2025 Ford F-150 Owner Complaints

When backing Ford f-150 up on any kind of an incline rear end is locked up for about ten seconds causing a safety risk. When shifting from reverse to drive. Does not do this on a flat surface. Have almost been hit three times now by cars coming around the corner of my street. Does not throw a code. Been at dealership a couple weeks. Dealership sent tech to house to observe. Did it every time! Truck only has 800 miles on it.

4/5/2025

Loss on all braking systems. Multiple warning lights including on dash. Brakes will become spongy and not stop or lock up all 4 wheels at slightest touch. Taken to dealer who provided a service memo SSM 53683 which basically says vehicle unable to power down and no fix available. Ford is aware of the problem and has done nothing to fix this despite multiple phone calls and emails. This is a significant safety issue Vehicle is also brand new will less than 1000 miles on it

6/2/2025

A piece of reflective cloth like material has fallen from underside of truck bed and onto tailpipe and begun to burn. This creates a fire hazard for anybody using this vehicle. I have two of these similar trucks and it’s happening to both of them before 500 miles.i don’t know if the issue has been verified of reproduced by anybody. The vehicle has not yet been inspected by the dealer or manufacturer. There were no warning lamps or symptoms prior to me finding this by chance as I was replacing a wheel.

7/7/2025

Rear, side and front camera system complete failure. No seemed cause to the issue. Cannot use any of the cameras during the driving session until a power cycle is completed Around 30mi: Dealer inspected once and power cycled it. System fixed. Around 650mi: I power cycled the system and reset it.

8/17/2025

The Ford BlueCruise system almost got my family and myself rear ended with possibly a major injury to death. On our way to San Antonio, Texas from Houston, Texas we were driving across [XXX] withe the BlueCruise engaged. Then out of no where it started giving me the message to place my hands on the steering wheel. My hands were on the steering wheel. It gave me the message 3 times. Then it shook the steering wheel at the same time flashing Resume control. Then it slammed on the brakes. Luckily the truck behind us was paying attention and slammed on their brakes slowing their vehicle down. They drove around us. My wife asked if I did that and I said No, it was the truck. It also did it on the way back to Houston, Texas. After several times of the BlueCruise acting up, I took the truck back to the dealership. It was also turned in for the Brake system recall. iT has been at the dealership for just over a week now p w. The dealership; Tomball Ford, contacted me saying their technician and QC tech couldn't replicate the issue. So, i went up there and had; Ray, the QC tech ride with myself in the truck. Within a mile or 2 the truck's BlueCruise did exactly the same thing. We turned around to head back to the dealership and the truck did it again, but worse. This time the brakes engaged 3 to 4 times slowing the truck down from 60 mph to 30 mph and turning on the Hazard flashers before I turned it off. This time numerous vehicles slowed down and swerved to avoid rereading my truck with both myself and the Tomball Ford QC technician. All the QC technician said, was, "Oh, that's not supposed to do that." I was like [XXX] But your technician couldn't replicate that? The truck is in the shop, but I do have the messages from the service advisor; Ashly, from Tomball Ford. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

8/28/2025

Ford BlueCruise cut-in non-response Incident date/time: September 29, 2025, ~6:15 PM Location: US-290 East, near Waller, Texas Vehicle: 2025 Ford F-150 Lightning System: Ford BlueCruise (hands-free driver assistance) While traveling eastbound on US-290 with BlueCruise engaged (hands-free with lane centering and adaptive cruise), an 18-wheeler flatbed changed into my lane directly ahead. The system did not decelerate or otherwise respond to the cut-in and continued closing speed on the truck. After a couple of seconds, I manually and rapidly disengaged and braked to prevent a rear-end collision. No contact occurred, but the lack of deceleration created an immediate crash risk.

10/8/2025

When backing Ford f-150 up on any kind of an incline rear end is locked up for about ten seconds causing a safety risk. When shifting from reverse to drive. Does not do this on a flat surface. Have almost been hit three times now by cars coming around the corner of my street. Does not throw a code. Been at dealership a couple weeks. Dealership sent tech to house to observe. Did it every time! Truck only has 800 miles on it.

