2023 Volvo XC40 Owner Complaints

The contact owns a 2023 Volvo XC40. The contact stated that the SOS button had malfunctioned and had caused several different calls to be made except for a call for roadside assistance. The contact contacted the dealer; however, the vehicle was not diagnosed. The vehicle had not been repaired. The manufacturer was made aware of the failure. The approximate failure mileage 700.

3/15/2023

The contact owns a 2023 Volvo XC40. The contact stated that while her son was driving at various highway speeds, the brakes inadvertently activated, causing the vehicle to abruptly stop even though were no other vehicles or objects nearby. Additionally, the vehicle occasionally stalled and hesitated while accelerating. The contact also stated that the display screen occasionally became inoperable, and messages and safety warnings were not available to the driver. The vehicle was taken to the local dealer who was unable to duplicate the failure. The dealer had replaced unknown sensors, but the failure persisted. The manufacturer was not notified of the failure. The failure mileage was 13,000.

9/29/2023

We were notified by email of a computer update to our 2023 Volvo XC40 Recharge (it stated it would automatically download the update then ask us to initiate the installation). The next day I was charging the car. The car is programmed for 1 pedal driving. After disconnecting the charger, I got into the car, put my foot on the brake, and placed the car in reverse. When I released the brake, the car just took off in reverse. It should not have moved until I pushed on the accelerator. I am theorizing that the car was either in the middle of the download or had just finished the download portion of the update. This problem persisted after I put the car in Drive. I drove about 2 blocks and parked the car. After about 10 minutes I put the car in Drive and it returned to the 1 pedal drive mode and the computer screen in the car showed a message that the update was ready for installation. The car drove normally for 20 miles to our house. We installed the update after arriving home. My wife drove the car the following morning. She experienced no further problems.

12/7/2022

Describe what happened: While driving my Volvo, both right side tires simultaneously went flat on a deserted road. I was traveling with my [XXX] daughter, who was hungry and tired, making this situation extremely stressful and unsafe. There were no warning lamps or messages indicating any issues before the tires went flat. What component or system failed or malfunctioned, and is it available for inspection upon request? The GPS navigation system failed to report an accurate location to Volvo Roadside Assistance. Yes, the GPS navigation system is available for inspection upon request. How was your safety or the safety of others put at risk? Our safety was severely compromised as we were stranded on a deserted road with no immediate help available. I had to drive on flat tires to find assistance, which could have caused further damage to the vehicle and posed additional risks. Has the problem been reproduced or confirmed by a dealer or independent service center? No, the problem has not been reproduced or confirmed by a dealer or independent service center. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives, or others? No, the vehicle or component has not been inspected by the manufacturer, police, insurance representatives, or others. Were there any warning lamps, messages, or other symptoms of the problem prior to the failure, and when did they first appear? There were no warning lamps, messages, or any other symptoms prior to the tires going flat. Additional Details: Despite being a loyal Volvo customer, the GPS location provided to the tow truck by Volvo Roadside Assistance was incorrect, and the tow truck never arrived. I had to drive on flat tires to find help and eventually flagged down a park service vehicle to get an address for roadside assistance. Additionally, Volvo wouldn't provide an Uber due to my phone's unstable connection, leaving us feeling completely abandoned. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5

6/18/2024

The rear reverse camera cuts out with a message on the driver display stating "Camera temporarily not available". This occurs ~10% of the time. Other times the camera will flicker in and out but both scenarios result in partial or complete obstruction of view while reversing. With my children and other little children on the street, this is very concerning. The issue was reported to the dealership and software was updated but the problem remains.

1/31/2025

When pulling out my pack up camera often say camera is not available at this time.

2/9/2025

I am reporting 2 incidents for my 2023 Volvo XC40, both involving failure of brakes to engage. The 1st incident occurred on 26 August 2023. The 2nd incident occurred on 20 September 2023. A full description of both incidents, including 2 photos of the incident scenes, is attached. The 1st incident involved a collision with a Jersey wall and crosswalk signal activation sign. Repair of the resulting damage required replacement of a mirror assembly that was destroyed and some repainting.

