2022 Toyota RAV4 Owner Complaints

On May 13th, 2022, I was in my garage and inside the vehicle in park mode, when I suddenly heard a little crack sound coming from the windshield. It was very faint, but I heard it. Then I noticed that it was the windshield and it had a little crack. On May 19, 2022, I took the vehicle to Elmhurst Toyota and they stated that a rock hit the windshield which is false. I am certain that it is a defect of the windshield in the RAV4's. I am not the first person to complain about the faulty windshield on these models and truly believe that is very unsafe. This needs to be investigated as it can cause a car accident if cracked on the highway.

5/19/2022

Unknown crack on exterior front windshield. The vehicle is nearly a month old and always garage kept. Discovered hairline crack from drivers pillar to halfway towards the rear view mirror.

6/13/2022

The total fuel dispensed is less than expected when the fuel nozzle automatically clicks off when refueling. [Some customer reports] have also noted the Distance to Empty" shown on the multi-information display is less than expected."

3/18/2022

The contact owns a 2022 Toyota Rav4. The contact stated while driving 50 MPH, the vehicle ESC became inoperable. The vehicle was taken to the dealer and the ESC system was updated but the failure reoccurred. The manufacturer was contacted, and a case was filed. The failure mileage was 4,800.

11/7/2022

The total fuel dispensed is less than expected when the fuel nozzle automatically clicks off when refueling. [Some customer reports] have also noted the Distance to Empty" shown on the multi-information display is less than expected."

3/18/2022

Car automatically accelerated when slowing down to make a turn into parking lot. Car is only a few months old and has 7,000 miles on it.

10/27/2022

When driving at a speed of ~60 miles, I felt a brief loss of power steering. The wheels were heavy and difficult to control. It lasted for less than a second but occurred twice already in one week.

10/17/2022

Apple Carplay does not function posing a safety hazard. When connected, volume is unable to be lowered via the steering wheel controls or the factory installed radio. As such, in an emergency, the volume could not be lowered to communicate with emergency services. Dealer updated radio to latest software on 8/3/23 but the problem persists. Apple is aware of the problem but does not have a solution.

8/5/2023

The vehicle without warning will lose all power; "Accelerator System Malfunction Output Power Reduced Visit Your Dealer" and "Pre-Collision System Malfunction - Visit Your Dealer" are the warning messages that appeared when power was lost. The "Check Engine" light also illuminated as well as a collision error light appeared. The vehicle has done this twice; the first time, the dealer found a recall which was a software update. However, today the vehicle became unresponsive again with the same error messages as before; we were lucky no vehicle hit us from behind since we were turning towards the frontage road to access the highway. The first time this happened, my wife was entering the ramp towards the expressway when the vehicle lost all power and she had to go to the side. Vehicle is now again at the dealer but cannot be serviced until Monday; however, this needs to be addressed since it is a safety concern. On the Toyota App, it is also listing a hybrid malfunction; this needs immediate attention to avoid a catastrophic event. Losing all power with no warning is completely unacceptable.

8/6/2022

Car automatically accelerated when slowing down to make a turn into parking lot. Car is only a few months old and has 7,000 miles on it.

10/27/2022

SUV came on highway on exit ramp car ahead of me sharply moved right to center lane. Seeing the headlights I did too but he sideswiped me on driers side tearing the back tire and everything else out. He flipped me around so now I was facing on coming traffic in center lane. My face hit steering wheel. No airbag deployed

8/12/2022

I received from Toyota USA via USPS a "Safety Recall Notice" regarding my 2022 RAV4 hybrid. Both the local Toyota dealer and Toyota Brand Engagement Center told me there is no recall on my vehicle. Neither could tell me why I received the notice. When I searched NHTSA recall database for Recall No. 22V-519, it referenced an unrelated fire hazard on HYundai and Kia vehicles. Attached please find the notice and its envelope. Sending false information like this creates a perception of danger, when perhaps none exists

9/16/2022

My wife and I were traveling down SR74 mp 12 and rear ended a cow at 68 miles per hour. The airbags did not deploy from impact and yet the car is totaled the hood started through the safety glass of the windshield.

3/14/2024

Rear passenger door does not drain and holds water. This is a potential mold issue which is a health problem. This will also cause the doors to rust.

8/4/2024

The fuel tank warning light comes on when the car still has over 4 gallons of gas remaining in the tank. This was confirmed by checking fuel fill versus tank size and also running vehicle well past warning light. The warning light appears to mislead drivers and is inaccurate. The actual range of the vehicle is misleading with this warning light.

