2023 Hyundai Tucson Owner Complaints

I was driving on I95 and all of sudden the truck started sputtering and shut off. I turned off and back on , it would not go. Then the engine light came on. There was also smoke coming from the tail pipe when I tried again to start it. Back in December 2022, I was driving and the truck cut off and would not start at all. It was diagnosed as the Ignition coil being the problem. This horrible, both times could have been worse because of it cutting off while driving.

7/9/2023

This is copy and pasted from your site. Hyundai does not have a recall ready, so I am filing a complaint. Is this the correct action? THE TRANSMISSION ELECTRIC OIL PUMP FOR THE IDLE STOP & GO SYSTEM (ISG) IN THE SUBJECT VEHICLES MIGHT HAVE BEEN ASSEMBLED WITH PRINTED CIRCUIT BOARDS (PCB) THAT WERE DAMAGED DURING MANUFACTURING BY THE OIL PUMP CONTROLLER SUPPLIER. A DAMAGED CAPACITOR ON THE PUMP CONTROLLER PCB COULD IMPACT ELECTRICAL OPERATION LEADING TO HEAT DAMAGE TO THE ELECTRIC OIL PUMP CIRCUIT BOARD, CONNECTOR, AND WIRING HARNESS. THE HEAT DAMAGE AT THE PUMP INCREASES THE RISK OF A VEHICLE FIRE IN ADDITION TO A POTENTIAL CONTROLLER AREA NETWORK (CAN) COMMUNICATION DISRUPTION FOR MULTIPLE ONBOARD CONTROLLERS. Thanks for your time.

8/6/2023

Two days after purchasing this vehicle BRAND NEW, I received a "Low Oil" alert. I took it to the nearest Hyundai dealership where a salesman filled the engine with oil. Only a couple hundred miles later I received another "Low Oil" alert. I have been attempting to solve this issue with Hyundai, however, they are insistent that I must complete an oil consumption test, which takes 3,000 miles of testing to complete. This vehicle is burning oil, and burning oil FAST. I do not know where the burnt oil is going, but if it is going through the exhaust system and catalytic converter this may be a FIRE HAZARD.

12/19/2022

I leased my 2023 Hyundai Tucson from your Authorized Dealership South Shore Hyundai in NY March 18,2003. I received the vehicle with 34 miles on the digital Odometer at approximately 1750 eastern standard time. At approximately 2030 eastern standard time with the vehicle at 62 mile on the digital Odometer. I was Driving with my family, which is made up of my wife, daughter 22yrs old and son 14 years old on the Wantagh Parkway South approximately location 40.740739,-73.544842 at the speed limit of 55 MPH. I began to hear knocking noise from the front of the vehicle that progressively got louder. Then immediately the check engine, brake, oil, key with car, battery, open doors, every light that the dashboard has came on. Immediately the whole vehicle lost power and I could no longer accelerate. The steering wheel got stiff and the vehicle had no response to brakes. The vehicle started stuttering.The engine died, RPMs at 0 and no response on the accelerator, brakes and steering. The vehicle would not start.I tried push start several times start the vehicle, remote start, app start and putting the remote close to the push start with no results. I felt helpless and in a very dangerous situation that this brand new Hyundai vehicle put my family and me in. My family’s life was at the mercy of a 62 mile brand new 2023 Hyundai Tucson Sel that I received less than 2 and half hours ago from a certified dealership South Shore Hyundai in NY. We were stuck in the left lane in the middle of the Wantagh Parkway south bound with nowhere to go with the median divider to my left and to the right it was a fully active lane of on coming traffic in order to reach the safety of the shoulder. My family and I had to cross a full active lane of on coming traffic to get to the shoulder safely. We were able to get to the shoulder safely.The safety hazards presented by this vehicle created is dangerous to America Families. Brand New vehicle should not suddenly shut off.Put the public in danger.

3/20/2023

The contact owns a 2023 Hyundai Tucson. The contact stated that while driving from a stationary position, the vehicle switched to safe mode and suddenly decelerated, and would not accelerate above 20 - 27 MPH. During the failure, the message "Limited to 20 MPH" was displayed. The cause of the failure was not determined. The local dealer and manufacturer were not yet notified of the failure. The failure mileage was 1,789.

12/22/2022

I just bought the car, it was brand new off the lot. The check engine light came on followed by every emergency warning on my dash. After this my power steering failed, I was able to move over to the right lane a bit, but that’s it. I tried turning the car off at this point and turning it back on, but it would not turn back on. I could not even put on my emergency 4 way blinkers. The car would not even detect the key at this point. Thankfully we were on a small, low traffic road and not the freeway or a major accident would have been inevitable.

