2013 Volvo XC60 Owner Complaints

WINDSHIELD WATER LEAK AT GASKET, ABOVE THE STEERING WEEL AREA.

6/9/2017

VOLVO XC60 GLASS BONDING DEFECT. WHENEVER WATER FROM RAIN HITS THE WINDSHIELD WATER RUNS DOWN THE INTERIOR OF THE GLASS INSIDE THE VEHICLE. THE BONDING MATERIAL HAS ERODED AND GLASS CAN BE PUSHED OUT OF THE FRAME WITH MY FINGERS. THE LEAK HAS EXPANDED TO ENCOMPASS THE PASSENGER SIDE. THERE IS CONCERN THE ENTIRE WINDSHIELD WILL DISENGAGE FROM THE FRAME. I HAVE CONSULTED A WINDSHIELD REPLACEMENT COMPANY WHO HAVE CONFIRMED THAT THE BONDING MATERIAL IS ERODED. THIS IS A SAFETY CONCERN AS SEVERAL SAFETY FUNCTIONS OPERATE FROM THIS AREA(AUTOMATIC STOPPING, AIRBAG DEPLOYMENT IN A ROLLOVER).

1/18/2019

MOLD, MILDEW AND BACTERIA GROWING IN VENTILATION SYSTEM. INITIALLY NOTICED BECAUSE OF VERY BAD ODOR COMING FROM AIR CONDITIONING SYSTEM. A DESIGN FLAW IN AIR CONDITIONING/VENTILATION SYSTEM. CONDENSER DOES NOT DRAIN PROPERLY, CAUSING IT TO CLOG AND MOLD/MILDEW AND BACTERIA GROW IN THE SYSTEM. VOLVO'S SOLUTION IS JUST CHANGE THE FILTERS MORE FREQUENTLY TO SPRAY CHEMICALS IN THE SYSTEM RATHER THAN FIX THE PROBLEM. A CHECK ONLINE SHOWS THAT THERE ARE MANY OTHER VOLVO OWNERS AFFECTED BY THE PROBLEM. CONDENSER SHOULD BE RECALLED AND FIXED PROPERLY SO THAT IT DRAINS AND THAT MOLD AND BACTERIA DO NOT GROW IN THE SYSTEM. INHALATION OF MOLD AND BACTERIA HAS BEEN SHOWN TO CAUSE LUNG DISEASE, AND AGGRAVATES CONDITIONS LIKE ASTHMA. I HAVE TAKEN MY VEHICLE TO THE DEALER TWICE TO HAVE THE PROBLEM ADDRESSED. THEY REFUSED TO REPLACE THE PART. I ALSO CONTACTED VOLVO CORPORATE OFFICES AND THEY REFUSED TO INTERVENE. THEY ALSO REFUSED TO PROVIDE CONTACT INFORMATION FOR THEIR DISTRICT MANAGER.

5/25/2016

NUMEROUS TRIPS TO THE LOCAL VOLVO DEALER TO FIND THE ISSUE WITH MY VOLVO. LAST EPISODE 10.07.2016 DRIVING ON CITY STREETS. APPROX. SPEED 25-30 MPH. SLOWING DOWN AND MAKING A COMPLETE STOP. ACCELERATING TO MOVE ON BUT CAR IS NOT RESPONDING. RPM STAYS AT 600 EVEN THOUGH GAS PEDAL IS PRESSED DOWN. THIS CAN LAST 3 TO 6 SECONDS. FINALLY CAR STARTS MOVING. I WANTED TO PARK ON A FAIRLY STEEP STREET IN SAN FRANCISCO ON 10.06.2016. ON THE FIRST ATTEMPT I WAS TOO FAR AWAY FROM THE SIDE OF THE STREET. PUT CAR INTO REVERSE AND ATTEMPTED TO BACK UP. AGAIN THE ENGINE STAYED AT 600 RPM AND DID NOT MOVE AT ALL. SINCE I WAS FACING DOWNHILL THE CAR STARTED TO ROLL DOWNWARDS. ONLY MY QUICK REACTION I STEPPED ON THE BRAKE PEDAL AND PRESSED IT AS HARD AS I COULD. CAR CAME TO A STANDSTILL INCHES AWAY FROM ANOTHER CAR THAT WAS PARKED. THIS KIND OF PROBLEM IS BEEN ONGOING.