3/18/2022

The total fuel dispensed is less than expected when the fuel nozzle automatically clicks off when refueling. [Some customer reports] have also noted the Distance to Empty" shown on the multi-information display is less than expected."

3/18/2022

My Rav4 Hybrid 2022 exhibits a front brake squeal/squeak noise when braking at low speeds. Went to Toyota delearship and they examined but said there's no issue! Called toyota customer service and expected a call back but didn't hear back.(Toyota Case Number 220726001124)

7/27/2022

The breaks are failing to stop the car if there is any rough spots in the road it feels like I'm pushing against air, the car jerks, the break pedal will shudder. The car has no warning lights or sounds when this occurs. The car has recently been inspected by the dealership for this issue, they performed a resurfacing to the breaks. The issue has continued and 2 days after repair, car slipped into intersection due to a failure of the breaks and after going over a rough spot in the road.

8/26/2022

My Car is Toyota Rav4 2022 Premium XLE have many safety issues -During i'm braking/ hold button and standing on the light i find the car is jumping to front many times it was going to hit some one of pedsterian and car front of me ( it was like Starting engine with jumping) - Precollsion system doesn't work while doen't see any cars front of me while going to traffice light - Keep lane assistant doesn't work and is not senstive sometime my car get out of the lane during i'm driving - Sometime keep lane assistant system pushing the car to get out of the lane

6/24/2022

Problemas con el sistema de precolosion falla del sensor el carro es inseguro e tenido 2 incidentes donde el sistema no responde ni se activa antes del impacto problemas con el motor, estabilidad del carro, conteo de velocidad, frenos, llantas, cruze de carriles, puntos ciegos

12/20/2023

The vehicle without warning will lose all power; "Accelerator System Malfunction Output Power Reduced Visit Your Dealer" and "Pre-Collision System Malfunction - Visit Your Dealer" are the warning messages that appeared when power was lost. The "Check Engine" light also illuminated as well as a collision error light appeared. The vehicle has done this twice; the first time, the dealer found a recall which was a software update. However, today the vehicle became unresponsive again with the same error messages as before; we were lucky no vehicle hit us from behind since we were turning towards the frontage road to access the highway. The first time this happened, my wife was entering the ramp towards the expressway when the vehicle lost all power and she had to go to the side. Vehicle is now again at the dealer but cannot be serviced until Monday; however, this needs to be addressed since it is a safety concern. On the Toyota App, it is also listing a hybrid malfunction; this needs immediate attention to avoid a catastrophic event. Losing all power with no warning is completely unacceptable.

8/6/2022

I was at stop position. i pressed the hold button and then took my foot off the break. when traffic started moving i pressed the hold button again with my foot still on floor the car started jumping and pressing the the two other car on my front. the two other cars got totaled.

6/20/2023

I purchased a brand new Toyota RAV4 Hybrid XLE on June 30, 2022 and on my first drive, 6.4 miles from the dealership to my home, the the windshield developed a crack on the driver's side. It is available for inspection. Both Toyota and Safelite say they are having supply issues with the windshield and of Sep 1, 2022 neither Toyota or Safelite have replacement windshields for the RAV4. The crack affects vision for both the driver and those outside the vehicle. The problem has been confirmed by the local dealer, Toyota of Cedar Park, TX and by Safelite of Austin Texas. The windshield has NOT been inspected by the manufacturer, police, Amica insurance, or any others There were no warning lamps, messages or symptoms of the problem prior to failure or after the failure.

9/1/2022

Hello, I am concerned about the windshield on our new RAV4. It was chipped and the glass cracked from the passenger side to the drivers side of the car. Currently we are waiting for the car insurance to cover the cost of repair for the windshield. For safety reasons you cannot clearly see out of the windshield because of the crack. The problem cannot be reproduced currently. the problem was inspected by the insurance company representative (SAFELITE) and we are still waiting on the new windshield because apparently there is a hug backlog there was no warning when the windshield cracked. But seemingly cracked when there was no warning, my wife was driving the car when something hit the corner of the windshield (some rock or road debris)

9/14/2022

Above checked ADAS items don't work appropriately, and can't relay on them all the time. Apart from that My Toyota RAV4 Moon Roof shield couldn't be able to withstand for the wind during raining when the vehicle speed was at 75mph on Highway i-35 in Oklahoma. The glass busted completely, and those glass particles causes inconvenience to the other vehicle on the high way. I reported this incident to the car dealer but they were so rude to me, and said that car is not designed for the 75mph speed. Ended up convincing myself that RAV4 is not safe to drive anymore.

