2020 Ford Ecosport Owner Complaints

Driving on the interstate the low oil pressure light came on no check engine lights or anything . The oil pump is belt driven aka wet belt and the rubber teeth come off stopping up the oil pump and causing it not to work properly . With the rubber pieces going into the motor the rubber melts causing issues with the pistons and engine block. The Ford dealership recommends not replacing just the oil pump because of all the other issues the rubber belt causes because it melts inside the engine . So I am left with no choice but to replace the engine at a cost of 5,000.00. Why there hasn't been a recall is questionable . I am in the process of getting said motor replaced but does that mean every 2 years it will have same issues ?

12/13/2022

My husband was driving home from work when he heard a boom. He had thought he hit something but didn’t feel or see anything. A few minutes later he saw smoke coming from the engine and thought maybe a hose had come off or something so he pulled into a parking lot. When he lifted the hood the car was on fire.

2/8/2023

The contact owns a 2020 Ford EcoSport. The contact stated that while driving at undisclosed speeds, the check engine warning light illuminated. The vehicle was taken to the local dealer, where the PCM was reset. The vehicle was repaired, but the failure recurred. The contact stated that while driving at approximately 35 MPH, the oil light illuminated. The vehicle was towed to the local dealer, where it was diagnosed and determined that the oil pump had failed, and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was approximately 84,000.

11/3/2023

The contact owns a 2020 Ford EcoSport. The contact stated that while his daughter was driving out of a parking lot, the low oil pressure warning light illuminated, and the engine made an abnormally loud sound. The contact's daughter parked the vehicle. The vehicle was towed to the dealer, where it was diagnosed and determined that the engine needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Action Number: PE23015 (Engine and Engine Cooling). The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 78,000.

11/3/2023

The contact owns a 2020 Ford Ecosport. The contact stated that while the gear shifter was in park, the contact exited the vehicle to retrieve an item and without warning, the vehicle started rolling backwards. The contact ran and entered the vehicle and slammed on the brake pedal to stop the vehicle. The vehicle was not diagnosed nor repaired. Neither the dealer nor the manufacturer was notified of the failure. The failure mileage was approximately 17,904.

8/25/2021

Was leaving work and suddenly the oil pressure light came on and the engine started making a terrible noise. I pulled over and had the car towed to the Ford dealership. The dealership inspected it and said that the oil pump belt "shredded" and the sudden loss of oil pressure, along with the debris from the oil pump belt, completely ruined both the motor and the turbo requiring full replacement of both at a cost of $6500. Car was purchased new less than 2 1/2 years before but Ford will not pay for the repairs.

3/8/2023

FOR SOME REASON SCREEN ON MY ENTERTAINMENT CENTER ON ECOSPORT GOES BLACK. SO FAR I HAD TWO SOFTWARE UPDATES AND ONE SCREEN REPLACEMENT BUT THE PROBLEM STILL APPEARS. I AM SO PISSED OFF WITH THIS THAT MY DEALER IS NOT ABLE TO FIX THIS PROBLEM. FOR SOME REASON SCREEN ON MY ENTERTAINMENT CENTER ON ECOSPORT GOES BLACK. SO FAR I HAVE HAD TWO SOFTWARE UPDATES AND ONE SCREEN REPLACEMENT BUT THE PROBLEM STILL APPEARS. I AM SO PISSED OFF WITH THIS THAT MY DEALER IS NOT ABLE TO FIX THIS PROBLEM ALWAYS THIS PROBLEM APPEARS WHEN I TURN THE GEAR FROM PARKING TO DRIVE OR DRIVE TO PARKING OBVIOUSLY WHEN I SWITCHED THE GEARS, NEVER WHEN I DRIVING SO FAR ON 1/7/21, 1/20/21, 2/12/21, 4/15/21

4/21/2021

Car was parked in the driveway and back windshield shattered out of no where. We were outside when we heard the explosion as it happened.