10/11/2016

12/24/13 APPROX 6:00 PM DRIVING APPROX. 65 MPH ON ROUTE 9 SOUTH IN CT WITH CRUISE CONTROL ON. NO OTHER VEHICLES IN FRONT OR NEARBY AND SUDDENLY THE RED DASHBOARD LIGHT FLASHED AND WARNING SOUNDS AND THE CAR BEGAN TO AUTO BRAKE ABRUPTLY TO 45 MPH. I PULLED OFF THE ROAD TURNED OFF THE CRUISE CONTROL THEN RESUMED MY TRIP UNEVENTFULLY. 12/27/13 APPROX 2:00 PM DRIVING APPROX. 60 MPH ON ROUTE 84 IN CT WITH CRUISE CONTROL ON. NO OTHER VEHICLES IN FRONT OR NEARBY AND SUDDENLY THE RED DASHBOARD LIGHT FLASHED AND WARNING SOUNDS AND THE CAR BEGAN TO AUTO BRAKE HARD DOWN TO 45 MPH. I PULLED OFF THE ROAD TURNED OFF THE CRUISE CONTROL THEN RESUMED MY TRIP UNEVENTFULLY. I CALLED SERVICE MANAGER [XXX]AT GENGRAS VOLVO 860 727 6200 AND ARRANGED TO BRING THE CAR IN FOR ANALYSIS ON 2/17/14. THE SAME BEHAVIOR WAS EXPERIENCED BY [XXX] ON 2/19/14 AS HE RELAYED THE EXPERIENCE TO ME. 5/21/14 [XXX] IS THE NEW GENGRAS VOLVO SERVICE MANAGER, REPLACING [XXX]. HE SAID THEY CHANGED OUT MY FORWARD LOOKING RADAR UNIT WHICH INCLUDES THE CIRCUIT BOARD AND HE ALSO UPDATED THE SOFTWARE (AGAIN). HE STATED THAT IF THE AUTO BRAKE MIS-FUNCTIONS AGAIN THERE IS NO OTHER SERVICE HE CAN PERFORM AND THE CAR SHOULD BE REPLACED. JULY 5, 2015 AFTER 2,000 MILES OF DRIVING WITHOUT NEW INCIDENTS IT APPEARS THAT THE FORWARD LOOKING RADAR UNIT HAD A DEFECT AND CAUSED THE PROBLEM! THIS UNIT NEEDS TO BE RECALLED ON ALL VEHICLES IN WHICH IT IS INSTALLED TO AVOID POTENTIALLY FATAL CRASHES CAUSED BY AUTOBRAKE ENGAGING AND RAPIDLY DECELERATING THE CAR FOR NO REASON. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

7/5/2014

CAR LEAKS WATER INSIDE,COMING FROM BOTH A PILLARS .THIS IS WHERE THE CURTAIN AIRBAGS ARE LOCATED. THIS CLEARLY IS A SAFETY CONCERN. I HAVE DONE A LITTLE RESEARCH AND VOLVO OF NORTH AMERICA WHERE SUED IN NJ FOR THIS TYPE OF WATER INTRUSION PROBLEM. THIS OCCURS WHEN IT RAINS AND CAR JUST SITS WHILE PARKED .

2/16/2018

CAR LEAKS WATER INSIDE,COMING FROM BOTH A PILLARS .THIS IS WHERE THE CURTAIN AIRBAGS ARE LOCATED. THIS CLEARLY IS A SAFETY CONCERN. I HAVE DONE A LITTLE RESEARCH AND VOLVO OF NORTH AMERICA WHERE SUED IN NJ FOR THIS TYPE OF WATER INTRUSION PROBLEM. THIS OCCURS WHEN IT RAINS AND CAR JUST SITS WHILE PARKED .

2/16/2018

SRS WARNING

10/19/2019

I RECENTLY NOTICED WATER INTRUDING INTO THE TOP SIDE OF THE WINDSHIELD. THE ISSUE PERSISTED OVER THE COURSE OF A COUPLE WEEKS UNTIL THE WATER INTRUSION BECAME SEVERE AND RISKED ELECTRICAL DAMAGE TO THE VEHICLE. AFTER CONTACTING SAFELITE AUTO GLASS I WAS INFORMED BY THE TECHNICIAN THAT THIS ISSUE IS COMMON ACROSS VOLVO VEHICLES IN HIS EXPERIENCE. THE TOP OF THE WINDSHIELD WAS NOT SEALED TO THE CAR AND COULD BE EASILY SEPARATED WHEN PRESSURE WAS APPLIED FROM INSIDE OF THE VEHICLE. I HAVE VIDEOS AND PHOTOS OF THIS SAFETY ISSUE WHICH WOULD CAUSE THE WINDSHIELD TO SEPARATE FROM THE CAR IN AN ACCIDENT CAUSING SEVERE DAMAGE TO PEOPLE AND PROPERTY. LOOKING ONLINE I HAVE FOUND MULTIPLE REPORTS OF THIS ISSUE ACROSS VOLVO MODELS AND NO RESOLUTION HAS BEEN OFFERED. I CALLED THE VOLVO CUSTOMER SERVICE LINE TODAY AND WAS TOLD THIS ISSUE COULD NOT BE RESOLVED WITHOUT A RECALL ON THE VEHICLE.