11/28/2022

While driving in stop-and-go traffic on a major highway, the auto braking system engaged and the brake would not release. The car came to an abrupt halt and the brake would not release, the gas pedal would not depress. I had to turn the car off, place the car in park and restart the car, the car then continued driving. There was a message on the dash about EPB.

10/14/2024

When back seat is empty, car incorrectly detects a person sitting in the back and dings until the back seat belts are buckled. Toyota dealer claims this is a known issue and claims it will not affect which airbags deploy in a collision. This is a daily issue, and can only be addressed by buckling the back seat belts at this time, according to the Toyota service department.

2/22/2025

The contact owns a 2022 Toyota RAV4. The contact stated that a sudden complete stop on a major roadway was necessary due to a turtle crossing, and the vehicle in front was at a complete stop and exited the vehicle in their attempt to remove the turtle from the road. A third vehicle coming from the rear failed to slow down and was driving at 55 MPH, crashed into the rear of the contact. As a result, the contact rear-ended the vehicle in front, which was unoccupied due to the attempt of a turtle removal from the roadway. The contact mentioned that the seat belt did not retract during the impact. No air bags deployed.  The vehicle was towed to Copart Collision Center pending the insurance company's inspection of the vehicle. The contact stated that she sustained a head injury that required medical attention. A police report was filed, but the police report number was unknown. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 36,098.

4/16/2025

My Car is Toyota Rav4 2022 Premium XLE have many safety issues -During i'm braking/ hold button and standing on the light i find the car is jumping to front many times it was going to hit some one of pedsterian and car front of me ( it was like Starting engine with jumping) - Precollsion system doesn't work while doen't see any cars front of me while going to traffice light - Keep lane assistant doesn't work and is not senstive sometime my car get out of the lane during i'm driving - Sometime keep lane assistant system pushing the car to get out of the lane

6/24/2022

Above checked ADAS items don't work appropriately, and can't relay on them all the time. Apart from that My Toyota RAV4 Moon Roof shield couldn't be able to withstand for the wind during raining when the vehicle speed was at 75mph on Highway i-35 in Oklahoma. The glass busted completely, and those glass particles causes inconvenience to the other vehicle on the high way. I reported this incident to the car dealer but they were so rude to me, and said that car is not designed for the 75mph speed. Ended up convincing myself that RAV4 is not safe to drive anymore.

11/28/2022

My Car is Toyota Rav4 2022 Premium XLE have many safety issues -During i'm braking/ hold button and standing on the light i find the car is jumping to front many times it was going to hit some one of pedsterian and car front of me ( it was like Starting engine with jumping) - Precollsion system doesn't work while doen't see any cars front of me while going to traffice light - Keep lane assistant doesn't work and is not senstive sometime my car get out of the lane during i'm driving - Sometime keep lane assistant system pushing the car to get out of the lane

6/24/2022

Above checked ADAS items don't work appropriately, and can't relay on them all the time. Apart from that My Toyota RAV4 Moon Roof shield couldn't be able to withstand for the wind during raining when the vehicle speed was at 75mph on Highway i-35 in Oklahoma. The glass busted completely, and those glass particles causes inconvenience to the other vehicle on the high way. I reported this incident to the car dealer but they were so rude to me, and said that car is not designed for the 75mph speed. Ended up convincing myself that RAV4 is not safe to drive anymore.

11/28/2022

Tire size:225 65/17 While driving the side of a brand new tire blew out. We had three passengers in the vehicle that could have been in danger if we were going at a greater speed. We took the new tire in and was told by the auto shop that it could not be repaired. We had to purchase a new one and I have the invoice. I try to resolve this with Firestone but according to them, the tire was not under warranty. The new tire only had 5000 miles and it is a tread of at least 60,000 miles.

3/31/2023

Tire split on the inside of the tire wall about 1 inch up. Less than 20,000 miles on them. I do not believe this is normal. 225/60 R18. Car was serviced by Toyota on March 21st.

4/16/2024

The contact owns a 2022 Toyota Rav4. The contact stated that while rolling down the driver's side window, the window made an abnormal sound. The vehicle was taken to the dealer, who removed plastic debris and tightened unknown screws on the driver's side door; however, the failure recurred. The manufacturer was made aware of the failure and informed the contact that it was a common failure in similar vehicles. The failure mileage was approximately 600.