4/5/2025

Brakes failed on my 2025 F150 and several ABS and brake system alarms came in. The problem went away on its own. I took the truck to my dealer and was told Ford is aware of the problem and does not have a fix. No other advice was given.

5/14/2025

1st incident: shift lever on centre consul " froze" in recessed position and vehicle could not be shifted into gear. Mileage at 500. 2nd incident: Mileage at 1600. With engine running, shift lever " froze" in reverse gear and couldn't be moved. If this happen on a busy street or highway, something serious could occur, even life threatening.

3/30/2025

The "service" light comes on frequently with a message that there's a powertrain/loss of power issue.

6/27/2025

On October 8, 2025, my wife and I purchased a 2025 Ford F-150 Lariat, 3.5L Full Hybrid, with Ford's BlueCruise hands-free driving feature. As first-time users, I reviewed the owner's manual and Ford’s videos to understand BlueCruise. After several uses, I noted unpredictable behavior and now report a serious safety issue warranting federal investigation. On October 15, 2025, while driving north on I-95 near Boston with BlueCruise engaged in hands-free mode on an approved route, I pressed the Memory 1 recall button to adjust my seat. A chime sounded, and the instrument panel stated that Memory Recall is not active while the vehicle is moving. Unexpectedly, pressing the button deactivated BlueCruise, causing immediate deceleration and returning steering control to me. During a shallow left turn, the vehicle proceeded straight, almost deviating from the lane. I quickly regained control, preventing a lane departure. The owner’s manual and Ford’s resources do not mention that Memory Recall can deactivate BlueCruise. This undocumented behavior is highly concerning. On October 20, I contacted Ford (Reference Number [XXX] ), but their response was inadequate, offering only a generic process without technical team access or follow-up commitment. BlueCruise’s lane-centering struggles with unclear or conflicting lane markings. On I-95 sections under resurfacing, temporary markings are placed 1-2 feet from fainter original lines. BlueCruise inconsistently tracks either set, causing unpredictable lateral movements, including sudden lane-edge excursions or rapid shifts over bridges where markings misalign. When another vehicle overtakes closely, crossing into our lane, BlueCruise momentarily loses lane-keeping ability due to obstructed markings, resulting in rapid steering movements. While such overtaking reflects poor driving by others, an automated system must handle these common scenarios reliably. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

10/20/2025

Ford BlueCruise steering oscillation •Date/Time: October 17, 8:00 PM •Location: Hempstead, Texas •System: Ford BlueCruise (hands‑free lane‑centering/driver‑assist) BlueCruise was engaged in hands‑free mode when, without driver input, the system became confused and initiated repeated left/right steering corrections. The vehicle weaved within the lane several times in quick succession, requiring immediate intervention to maintain control and prevent a collision. After I took over, the vehicle tracked normally with manual steering. This behavior represents a serious safety hazard.

10/28/2025

Ford BlueCruise cut-in non-response Incident date/time: September 29, 2025, ~6:15 PM Location: US-290 East, near Waller, Texas Vehicle: 2025 Ford F-150 Lightning System: Ford BlueCruise (hands-free driver assistance) While traveling eastbound on US-290 with BlueCruise engaged (hands-free with lane centering and adaptive cruise), an 18-wheeler flatbed changed into my lane directly ahead. The system did not decelerate or otherwise respond to the cut-in and continued closing speed on the truck. After a couple of seconds, I manually and rapidly disengaged and braked to prevent a rear-end collision. No contact occurred, but the lack of deceleration created an immediate crash risk.