8/10/2017

I OWN A 2013 XC 60. IT HAS ADHESIVE FAILURE ON THE WINDSHIELD. IT HAS BEEN THIS WAY FOR OVER TWO YEARS. EVERYWHERE I TAKE MY VEHICLE THEY TELL ME THAT IT IS PROBABLY THE SUNROOF LEAKING. (SAFELIGHT WHO VOLVO SAID I SHOULD USE) WE HAVE CHECKED ALL THE SUNROOF DRAINS AND IT IS NOT THE SUNROOF IT IS 100% MANUFACTURE DEFECT. I WAS TOLD BY ONE VOLVO DEALERSHIP THAT THEY WOULD CONSIDER PULLING IT OUT FOR ME BUT IF THE WINDSHIELD BROKE I AM RESPONSIBLE FOR A NEW WINDSHIELD. THEY ACKNOWLEDGE THAT THEY HAVE HAD MULTIPLE COMPLAINTS ON THIS YEAR MAKE AND MODEL FOR THE WINDSHIELD LEAKING. I DO BELIEVE THIS SHOULD BE RECALLED. MY CAR GROWS MOLD IN THE FLOORBOARD FROM IT LEAKING SO BADLY. SO I HAVE TO CONTINUE TO SHAMPOO OUT SO THAT MY FAMILY AND CHILDREN DO NOT GET SICK.

12/19/2019

ON JUNE 14TH DRIVING ON TEXAS 195 AT 55MPH WHEN MESSAGE ON "LOW ON COOLANT, PULL OVER". I IMMMEDIATELY PULLED OVER AND SAW A MAN RACE TO FRONT PASSENGER SIDE WITH FIRE EXTINGUISHER. I LOOKED AND THE RAT. FRONT TIRE WAS ENGULFED IN FLAMES. FLAMES WERE ALSO COMING FROM UNDER THE HOOD. THE POLICE AND FIRE DEPARTMENT SHOWED UP AND F.D. INSURED FIRE WAS OUT, AFTER CONTACTING MY INSURANCE I HAD THE CAR TOWED T GEORGETOWN TEXAS, VOLVO. SERVICE PERSON PERSON TOLD ME TO TAKE IT TO A BODY SHOP SINCE THEY DIDN'T HAVE ONE. I SAID CAR WOULDN'T RUN, I WAS THEN ASKED WHAT I HAD HIT AND I STATED NOTHING. MY WIFE AND I FOUND ON THE VOLVO FORUM THAT THIS HAD HAPPENED TO THIS YEAR, MAKE,AND MODEL OF CAR ON MORE THAN ONE OCCASION. ALL MAINTENANCE ON CAR HAD BEEN DONE AHEAD OF SCHEDULE.

7/15/2017

THIS VOLVO EXPERIENCES "SUDDEN UNINTENDED ACCELERATION" PERIODICALLY (ESTIMATED AT 2 TIMES PER YEAR) SINCE IT WAS NEW. THIS UNINTENDED ACCELERATION MANIFESTS ITSELF GENERALLY WHEN COMING TO A STOP (RED LIGHT, DRIVE THRU RESTAURANT, PARKING LOT) BUT HAS HAPPENED ONCE ON THE HIGHWAY. THE ENGINE RACES TO FULL THROTTLE AND LUCKILY, FOR THE INSTANCES SO FAR, WE HAVE BEEN ABLE TO CONTROL THE CAR WITH THE BRAKES. THE ACCELERATION LASTS FOR ROUGHLY 1-2 MINUTES. THE LAST TIME IT HAPPENED (MAY 31, 2020), I SHIFTED THE CAR INTO NEUTRAL, AND THE ENGINE RACED TO 8,000 RPMS, HELD THERE FOR A FEW SECONDS, AND THEN RETURNED TO NORMAL IDLE SPEED. I HAVE TAKEN THE TO THE DEALER (QUANTRELL VOLVO, LEXINGTON KY) TO HAVE THIS ISSUE RESOLVED NUMEROUS TIMES WITH NO SUCCESS. AT ONE POINT, THE VOLVO ENGINEERING TEAM SUGGESTED A NEW TRANSMISSION TO FIX THE ISSUE, WHICH WAS DONE AT VOLVO'S EXPENSE BY THIS DEALER, AND STILL THE PROBLEM CONTINUES. IT WAS IN FOR SERVICE MOST RECENTLY IN SEPTEMBER (9/25-9/29) 2020. THE DEALER COULD NOT FIND A "CODE" TO EXPLAIN THE FAULT AND STATED THEY THEREFORE COULD NOT DO ANYTHING FURTHER TO FIX THE PROBLEM. I THEN ESCALATED THE ISSUE TO VOLVO CUSTOMER CARE AND WAS GIVEN THE SAME RESPONSE. I CAN UPLOAD DOCUMENTS FROM THE DEALER IF NEEDED, ANY HELP YOU CAN PROVIDE IN GETTING THIS CAR FIXED WOULD BE GREATLY APPRECIATED.