6/15/2023

The contact owns a 2022 Toyota Rav4. The contact stated that after heavy rainfall, there was a swishing sound coming from the passenger’s side rear door. The contact stated that when the vehicle was parked, the contact inspected the vehicle, and became aware of water build-up in the passenger’s side rear door. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was 9,512.

5/8/2025

6/15/23 @ 18,357 miles the car was given a four wheel alignment at the owners request. Due to loud tire noise and visible cupping on the right rear inside edge, it was clear the car's wheel alignment was wrong. The dealer's before and after alignment is attached. When presented the before and after, I noted RR Camber was.-2.3 vs. a range of -1.8 to -0.3 degrees. The reading was unchanged from initial. They advised me the camber cannot be adjusted and is "fixed" from the Factory. The form also read "One of more value are not within specification. Tire wear, handling and safety problems may result". But they had no remedy. I escalated at Dealer. Dealer opened a ticket with Toyota to look at my car. Of note, my Sister in Law's RAV4car has the same issue. I felt I had made my concerns clear and Toyota Corp would address. 2/1/24 At 30,345 the problem is still unresolved and dealer gave me Toyota Corp number and I opened case 240201000061. 4 calls later I am told to bring my car to dealer 2/20/24. Research shows TSB 0042-14 for earlier RAV4. My safety problem is not new to Toyota, it is just a later model. When I told Toyota Corp their response from 6/15/23 to 2/1/24 is unacceptable, they took no ownership. When I asked if I should drive an unsafe car they said it is my choice. When I advised them of the language from the dealer said the tires were unsafe, they said the Dealer is independent from Toyota. In short, the dealer is "Independent". Toyota has a problem with their design using a static camber strut which causes premature wear which can lead to a blow out as shown by forums. Toyota is only interested in getting the car to 36,000 miles and little focus on safe design. I was surprised not to see this already listed. Perhaps it exists under another year? A company Hard Race has made adjustable rear Toe Arms for the RAV4. The dealer confirmed same.

2/9/2024

Loud clunk over bumps, suspension sounds loose and dangerous. Vehicle was purchased new and has 24,443 miles, this sound is NOT normal for a new vehicle.

4/11/2024

The contact owns a 2022 Toyota Rav4. The contact stated that while either driving at various speeds or coming to a stop, a moving water sound would emit from both the rear driver and passenger side doors. The contact had taken the vehicle to the dealer on multiple occasions to have the doors drained to prevent mold from developing inside the vehicle. The contact was also informed by the dealer that the failure was a result of the vehicle's design and that no other repairs could be made to address the failure. The manufacturer was not notified of the failure. The vehicle had yet to be repaired. The failure mileage was approximately 12,000.

10/17/2024

The contact owns a 2022 Toyota Rav4. The contact heard an abnormal sound coming from the driver's side rear door. The contact stated that the sound was a "sloshing" sound of water. The contact stated that when she had parked the vehicle on a road with an upgrade with the front of the vehicle facing up, she observed that water was leaking out from the bottom of the door. The contact stated that when it rained, the noise and water leak were more noticeable. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 26,000.

10/25/2024

The Cruise Control has issues. On 3 long rides so far, I have experienced that it suddenly loses speed and gives the message radar ready now. Furtunately i was maintaining very safe driving distance with other cars on the highway, which has helped me accelerate in time to continue driving and avoid collision. I dont know of any pattern which triggers this. This could lead to a serious problem if it fails in a tricky spot on highway. I am afraid to use it as its not 100 percent reliable.

7/8/2022

The contact owns a 2022 Toyota Rav4. The contact stated that while driving at an undisclosed speed, she noticed that the front windshield started to form a crack from the front passenger’s side over to the driver’s side of the windshield. The contact stated that the crack had formed without an impact to the windshield. The vehicle was not diagnosed nor repaired. Neither the dealer nor the manufacturer was notified of the failure. The failure mileage was 2,963. The VIN was unavailable.

11/9/2022

Problemas con el sistema de precolosion falla del sensor el carro es inseguro e tenido 2 incidentes donde el sistema no responde ni se activa antes del impacto problemas con el motor, estabilidad del carro, conteo de velocidad, frenos, llantas, cruze de carriles, puntos ciegos

12/20/2023

The Blind Spot Warning system fails to alert the driver when a vehicle in the adjacent lane is partially behind the current vehicle. It only activates when the nearby vehicle is completely behind the current vehicle. Due to this limitation, the system does not provide adequate warnings for nearby vehicles, which has nearly caused several accidents when the driver attempted to change lanes.

5/21/2024