10/18/2023

The brake systems have failed repeatedly on this vehicle, and have been replaced by the manufacturer TWICE since purchase (April 28, 2023). Brakes continued to intermittently freeze or lose pressure, so car is now classified as a lemon. However, as we have waited months and months for the lemon process to complete, the transmission began to fail. At first, we had incidents of the car seeming to shift into neutral at speeds of 30-40 MPH. The car’s engine would rev and yet forward propulsion would become coasting. Lifting foot from accelerator and then putting fit back on would often result in the gear “catching” and the car lurching into gear. On the most recent and dangerous iteration of this transmission/engine problem, when merging onto an interstate and traveling at 45-50 MPH, I attempted to accelerate and merge. Instead of downshifting to give me more power, the car entered a seeming neutral state (both hands were on the wheel, indicator said I was in Drive). The engine revved and yet the car coasted. I was unable to pull into traffic, on a very short entrance ramp. I pulled my foot off the gas pedal, waited a second, and put it back on. The car lurched into gear and shot forward. We have stopped driving this car while awaiting Volvo’s agreed upon lemon law payout. The dealer will not fix the car, given its lemon status. The buyback company, Sedgwick, takes no responsibility. We are fortunate enough to be able to afford a new car while awaiting the payout. But had we not been able to, these transmission/engine problems could easily have caused an accident. No other person should be in danger from these cars. The service manager at our dealer states that they are in the process of multiple XC40 buybacks right now. Volvo has a problem and it is simply buying back these cars. I will list the date of the most aggregators transmission issue (the merging problem) below.

12/28/2023

The contact owns a 2023 Volvo XC40. The contact stated while driving 65 MPH, the Forward Collision Avoidance system activated without a vehicle nearby and the vehicle experienced phantom braking. The contact stated that the failure occurred on three separate occasions. The vehicle was taken to the dealer, but the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 6,500. The contact stated that they have experienced multiple failures with their vehicle.

6/14/2023

The contact owns a 2023 Volvo XC40. The contact stated that while her son was driving at various highway speeds, the brakes inadvertently activated, causing the vehicle to abruptly stop even though were no other vehicles or objects nearby. Additionally, the vehicle occasionally stalled and hesitated while accelerating. The contact also stated that the display screen occasionally became inoperable, and messages and safety warnings were not available to the driver. The vehicle was taken to the local dealer who was unable to duplicate the failure. The dealer had replaced unknown sensors, but the failure persisted. The manufacturer was not notified of the failure. The failure mileage was 13,000.

9/29/2023

The vehicle was driving on cruise control at 55 mph approaching an intersection with a stop sign. Attempted to brake to cancel the cruise control, but vehicle sped and continued gathering speed so that the driver lost any control over the speed. Frantic application of the brake did not have any effect on the speed. The vehicle shot across a south bound highway, collided with traffic signs in the center, crossed northbound lanes, jumped a four foot berm and landed in bushes where the air bags deployed.

11/15/2023

On Wednesday, July 16, 2025 I was sitting at a stop light, using the Auto Hold system. A few minutes later, my car took off and accelerated on its own and hit the rear of a truck. I hit the truck so hard as he was sitting at the light as well, it pushed his vehicle into the vehicle in front of him. I was unable to stop my Volvo, it was like it took full control over.

7/17/2025

The rear-view camera is cutting out and/or unresponsive. Upon going into reverse, the rear-view camera occasionally cuts out to a blank screen. In a recent instance, I was in reverse and was completely unable to get the rear-view camera to operate whatsoever. When this occurs it is impossible to see what is directly behind the car. My car was just at the dealership yesterday (8/18/25) and has the current version of the software (v 3.7) installed.

8/19/2025

backup camera continues to say 'camera temporarily unavailable' even after software update from recall. latest software update has made the problem worse. Camera frequently fails when backing up

9/22/2025

The contact owns a 2023 Volvo XC40. The contact stated that while driving at approximately 30 MPH, he was approaching a stop light when he depressed the brake pedal to stop the vehicle however, the brake pedal stiffened. The contact stated that he had to apply pressure to the brake pedal when suddenly the ESC warning light, the brake warning light, the ABS warning light, and another unknown warning lights were illuminated. The contact then stated that in the same instance, the RPMs inadvertently increased to 1000 without acceleration when he desperately pumped the brake pedal multiple times to stop the vehicle however, the vehicle started to decrease in speed as the vehicle proceeded through the red stop light. As a result, another vehicle crashed into the front end of the contact’s vehicle. The air bags did not deploy. The driver of the other vehicle sustained an unknown injury that required medical attention. A police report was filed. The contact’s vehicle was towed to the dealer however, the contact was uninformed of the diagnoses. The vehicle was repaired. The contact notified the manufacturer by email of the failure and to inquire of a recall and the contact was informed that the VIN was included in the manufacture recall R10217. The contact stated that he then received a recall notification of the NHTSA Campaign Number: 23V012000 (Service Brakes, Hydraulic). The failure mileage was approximately 300.