10/2/2020

I HAVE A MINOR LEAK ON THE STEERING PUMP ON 2013 VOLVO XC60. WENT TO THE VOLVO-MISSISSAUGA DEALER TODAY (INVOICE# 197408) AND THEY SAID THAT THIS IS NOT QUALIFYING AS A LEAK BUT RATHER IT IS A "VISIBLE SWEAT" FROM THE STEERING PUMP. "VISIBLE SWEAT" MEANS LOOSING STEERING FLUID. STEERING PUMP IS A SAFETY PART OF THE VEHICLE AND I AM CONCERN FOR MY SAFETY. I HAVE PICTURES TO SHOW THE LEAK. I DISAGREE WITH VOLVO-MISSISSAUGA ASSESSMENT AND OPENED A DEFECT COMPLAIN WITH GOV OF CANADA - TRANSPORT CANADA OFFICE. COMPLAIN NUMBER # 2016-0077.

2/2/2016

THE STEERING WHEEL TRIM IS SEPARATING AND LEAVING SHARP METAL EDGES. THE CUTS I HAVE SUSTAINED ARE MINOR IN NATURE BUT THE DISTRACTION OF HAVING BLOOD DRIPPING ON THE STEERING WHEEL WHILE DRIVING IS SIGNIFICANT. THE PHOTO SHOWS A CUT FROM A DAY AGO, BUT THIS HAS HAPPENED MULTIPLE TIMES.

10/2/2017

UNEVEN BRAKE WEAR . THE CAR HAS 60000 MILES AND THE BACK BRAKES HAVE NEEDED TO BE CHANGED TWICE AS WELL AS ROTORS. THE FRONT PAD HAVE YET TO BE REPLACED.

6/18/2019

I WAS PULLING INTO A PARKING SPACE AND PUT MY FOOT DOWN TO APPLY THE BRAKES THE CAR WOULD NOT SLOW DOWN, THE HARDER I PUSHED ONTHE BRAKE THE MORE THE CAR WOULD GO FORDWARD. HAVE YOU HAD ANYTHING LIKE THIS BEFORE.

6/23/2019

The vehicle came to a stop in two different occasions (6 months apart) without a reason. The first occasion was while exiting the freeway, there was no car or object in front of me. The second time I had gone over a manhole and the car screeched to a halt on a city street. I was very fortunate that in both occasions I did not have a car behind me or this malfunction would have caused a collision. After the car stopped I was able to continue driving. After the car stopped the message "Auto braking by City Safety" appeared on the dashboard.

6/21/2024

The car came to a complete stop without a reason. This happened while exiting the freeway and no cars or objects were in front of me. I was very lucky that I did not have a car behind me or this would have caused a collision. After the car stopped the message "auto braking by City Safety" appeared on my dashboard

