAIN LATCHED WHILE DRIVING. THE CONTACT STATED THAT THE TAILGATE OPENED INDEPENDENTLY THREE TIMES WHILE DRIVING. ON ONE OCCASION, THE TAIL GATE OPENED WHEN THE CONTACT WAS HAULING A TRAILER AND DAMAGE THE TRAILER CAMPER GENERATOR. RANDALL REED'S PLANET FORD (19000 EASTEX FREEWAY, HUMBLE, TEXAS 77338, (800)-850-8751), WAS UNABLE TO DUPLICATE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED. THE FAILURE MILEAGE WAS 1,500. *BF CONSUMER STATED REPAIR WAS DONE ON 2017-2019.*JB

6/1/2020

FIFTH WHEEL ANDERSEN ULTIMATE HITCH SYSTEM FAILED WHILE WE WERE HAULING OUR UNIT. HITCH BROKE AND SAFETY CHAINS ALSO BROKE. UNIT WAS BLOWN OFF THE TRUCK WHILE DRIVING ON THE HIGHWAY CAUSING THE BALL TO BREAK SHEAR OFF DETACHING FROM TRUCK. COMPANY IS NOT WANTING TO DEAL WITH OUR INCIDENT. CAUSED OUR FIFTH WHEEL TO DETACH ON THE HIGHWAY AND ROLLED OVER. WE WERE HAULING UNDER WEIGHT TO WHAT THERE HITCH RECOMMENDS TO STAND 24,000 LBS OF TORQUE. WERE JUST ASKING FOR SOME HELP. OUR NEW $84,000 UNIT IS A COMPLETE LOSS AND OUR TRUCK IS IN THE COLLISION SHOP BEING REPAIRED. THANK YOU*DT*DT CONSUMER STATED MECHANIC DID NOT FIND ANY DAMAGE.*JB*DT*JB*DT*JB*DT*JB

7/3/2020

THE SAME PROBLEM AS THE RECALL IS 20S33. TORGUE CONVERTER DAMPER FRACTURE. THE TRUCK WAS SOLD WITH TECHNICAL PROBLEMS OF THE BACKUP CAMERA, THAT TOTALLY DOESN’T WORK TILL NOW. THE BIGGEST PROBLEMS STARTS ON 07 TH OF OCTOBER 2020, WHEN I NOTICED A HUGE NOISE IN THE CAR ACCORDING TO THE TRANSMISSION SYSTEM. ON THE 08 TH OF OCTOBER 2020, I HAVE BEEN TO DEALERSHIP LOCATED AT 8445 45 TH ST LYONS, IL, 60534, AND I LEFT THE CAR AT THEIR SERVICE CENTER TO DIAGNOSE THE TECHNICAL PROBLEM AND FOR SURE TO SOLVE IT. DURING ONE WEEK THEY CAN’T DIAGNOSE THE PROBLEM. AFTER THAT, THEY CALLED ME, AND SAID THAT THE PROBLEM WAS DIAGNOSED BUT UNFORTUNATELY THEY DIDN’T HAVE THE NECESSARY SPARE PARTS, BECAUSE THE FORD MOTOR COMPANY DOESN’T PRODUCE MORE THIS KIND OF SPARE PARTS. BUT HOW IT’S POSSIBLE TO SELL THE CARS WITHOUT NECESSARIES SPARE PARTS, WHAT HAVE TO DO THE CONSUMER IF THE CAR IS A NEW ONE AND IT BRAKES? THEY DIDN’T REPAIR THE TRUCK IN 30 DAYS; I CALLED THE FORD CUSTOMER SERVICE, BUT THE MS AT THE PHONE TOLD ME THAT THEY CAN’T SOLVE SUCH KIND OF PROBLEMS, AND I HAVE TO FIND ANOTHER DEALERSHIP WHO CAN REPAIRS THE TRUCK. ACCORDING TO THE LAW THEY HAVE TO REPAIR THE CAR IN 30 DAYS, AND THEY DIDN’T, THE CAR IT’S WORSE THEN IT WAS BEFORE. AND NOW I DON’T KNOW WHAT TO DO, WHY THE CAR NEW WARRANTY DOESN’T WORK, THE ADDITIONAL PREMIUM CARE WARRANTY DOESN’T WORK. AND I HAVE TO SAY THAT THE TRUCK IS A NEW ONE, WITH 58 000 MILES. I PAID A LOT OF MONEY FOR THIS CAR, AND NOW I’M IN THE SITUATION THAT I HAVE TO PAY THE CREDIT RATE AND I HAVE NO POSSIBILITY TO DO IT, BECAUSE THE TRUCK IS BROKEN AND I CAN’T WORK. NOW I DROVE THE TRUCK TO ANOTHER SERVICE (NOT FORD) WHERE I WAS TOLD THE COST OF THE REPAIR WOULD COST $7.000. THEY SAID THAT I CANNOT DRIVE THE TRUCK NOW BECAUSE IT IS DANGEROUS.