6/27/2021

While driving my 2020 Ford Ecosport it spontaneously caught fire and exploded on Sunday, May 29th. •I purchased my 2020 Ford Ecosport from Ford or Helfman Ford in Stafford Texas on Monday, May 25th, 2020. I immediately had problems with the vehicle and have taken the vehicle in multiple times for overheating issues and the check engine light coming on. •May 25th, 2020 – overheating and coolant light came on. Vehicle taken to Planet Ford in Dallas May 28, 2020. Vehicle repaired and picked up from Planet Ford on May 29th, 2020. •May 30th, 2020 - check engine light came back on. Vehicle taken back to Planet Ford in Dallas June 2, 2020 and I picked it up. Vehicle repaired and picked and I picked June 5, 2020. •April 2nd, 2021, I took it the vehicle to Helfman Ford for routine maintenance and the continuous check engine light problem. I received the car back the same day with paperwork stating that they could not re-create the problem. •August 4th 2021, I took it back to Helfman Ford, vehicle was running very rough and was extremely loud. On 10/06/2020 the vehicle was returned after extensive repairs were done to exhaust and engine under warranty (see repair invoice). •My check engine light and coolant light continued to come on sporadically producing the same error messages in the Ford app for my car. •On May 7, 2022 My check engine light come back on and I received an error message that I had never seen prior but as soon as I stopped the message went away •On May 17, 2022 I took the car in one final time too Planet Ford Dallas. They replaced the coolant sensor but were not able to replicate the error and I was told since they could not produce the error, •On May 29, 2022 at 2:08 while driving the check engine came on, and I lost all engine power. Smoke started coming from the engine area and within seconds from exiting the vehicle the engine was on fire and the car exploded.

4/25/2023

I purchased the 2020 Ford Ecosport in July 2022 from bulter Ford in milledgville ga I have been having problems with the car barely pulling up a hill when driving and I can feel the car jerking while driving feeling like it's going to cut off in the road I have been to the bulter shop 5 times and nothing is working it is still doing the same thing they say they can't find anything wrong I have not had a good ride out of the 8 month I have had the car I need help

5/30/2023

TL* THE CONTACT OWNS A 2020 FORD ECOSPORT. THE CONTACT STATED THAT WHILE DRIVING OR WHILE IN REVERSE, THE BRAKE PEDAL WAS DEPRESSED AND THE CONTACT HEARD AN ABNORMAL SOUND. THE FAILURE RECURRED TWICE. THE VEHICLE WAS TAKEN TO CAGUAS EXPRESSWAY MOTORS, CAGUAS, 00725, PUERTO RICO AND WAS INFORMED THAT THE BRAKE DRUM AND PLATE NEEDED TO BE ADJUSTED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN BACK TO THE DEALER AND WAS INFORMED THAT UNKNOWN REPAIRS TO THE BRAKES WERE BEING PERFORMED. THE VEHICLE WAS NOT YET REPAIRED. THE MANUFACTURE WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 8,600.

12/21/2020

The Brake system emits a squeaking, moan/groan sound when backing up. The vehicle is available for inspection upon request. The concern was that any sound not usual to the operation of the vehicle is a warning of a potential problem. No warning lights appeared. This problem was inspected, confirmed/diagnosed at a Ford dealer in Huntington, WV. The problem was supposed to be remedied with the replacement of the rear braking system(pads, rotors. and slides). The vehicle had 19,736 miles on it but the dealer said it was not a warranty item and charged $600.00 for the repair. The problem was not corrected. The manufacturer was contacted. A Ford representative contacted the dealer and was convinced by the dealer that nothing could be done to remedy this condition. Hence it still poses a threat to the safety of the vehicle. I researched the issue via the internet and found a considerable number of postings relating the same problem from other 2018-2020 Ford Ecosport owners. The results of their efforts mirrored mine. A video of the problem (post repair) is available but not able to download in this format.

12/18/2022

For the 2nd time in about 8-10 months, while braking and having nearly come to a stop, on a slight incline, the car had a sudden acceleration. Driver repeatedly stomped on the brake as the car tried to leap forward. Extremely dangerous. No warning lights. I know the dealer won’t do anything because they won’t be able to reproduce it. Conditions were mild, slight sprinkle. I bought the car from a dealer with 5000 mile on it. Wonder whether original owner experienced a similar problem.

9/10/2023

The contact owns a 2020 Ford EcoSport. The contact stated that while driving at an undisclosed speed and attempting to overtake another vehicle, the vehicle failed to accelerate as needed. The contact was able to drive to the shoulder. The check engine warning light was illuminated. The vehicle was towed to the residence. On another occasion while driving at an undisclosed speed, the vehicle lost motive power. The vehicle was driven to the local dealer, but the dealer was unable to determine the cause of the failure. The vehicle was not diagnosed or repaired. The contact stated that vehicle occasionally failed to start. The vehicle was taken to the local dealer, where it was diagnosed and determined that the battery needed to be replaced. The vehicle was repaired, but the failure persisted. The manufacturer was not contacted. The failure mileage was approximately 73,950.