6/21/2024

12/24/13 APPROX 6:00 PM DRIVING APPROX. 65 MPH ON ROUTE 9 SOUTH IN CT WITH CRUISE CONTROL ON. NO OTHER VEHICLES IN FRONT OR NEARBY AND SUDDENLY THE RED DASHBOARD LIGHT FLASHED AND WARNING SOUNDS AND THE CAR BEGAN TO AUTO BRAKE ABRUPTLY TO 45 MPH. I PULLED OFF THE ROAD TURNED OFF THE CRUISE CONTROL THEN RESUMED MY TRIP UNEVENTFULLY. 12/27/13 APPROX 2:00 PM DRIVING APPROX. 60 MPH ON ROUTE 84 IN CT WITH CRUISE CONTROL ON. NO OTHER VEHICLES IN FRONT OR NEARBY AND SUDDENLY THE RED DASHBOARD LIGHT FLASHED AND WARNING SOUNDS AND THE CAR BEGAN TO AUTO BRAKE HARD DOWN TO 45 MPH. I PULLED OFF THE ROAD TURNED OFF THE CRUISE CONTROL THEN RESUMED MY TRIP UNEVENTFULLY. I CALLED SERVICE MANAGER [XXX]AT GENGRAS VOLVO 860 727 6200 AND ARRANGED TO BRING THE CAR IN FOR ANALYSIS ON 2/17/14. THE SAME BEHAVIOR WAS EXPERIENCED BY [XXX] ON 2/19/14 AS HE RELAYED THE EXPERIENCE TO ME. 5/21/14 [XXX] IS THE NEW GENGRAS VOLVO SERVICE MANAGER, REPLACING [XXX]. HE SAID THEY CHANGED OUT MY FORWARD LOOKING RADAR UNIT WHICH INCLUDES THE CIRCUIT BOARD AND HE ALSO UPDATED THE SOFTWARE (AGAIN). HE STATED THAT IF THE AUTO BRAKE MIS-FUNCTIONS AGAIN THERE IS NO OTHER SERVICE HE CAN PERFORM AND THE CAR SHOULD BE REPLACED. JULY 5, 2015 AFTER 2,000 MILES OF DRIVING WITHOUT NEW INCIDENTS IT APPEARS THAT THE FORWARD LOOKING RADAR UNIT HAD A DEFECT AND CAUSED THE PROBLEM! THIS UNIT NEEDS TO BE RECALLED ON ALL VEHICLES IN WHICH IT IS INSTALLED TO AVOID POTENTIALLY FATAL CRASHES CAUSED BY AUTOBRAKE ENGAGING AND RAPIDLY DECELERATING THE CAR FOR NO REASON. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

7/5/2014

HEADLIGHT MOUNTS LOCATED ON REAR OF ASSEMBLY FRACTURE/BREAK OVER TIME. THIS LEAVES THE HEADLIGHT ASSEMBLY DISCONNECTED FROM THE VEHICLE CHASSIS AND CERTAIN CIRCUMSTANCES COULD LEAD THE HEADLIGHT TO FALL FROM THE VEHICLE.

2/3/2017

CAR LEAKS WATER INSIDE,COMING FROM BOTH A PILLARS .THIS IS WHERE THE CURTAIN AIRBAGS ARE LOCATED. THIS CLEARLY IS A SAFETY CONCERN. I HAVE DONE A LITTLE RESEARCH AND VOLVO OF NORTH AMERICA WHERE SUED IN NJ FOR THIS TYPE OF WATER INTRUSION PROBLEM. THIS OCCURS WHEN IT RAINS AND CAR JUST SITS WHILE PARKED .

2/16/2018

TL* THE CONTACT OWNS A 2013 VOLVO XC60. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING WHILE DEPRESSING THE ACCELERATOR PEDAL. THE CONTACT INITIALLY CALLED THE MANUFACTURER AND SPOKE WITH THREE DIFFERENT REPRESENTATIVES WHO REFUSED TO INFORM HIM IF THE VIN WAS UNDER RECALL. THE CONTACT THEN SPOKE TO AUTOBARN VOLVO CARS OAK PARK (1140 GARFIELD ST, OAK PARK, IL 60304) WHERE HE WAS GIVEN AN ESTIMATE FOR A DIAGNOSTIC FEE. THE CONTACT DECLINED THE DIAGNOSTIC TEST. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 40,000.*DT*DT*JB*JB

12/29/2020

EVERY TIME IT RAINS WATER RUNS IN FROM SUNROOF AND OR FRONT WINDSHIELD GOT TO WHERE YOU CAN'T EVEN DRIVE IN THE RAIN ANYMORE IT IS SO BAD. STILL HAS THE FACTORY WINDSHIELD IN THE CAR.

4/13/2021

The gas gauge no longer reports accurate level of fuel in tank. Thousands of people have reported this issue, yet no recall exists, though this endangers lives - especially in the deserts of the southwest. Volvo service quotes are aways ripoffs, quoting $3000 minimum.

10/23/2021

The windshield leaks when I am driving from the passenger side and the driver side. Last rain a lot of water got into the car which makes it very dangerous to drive and obviously to break since it gets slippery. I live in the mountains, and we get a lot of rain and now I have to pay out of pocket to get it diagnosed when even the service advisor said that that particular year and models leaks a lot.

12/1/2023

The accelerator got stuck and and the engine went full power. It would not shut off and the overheated.

11/30/2025