5/5/2023

The contact owns a 2023 Volvo XC40. The contact stated that while her son was driving at various highway speeds, the brakes inadvertently activated, causing the vehicle to abruptly stop even though were no other vehicles or objects nearby. Additionally, the vehicle occasionally stalled and hesitated while accelerating. The contact also stated that the display screen occasionally became inoperable, and messages and safety warnings were not available to the driver. The vehicle was taken to the local dealer who was unable to duplicate the failure. The dealer had replaced unknown sensors, but the failure persisted. The manufacturer was not notified of the failure. The failure mileage was 13,000.

9/29/2023

The contact owns a 2023 Volvo XC40 equipped with Pirelli Tires, Tire Line: Scorpion Zero, Tire Size: 235/45/R20, DOT Number: 1XB1H884J5022. The contact stated that the message "Low Air Pressure" was displayed. Upon inspection, it was discovered that the rear passenger’s side tire was flat. The vehicle was towed to the local dealer who replaced the tire. Later, while driving approximately 35 MPH, the front driver’s side tire had a blowout. The cause for the failures was not yet determined. The manufacturer was not notified of the failure. The failure mileage was 3,588.

10/30/2023

The vehicle was driving on cruise control at 55 mph approaching an intersection with a stop sign. Attempted to brake to cancel the cruise control, but vehicle sped and continued gathering speed so that the driver lost any control over the speed. Frantic application of the brake did not have any effect on the speed. The vehicle shot across a south bound highway, collided with traffic signs in the center, crossed northbound lanes, jumped a four foot berm and landed in bushes where the air bags deployed.

11/15/2023

The vehicle was driving on cruise control at 55 mph approaching an intersection with a stop sign. Attempted to brake to cancel the cruise control, but vehicle sped and continued gathering speed so that the driver lost any control over the speed. Frantic application of the brake did not have any effect on the speed. The vehicle shot across a south bound highway, collided with traffic signs in the center, crossed northbound lanes, jumped a four foot berm and landed in bushes where the air bags deployed.

11/15/2023

The brake systems have failed repeatedly on this vehicle, and have been replaced by the manufacturer TWICE since purchase (April 28, 2023). Brakes continued to intermittently freeze or lose pressure, so car is now classified as a lemon. However, as we have waited months and months for the lemon process to complete, the transmission began to fail. At first, we had incidents of the car seeming to shift into neutral at speeds of 30-40 MPH. The car’s engine would rev and yet forward propulsion would become coasting. Lifting foot from accelerator and then putting fit back on would often result in the gear “catching” and the car lurching into gear. On the most recent and dangerous iteration of this transmission/engine problem, when merging onto an interstate and traveling at 45-50 MPH, I attempted to accelerate and merge. Instead of downshifting to give me more power, the car entered a seeming neutral state (both hands were on the wheel, indicator said I was in Drive). The engine revved and yet the car coasted. I was unable to pull into traffic, on a very short entrance ramp. I pulled my foot off the gas pedal, waited a second, and put it back on. The car lurched into gear and shot forward. We have stopped driving this car while awaiting Volvo’s agreed upon lemon law payout. The dealer will not fix the car, given its lemon status. The buyback company, Sedgwick, takes no responsibility. We are fortunate enough to be able to afford a new car while awaiting the payout. But had we not been able to, these transmission/engine problems could easily have caused an accident. No other person should be in danger from these cars. The service manager at our dealer states that they are in the process of multiple XC40 buybacks right now. Volvo has a problem and it is simply buying back these cars. I will list the date of the most aggregators transmission issue (the merging problem) below.

12/28/2023

When traveling down a local and city road traveling at approximately 55 miles per hour, the vehicle is fine. But once I get on the highway and travel over 60 miles per hour (approximately driving 70 miles per hour), there is a horrible click that engages in the steering wheel at around approximately 1° angle (it turns right barely when it happens). While driving in either lane, the steering wheel will automatically lock up and turn the vehicle right. When this happens, you can legitimately feel it in the steering wheel. You have to then turn the steering wheel left in order for the click to disengage, but it causes the vehicle to turn sharply. This is unsafe and I feel it will eventually result in a car accident if this is not fixed. It is my daily drive and I feel 100% unsafe!