2/22/2024

THIS CAR WAS HIT AND THE SEAT BENT. I AM STILL DEALING WITH HIP NECK KNEE AND SHOULDER INJURIES. IT WAS A RENTAL CAR. I WAS SITTING AT A RED LIGHT. AN 8 TON BOX TRUCK HIT IT GOING APPROX 45 MPH. I SUSTAINED A CONCUSSION. 2 MONTHS LATER I HAD A HEMORRHAGIC STROKE.

1/3/2021

Suspension will start going up and down not safe while driving

7/17/2022

The contact owns a 2020 Ford Ecosport. The contact stated that while stopped and attempting to make a left turn, another vehicle ran a red light and T-boned his vehicle. Due to the impact, his vehicle slammed into a guardrail on a bridge, nearly knocking the vehicle over the bridge. The contact stated that all curtain side airbags were deployed; however, his driver and passenger side airbags did not deploy. The contact stated that he was trapped in the vehicle and had to wait for authorities to assist him out of the vehicle. The contact was rushed to the hospital but decided to leave after a long wait in the emergency room. The contact stated that he did have soreness to his right shoulder and right arm. A police report was filed (210066310). The whereabouts of the other driver were unknown. The vehicle was towed to an independent body shop where it remained in their possession after the contact was given an estimate for repair. Upon investigation, the contact linked his failure to NHTSA Campaign Number: 20V791000(Air Bags). The dealer nor the manufacturer had yet to be notified of the failure. The vehicle had yet to be repaired. The failure mileage was approximately 20,310.

10/1/2021

I rear ended a car got a concussion because my airbags did not deploy

9/13/2022

The contact owns a 2020 Ford EcoSport. The contact stated that upon cleaning the vehicle, he noticed water on the floorboard under the front passenger's seat. The contact cleaned up the water; however, the failure recurred on another occasion. The contact stated that there was a significant amount of water under the front passenger's seat. The vehicle was taken to the local dealer, where it was inspected. The local dealer determined that the failure occurred because the sunroof drain was clogged. The sunroof drain was cleaned; however, the failure persisted. The contact stated that the water accumulation had generated rust and unknown electrical failures. The vehicle was later taken to a second dealer Al Packer Ford West Palm Beach (1530 N Military Trl, West Palm Beach, FL 33409), to a third dealer Wayne Akers Ford (2000 10th Ave N, Lake Worth Beach, FL 33461), and to several unknown dealers who determined that the water could be leaking from the A/C evaporator and condenser. The vehicle was not repaired. Additionally, the contact stated while driving 20 MPH, the engine seized inadvertently. Several unknown warning lights were illuminated. The contact was able to pull to the side of the road. The vehicle was towed to the local dealer, where it was diagnosed and determined that the engine had seized and needed to be replaced. The engine was replaced. Additionally, the contact stated that the front driver's side and front passenger's side doors check arm had cracked. The local dealer replaced the parts; however, the failure recurred. Additionally, the contact stated that the four doors check arms had cracked. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 25,000.

11/17/2023

Driving around town and the low oil pressure warning come on the dash and the vehicle had loss of power. The vehicle was parked the oil was full and oil changed was done 2 weeks earlier. No the vehicle sounds load.

12/18/2023

THIS CAR WAS HIT AND THE SEAT BENT. I AM STILL DEALING WITH HIP NECK KNEE AND SHOULDER INJURIES. IT WAS A RENTAL CAR. I WAS SITTING AT A RED LIGHT. AN 8 TON BOX TRUCK HIT IT GOING APPROX 45 MPH. I SUSTAINED A CONCUSSION. 2 MONTHS LATER I HAD A HEMORRHAGIC STROKE.

1/3/2021

Suspension will start going up and down not safe while driving

7/17/2022

Suspension will start going up and down not safe while driving

7/17/2022

On December 07 2023 while driving off the interstate my vehicle abruptly stopped. It wouldn't accelerate at all and came out of no where. I had my kids in the car but thankfully I was close enough to their school that I was able to pull over and call a tow to take it to a dealership. That same day a service warning came up on the app that I did not see until after my car stalled on me saying there was a "Service Engine Soon Warning" On the app it stated: "The Engine Control system has detected that one of the engines internal components is not responding as expected. This can be caused by improper engine oil pressure or improperly operating engine timing components. The Engine Start/Stop feature (if equipped) may be disabled when this fault is present." The next step was: "Have your vehicle checked by an authorized dealer as soon as possible." It was 830 at night at this point I was not in the position to have it checked at this time but again it was towed to the dealership. At this time there had been ZERO recalls on this vehicle and I am diligent about getting my service done on it. Also I had no reason until this day to look up any issues with this vehicle but when I did I was furious to see that since September 2023 Ford has been made aware of this ongoing issue and had not issues a recall on my or other's vehicles. I am well within my 60K Powertrain warranty thankfully unlike others and my engine was replaced. I picked up my vehicle after repairs on January 03 2024. 1 Month later AGAIN while driving with my children in the car trying to get home in a snow storm my vehicle completely stopped and this time it would not budge. I could not safely get to the side of the road. I could not go in neutral it did nothing. Again it has been towed. Again the engine "has to be replaced" again the same issue is happening and it wasn't until February 23rd did I finally receive an advance notice. I am furious at the lack of safety for myself and my children in this car.