10/8/2025

Ford BlueCruise steering oscillation •Date/Time: October 17, 8:00 PM •Location: Hempstead, Texas •System: Ford BlueCruise (hands‑free lane‑centering/driver‑assist) BlueCruise was engaged in hands‑free mode when, without driver input, the system became confused and initiated repeated left/right steering corrections. The vehicle weaved within the lane several times in quick succession, requiring immediate intervention to maintain control and prevent a collision. After I took over, the vehicle tracked normally with manual steering. This behavior represents a serious safety hazard.

10/28/2025

On the morning of Wednesday May 28, 2025 I walked out to 2025 Ford F-150 (5200 miles) when it suddenly sounded as if someone shoot a gun towards me. After standing back up I saw the rear glass had shattered looking as if it exploded from inside out due to the glass being in truck bed and not inside back seat. The four corners of glass were all broken off with giant hole in middle. The truck engine was not on and I had front passenger door open. I called Ford and they stated that they have never seen or heard of this, although I googled it and have seen many forums on same thing happening, and that they are not responsible. It is crazy to think about this happening if I had been driving when this happened and the potential accidents this could have caused on the road.

5/28/2025

Backup camera failure after dealer replaced entire interior main body harness

10/21/2025

Short loss of control with a short period of excessive play and a slight shimmy/shaking sensation when turning left into a curve. The issue seems to only occur when turning to the left.

8/26/2025

On October 8, 2025, my wife and I purchased a 2025 Ford F-150 Lariat, 3.5L Full Hybrid, with Ford's BlueCruise hands-free driving feature. As first-time users, I reviewed the owner's manual and Ford’s videos to understand BlueCruise. After several uses, I noted unpredictable behavior and now report a serious safety issue warranting federal investigation. On October 15, 2025, while driving north on I-95 near Boston with BlueCruise engaged in hands-free mode on an approved route, I pressed the Memory 1 recall button to adjust my seat. A chime sounded, and the instrument panel stated that Memory Recall is not active while the vehicle is moving. Unexpectedly, pressing the button deactivated BlueCruise, causing immediate deceleration and returning steering control to me. During a shallow left turn, the vehicle proceeded straight, almost deviating from the lane. I quickly regained control, preventing a lane departure. The owner’s manual and Ford’s resources do not mention that Memory Recall can deactivate BlueCruise. This undocumented behavior is highly concerning. On October 20, I contacted Ford (Reference Number [XXX] ), but their response was inadequate, offering only a generic process without technical team access or follow-up commitment. BlueCruise’s lane-centering struggles with unclear or conflicting lane markings. On I-95 sections under resurfacing, temporary markings are placed 1-2 feet from fainter original lines. BlueCruise inconsistently tracks either set, causing unpredictable lateral movements, including sudden lane-edge excursions or rapid shifts over bridges where markings misalign. When another vehicle overtakes closely, crossing into our lane, BlueCruise momentarily loses lane-keeping ability due to obstructed markings, resulting in rapid steering movements. While such overtaking reflects poor driving by others, an automated system must handle these common scenarios reliably. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

10/20/2025

My brand new truck with 3500 miles when the cruise control is set to a speed the truck will randomly accelerate un commanded. This occurs when for no reason the cruise control will select 95 MPH if you at 75 MPH. It will do this at any speed selected. This uncommanded speed can occur multiple times within minutes or can late as long as 30 minutes. Also this uncommanded speed can also occur at lower speed set in the cruise control. This can only be corrected by hitting the brake. This is especially dangerous in traffic and on curves. This has happened in both places as well as on long stretches. I almost rear ended a car in front of me in traffic as I was going 55 and when the speed changed to 95 the truck floored the accelerator with full engine power.

4/10/2025

On November 2nd, 2025 at approximately 6pm, in Houston, Texas, my 2025 Ford F‑150 with Ford BlueCruise engaged in Hands‑Free mode was traveling with traffic at about 70 mph on a major thoroughfare. Without driver input, the system rapidly reduced speed to about 50 mph after it appeared to misinterpret an unknown speed‑limit change. This sudden, uncommanded deceleration created a hazardous speed differential with surrounding traffic. I swiftly took over manual control to maintain traffic flow and prevent a potential rear‑end collision. No crash or injury occurred, but the behavior constitutes phantom braking and false speed‑limit recognition in an Advanced Driver Assistance System feature.