11/12/2020

The contact owns a 2020 Ford F-350. The contact stated while driving approximately 58 MPH, the steering column started to vibrate excessively. The contact was able to pull over safely. There was no warning light illuminated. The vehicle was taken to a local dealer to be diagnosed; however, the mechanic was unable to determine the cause of the failure. The manufacturer was not informed of the failure. The failure mileage was approximately 19,000.

1/5/2022

The contact owns a 2020 Ford F-350. The contact stated while driving 5 MPH and while going up a hill, the vehicle started to jerk, and the contact felt the vehicle would lose steering. The vehicle was towed to the dealer and they stated that the steering columns needed to be replaced. The manufacturer was not contacted. The failure milage was 146,000.

8/10/2022

The contact owns a 2020 Ford F-350. The contact stated that after the vehicle had been exposed to an extremely cold weather, he attempted to open the front passenger's side door to let his friend in the vehicle. The contact stated that while using the key fob and the door lock switch to attempt to open the door, the front passenger's side door failed to unlock. The contact stated that he was able to open the door by using the interior door handle. The dealer and the manufacturer were notified of the failure and informed the contact that the vehicle was not covered under Ford Campaign Number: 20M04. The dealer advised the contact to take the vehicle to their location to be repaired. The vehicle was not repaired. The failure mileage was approximately 45,500.

2/14/2024

The contact owns a 2020 Ford F-350. The contact stated that the grill, 350 emblem, and driver’s side mirror had melted. There were no warning lights illuminated. The vehicle was taken to the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 200.

4/12/2024

The contact owns a 2020 Ford F-350. The contact stated while driving 65 MPH, the vehicle stalled and experienced loss of power steering functionality and reduced braking functionality, causing the vehicle to almost drive into a ditch while the contact was pulling over to the side of the road. There was no warning light illuminated. The vehicle failed to restart and was towed to the dealer, where it was diagnosed and determined that the high-pressure fuel pump had failed; however, the contact was denied warranty coverage due to fuel contamination. The contact stated that a lab later performed the fuel lab test and confirmed that the fuel was not contaminated. The vehicle was then towed to 1 Way Diesel Performance LLC, where it was determined that the high-pressure fuel pump had failed and had caused metal shavings intrusion into the fuel system. The mechanic determined that the fuel system needed to be replaced. The vehicle was being repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 36,236.

1/2/2025

The contact owns a 2020 Ford F-350. The contact stated that while driving and approaching a stop, the vehicle lost motive power, the brake pedal depressed and went to the floorboard, and the vehicle rolled into the intersection. There were no warning lights illuminated. The vehicle was towed to the local dealer, where it was diagnosed and determined that the fuel pump had disintegrated and there was metal in the fuel system. The vehicle was not repaired. The manufacturer was contacted, but no additional assistance was provided. The approximate failure mileage was 106,000.

6/18/2025

The contact owns a 2020 Ford F-350. The contact stated that while driving and approaching a stop, the vehicle lost motive power, the brake pedal depressed and went to the floorboard, and the vehicle rolled into the intersection. There were no warning lights illuminated. The vehicle was towed to the local dealer, where it was diagnosed and determined that the fuel pump had disintegrated and there was metal in the fuel system. The vehicle was not repaired. The manufacturer was contacted, but no additional assistance was provided. The approximate failure mileage was 106,000.

6/18/2025

The connectors (part #1 HUZZ-14S411-HB) and (part #2 HUZZ-14S411-FA) are located in on the frame of the truck where the back wheels throw water towards when driving on wet terrain. They tend to hold water which causes electrical damage. This is happening on multiple ford trucks from 2020 - current models. This is causing tail light, AC, radio and other failures to occur.

7/10/2025

The connectors (part #1 HUZZ-14S411-HB) and (part #2 HUZZ-14S411-FA) are located in on the frame of the truck where the back wheels throw water towards when driving on wet terrain. They tend to hold water which causes electrical damage. This is happening on multiple ford trucks from 2020 - current models. This is causing tail light, AC, radio and other failures to occur.

7/10/2025