3/6/2024

THIS CAR WAS HIT AND THE SEAT BENT. I AM STILL DEALING WITH HIP NECK KNEE AND SHOULDER INJURIES. IT WAS A RENTAL CAR. I WAS SITTING AT A RED LIGHT. AN 8 TON BOX TRUCK HIT IT GOING APPROX 45 MPH. I SUSTAINED A CONCUSSION. 2 MONTHS LATER I HAD A HEMORRHAGIC STROKE.

1/3/2021

205/50/17 Tires were cut with knife

7/17/2022

The contact owns a 2020 Ford EcoSport. The contact stated that upon cleaning the vehicle, he noticed water on the floorboard under the front passenger's seat. The contact cleaned up the water; however, the failure recurred on another occasion. The contact stated that there was a significant amount of water under the front passenger's seat. The vehicle was taken to the local dealer, where it was inspected. The local dealer determined that the failure occurred because the sunroof drain was clogged. The sunroof drain was cleaned; however, the failure persisted. The contact stated that the water accumulation had generated rust and unknown electrical failures. The vehicle was later taken to a second dealer Al Packer Ford West Palm Beach (1530 N Military Trl, West Palm Beach, FL 33409), to a third dealer Wayne Akers Ford (2000 10th Ave N, Lake Worth Beach, FL 33461), and to several unknown dealers who determined that the water could be leaking from the A/C evaporator and condenser. The vehicle was not repaired. Additionally, the contact stated while driving 20 MPH, the engine seized inadvertently. Several unknown warning lights were illuminated. The contact was able to pull to the side of the road. The vehicle was towed to the local dealer, where it was diagnosed and determined that the engine had seized and needed to be replaced. The engine was replaced. Additionally, the contact stated that the front driver's side and front passenger's side doors check arm had cracked. The local dealer replaced the parts; however, the failure recurred. Additionally, the contact stated that the four doors check arms had cracked. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 25,000.

11/17/2023

Oil pump failure because of Ford recall on broken oil pump belt- driving down the interstate with no place to pull over about getting ran over by semi bc the car suddenly stopped with any warning or anything. Ford won’t even look at my vehicle because over 60,000 miles warranty with vehicle have 66,000 miles on it I purchased the car brand new with 25 miles on it .. only way ford or a dealership said they would even look at it is if I’m willing to pay a 100% out of pocket til then they refuse to do absolutely anything

1/17/2024

The contact owns a 2020 Ford EcoSport. The contact stated that while driving at an undisclosed speed, there was an abnormally loud sound coming from the engine, and the oil pressure warning light illuminated. The contact pulled over to the side of the roadway and turned off the vehicle. The vehicle was then towed to the local dealer to be diagnosed, where belt fragments and metal shavings were found in the oil pan. The contact was advised by the local dealer that the long block, turbocharger, and lubricating system needed to be replaced. The vehicle was not repaired. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling) however, the parts to do the recall repair were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure. The failure mileage was 67,000. VIN tool confirms parts not available.

1/23/2024

As I was driving the car started smoking and then caught on fire. Full flames for the front I had to rush out the car.

2/18/2024

The engine oil pump dive belt tensioner arm broke, and it caused damage to the engine, causing the engine to lose engine oil pressure and causing engine damage, almost causing an accident. There were no warning or messages prior to the failure it just happened, I was driving and it happened almost causing an accident. The dealership confirmed that this was the problem that belt broke causing motor damage but the letter of the recall had not yet been received and I cannot pay for that repair.

2/20/2024

The contact owns a 2020 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

4/3/2024

The contact owns a 2020 Ford EcoSport. The contact stated while driving at approximately 50 MPH, the vehicle independently steered into the opposite lane of oncoming traffic. The contact stated that extra effort was needed to steer the vehicle back into the lane. The contact stated that the vehicle again steered independently into the opposite lane. The contact was able to regain control and pulled the vehicle over. The contact turned off and restarted the vehicle and was able to continue driving to her destination. The contact stated no warning light was illuminated. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 57,000.

4/22/2024