11/3/2025

The third brake lights on this generation Raptor are very, very dim. There are three individual/small LED lights, and when the tail lights are on, which includes the third brake light on these vehicles since they act as marker lamps due to the vehicle's width), the third brake lights are not noticeable. This is especially bad in the daytime if the headlights are on, because there is almost no difference in luminescence between the tail lights and brake lights.

10/4/2025

Water erosion to the wiring harness to the front headlights led to an outage of the LEDs on glad of the vehicle.

12/1/2025

When backing Ford f-150 up on any kind of an incline rear end is locked up for about ten seconds causing a safety risk. When shifting from reverse to drive. Does not do this on a flat surface. Have almost been hit three times now by cars coming around the corner of my street. Does not throw a code. Been at dealership a couple weeks. Dealership sent tech to house to observe. Did it every time! Truck only has 800 miles on it.

4/5/2025

The contact owns a 2025 Ford F-150 equipped with Hankook Tires, Tire Line: Dynapro A/T 2, Tire Size: 275/60/R20, DOT Number: (N/A). The contact stated that upon inspection, it was discovered that the rear passenger’s side tire had a 3/4-inch sized tread separation. A replacement tire was installed. The contact later discovered that the same failure had occurred with the front passenger’s side tire. The cause of the failures were not yet determined. The manufacturer and local dealer were notified of the failure. The failure mileage was 5,000.

6/11/2025

The contact owns a 2025 Ford F-150. The contact received notification of NHTSA Campaign Number: 25V341000 (SUSPENSION). While attempting to schedule a recall repair appointment, several dealers in the area either failed to answer the phone, and several other dealers were unable to schedule an appointment. However, Loveland Ford (3905 Mountain Lion Dr, Loveland, CO 80537, Phone: (970) 744-7101) initially offered to schedule a mobile appointment but later retracted the offer. The contact notified the manufacturer of the issue. The manufacturer attempted to reach the dealers to schedule a recall repair appointment and was unsuccessful. The contact was seeking assistance in resolving the issue. The contact had not experienced a failure. Parts distribution disconnect.

7/25/2025

Ford BlueCruise cut-in non-response Incident date/time: September 29, 2025, ~6:15 PM Location: US-290 East, near Waller, Texas Vehicle: 2025 Ford F-150 Lightning System: Ford BlueCruise (hands-free driver assistance) While traveling eastbound on US-290 with BlueCruise engaged (hands-free with lane centering and adaptive cruise), an 18-wheeler flatbed changed into my lane directly ahead. The system did not decelerate or otherwise respond to the cut-in and continued closing speed on the truck. After a couple of seconds, I manually and rapidly disengaged and braked to prevent a rear-end collision. No contact occurred, but the lack of deceleration created an immediate crash risk.

10/8/2025

See attached document for complaint.

10/16/2025

When in reverse the backup Camera Goes to a clear image then randomly goes from a Black screen to a Green Screen and then back to normal. During that whole process and chime goes off in the truck. A message is displayed on the dash but it disappears too fast. The dealership has been able to recreate the problem but unable to repair my truck because they can’t catch the truck doing that error while hooked up to their computer system. Happens about twice a week.

10/18/2025

When in reverse the backup Camera Goes to a clear image then randomly goes from a Black screen to a Green Screen and then back to normal. During that whole process and chime goes off in the truck. A message is displayed on the dash but it disappears too fast. The dealership has been able to recreate the problem but unable to repair my truck because they can’t catch the truck doing that error while hooked up to their computer system. Happens about twice a week.