1/3/2024

Rear passenger door was unable to be opened via door handles either from inside or outside the vehicle which could trap occupant inside

4/23/2024

Rear passenger door was unable to be opened via door handles either from inside or outside the vehicle which could trap occupant inside

4/23/2024

On January 22, 2025 on a clear sunny day (no wind) I was putting groceries in the trunk of my car when the trunk lid came down on my head injuring me. I was leaning from the right side of my car across to the left side. My key was in my pocketbook on my right shoulder. Volvos should be "Mom" cars where one should be safe putting groceries in the trunk. Instead of popping back open with an obstruction, it continued to press down on my head before eventually popping back open. According to Volvo chat boards, this has happened to others. On January 6 my car had its two year servicing at the dealer on my leased vehicle. The service department's initial reaction to this malfunction was to BLAME me for having the key too close to the kick open sensor and to leave the key in the car while loading groceries. When I got the car, we were told (and it was demonstrated) that the kick open feature was on the left side of the trunk under the first "V". It appears that there was an update which electrified the entire back of the trunk without any notice to owners. Even so, I am 5 feet 2 1/2 inches tall. It is extremely difficult for me to kick open the trunk which is why I always open it from the button in the middle of the trunk and close it with the controls on the top right of the trunk lid. Buried in the owners' manual is a statement that you can kick the trunk lid closed, but no one ever told us that or that it can be kicked closed from the right side of the trunk. I did not kick the sensor to activate the trunk lid closing on my head. Only after a second call to the service department did the dealer agree to "look at" my car, but that they were booked up for the next two weeks.

1/28/2025

On January 22, 2025 on a clear sunny day (no wind) I was putting groceries in the trunk of my car when the trunk lid came down on my head injuring me. I was leaning from the right side of my car across to the left side. My key was in my pocketbook on my right shoulder. Volvos should be "Mom" cars where one should be safe putting groceries in the trunk. Instead of popping back open with an obstruction, it continued to press down on my head before eventually popping back open. According to Volvo chat boards, this has happened to others. On January 6 my car had its two year servicing at the dealer on my leased vehicle. The service department's initial reaction to this malfunction was to BLAME me for having the key too close to the kick open sensor and to leave the key in the car while loading groceries. When I got the car, we were told (and it was demonstrated) that the kick open feature was on the left side of the trunk under the first "V". It appears that there was an update which electrified the entire back of the trunk without any notice to owners. Even so, I am 5 feet 2 1/2 inches tall. It is extremely difficult for me to kick open the trunk which is why I always open it from the button in the middle of the trunk and close it with the controls on the top right of the trunk lid. Buried in the owners' manual is a statement that you can kick the trunk lid closed, but no one ever told us that or that it can be kicked closed from the right side of the trunk. I did not kick the sensor to activate the trunk lid closing on my head. Only after a second call to the service department did the dealer agree to "look at" my car, but that they were booked up for the next two weeks.

1/28/2025

Going back to last year I have reported to Volvo the software issues on the car. 1. Automatic Emergency Braking - Currently the car is ABRUPTLY breaking in the streets thinking it there is a car in front. It's so incredibly dangerous. I've reported it and they have not done anything about it. (Most Recent Issues) 2. Electrical - the screen every other week needs to be reset - it reads that it does not have air-conditioning, airbags, and all the buttons are grayed out. I've reported this since December of last year. NOTHING HAS BEEN DONE 3.

5/29/2025

The contact owns a 2023 Volvo XC40. The contact stated while the vehicle was parked, the front passenger's side seat belt failed to latch as intended. The contact's mother was attempting to latch the front passenger's side seat belt when the failure occurred. The contact stated that the failure could have occurred while the vehicle was being driven. The vehicle was taken to the dealer to be diagnosed; however, the contact was not provided the result of the diagnostic test. In addition, the contact stated that four months prior to the failure, the front driver's side seat belt failed to latch as intended. The vehicle was taken to the dealer where it was determined that there was a failure with the latching mechanism. The vehicle was repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 5,000.

11/4/2025