10/18/2025

The contact owned a 2025 Ford F-150. The contact stated that while driving at 60 MPH, and while depressing the brake to stop the vehicle from hitting a stopped vehicle, the rear end locked up and did not slow down as intended, and the front of the vehicle collided with the rear of the stopped vehicle. The contact sustained a broken sternum and had a concussion, and needed medical attention at a later time. A police report was taken. The vehicle was towed to two tow lots, where it was deemed a total loss. The contact stated that one day she received notification of NHTSA Campaign Number: 25V488000 (Service Brakes, Hydraulic), four days later in the mai,l and believes the failure to be associated with the unrepaired recall. The manufacturer was notified of the failure. The failure mileage was approximately 10,200.

10/20/2025

The following components have failed multiple times over the course of 3 months to include the above referenced recalls and additional components. The recalls have been completed per ford . The instrument panel was not going blank until the software update was completed now it malfunctions multiple times a day . The brake warning will appear randomly and without warning depicting "Brake System Fault" service required . "Parking Brake Fault " service required immediately. In addition to the above issues the entire lighting/lamp system will turn off unwarranted at night while on auto . Reported multiple issues as described to AutoNation Ford and Ford Credit. No resolution has been provided.

11/17/2025

My 2025 F-150 Tremor (5.0 V8, 402A package with modular front bumper) has a large open area in the front bumper. Through this opening you can clearly see the front of the engine and related components. This appears to be a design issue rather than a one-off build problem. Other 2025 Tremor owners with the same 402A modular bumper are reporting the same concern and asking whether a cover is missing from the factory. My concern is that the exposed opening could allow rocks, road debris, or off-road obstacles to directly impact vital components at highway speed or when driving on rough/uneven surfaces. This may increase the risk of damage, fluid leaks, or sudden loss of power/steering if components are struck. It also appears inconsistent with typical under-engine protection on off-road-oriented trims. I am asking NHTSA to review whether this bumper configuration provides adequate protection for critical components on the 2025 F-150 Tremor and whether a design change or shield/plate is needed for safety.

11/24/2025

My 2025 F-150 Tremor (5.0 V8, 402A package with modular front bumper) has a large open area in the front bumper. Through this opening you can clearly see the front of the engine and related components. This appears to be a design issue rather than a one-off build problem. Other 2025 Tremor owners with the same 402A modular bumper are reporting the same concern and asking whether a cover is missing from the factory. My concern is that the exposed opening could allow rocks, road debris, or off-road obstacles to directly impact vital components at highway speed or when driving on rough/uneven surfaces. This may increase the risk of damage, fluid leaks, or sudden loss of power/steering if components are struck. It also appears inconsistent with typical under-engine protection on off-road-oriented trims. I am asking NHTSA to review whether this bumper configuration provides adequate protection for critical components on the 2025 F-150 Tremor and whether a design change or shield/plate is needed for safety.

11/24/2025

Normal driving to work. Airbag light came on. Notification on Ford app about front air bag system not working correctly. Contact Ford for service. Contacted Denooyer Ford for service that was recommended. Same dealership I purchased the truck from. Service was able to schedule me within a week but recommended not driving the vehicle as it possibly didn't have working airbags. During service they corrected 2 other recalls on the vehicle and informed me that the air bag system warranty work would be 1-2 years on replacement parts. Dealer recommended not driving vehicle till proper replacement parts got installed to correct faulty air bag sensor in seat. Dealer told me that they don't have any rental vehicles in the meantime. 1-2 years of not driving a new vehicle is not acceptable.

11/29/2025

Normal driving to work. Airbag light came on. Notification on Ford app about front air bag system not working correctly. Contact Ford for service. Contacted Denooyer Ford for service that was recommended. Same dealership I purchased the truck from. Service was able to schedule me within a week but recommended not driving the vehicle as it possibly didn't have working airbags. During service they corrected 2 other recalls on the vehicle and informed me that the air bag system warranty work would be 1-2 years on replacement parts. Dealer recommended not driving vehicle till proper replacement parts got installed to correct faulty air bag sensor in seat. Dealer told me that they don't have any rental vehicles in the meantime. 1-2 years of not driving a new vehicle is not acceptable.

11/29/2025