1/22/2023

Twice in the past two months, I have been driving down the highway going 70 mph with no car in close proximity to the front of me and the automatic emergency braking has activated, suddenly braking for no reason. In the first instance, there was a car in the lane to the left of me, and the second time cars on both sides of me. But in neither instance was a vehicle close to them front of my vehicle. The second time the car felt like it was going into a skid when the braking activated. I took the car to the dealer (Irwin Hyundai) the first time and they told me the sensors on the car were not properly calibrated when the new car was delivered to me. When I called Irwin’s today after it happened a second time, I was told the car was “functioning as designed” but they would look at it. I am scared to drive the car at this point given that the brakes randomly were activated while at high speeds and without any basis for activation.

12/28/2022

on 04/16/23 I got into my car and Immediately after going into drive the brakes completely failed. The car continued accelerating even after releasing the accelerator and refused to stop even while pumping the brakes. Thank god I turned into a tree and missed pedestrians. the car was totaled.

4/16/2023

Vehicle was purchased new from local Hyundai dealership in Dubuque, IA on November 17, 2022 and delivered November 22nd. Vehicle had just under 200 miles on odometer. Brake system was working well at that time. On January 21, 2023 I stopped for a red light. After a few seconds the brake pedal started going down and went completely down. Mileage at that time was just over 1700 miles. I took the car into the dealership on January 23rd and they checked the system and said that it was normal. The shop supervisor said that it was not a problem that when the pedal went down it was applying more pressure to the brake system. I disagreed with them as this is usually the fault of master cylinder seals leaking. They brought a newer vehicle into the shop and it had the same problem so no repairs were made. I believe this is an accident waiting to happen and I would like to have the problem corrected. This appears to be a problem with Hyundai vehicles. Our vehicle is a Hyundai Tucson.

1/24/2023

I leased this SUV 12/22/2023,upon driving it on 12/26 as i exited a major highway,leaving highway amd entering exit ramp the SUV lost brake funcrion as well as transmission function,absolute total loss of both brake and transmission systems,miraculously I was able to coast to safty with assistance from another motorist holding the car from rolling furthermore,needless to say this was a harrowing and dangerously close to a tragic accident due to this compmete failure of brake and transmission simultaneously failing,i had to incur a costly towing fee and also completely uninformed as to what the root/cause of problem was as well as any timeframe of repair,as of the time of myself writing this message and thirty plus days later ,I have recieved ZERO cooperation and even outwardly standoffish behavior towards myself,my hisband and my personal leasing agent,I am very concerned of the loaner car becoming a financial burden as my husband was forced to basically suffer rentL vetting and credit card deposit protocols upon paying for and delivering the damaged SUV,we have for weeks tried to ascertain any information on the extent and cause of damage to leased SUV as we are NOT INTRESTED in recieving original damaged because we are FEARFUL of our safety as we are STILL uninformed as of 1/31/2023 PLEASE NOTE LOCAL POLICE WERE ON THE SCENE AND CONFIRMED TOTAL BREAKDOWN STATUs/TOW NEEDED STATUS

1/31/2023

I leased this SUV 12/22/2023,upon driving it on 12/26 as i exited a major highway,leaving highway amd entering exit ramp the SUV lost brake funcrion as well as transmission function,absolute total loss of both brake and transmission systems,miraculously I was able to coast to safty with assistance from another motorist holding the car from rolling furthermore,needless to say this was a harrowing and dangerously close to a tragic accident due to this compmete failure of brake and transmission simultaneously failing,i had to incur a costly towing fee and also completely uninformed as to what the root/cause of problem was as well as any timeframe of repair,as of the time of myself writing this message and thirty plus days later ,I have recieved ZERO cooperation and even outwardly standoffish behavior towards myself,my hisband and my personal leasing agent,I am very concerned of the loaner car becoming a financial burden as my husband was forced to basically suffer rentL vetting and credit card deposit protocols upon paying for and delivering the damaged SUV,we have for weeks tried to ascertain any information on the extent and cause of damage to leased SUV as we are NOT INTRESTED in recieving original damaged because we are FEARFUL of our safety as we are STILL uninformed as of 1/31/2023 PLEASE NOTE LOCAL POLICE WERE ON THE SCENE AND CONFIRMED TOTAL BREAKDOWN STATUs/TOW NEEDED STATUS

1/31/2023

I leased my 2023 Hyundai Tucson from your Authorized Dealership South Shore Hyundai in NY March 18,2003. I received the vehicle with 34 miles on the digital Odometer at approximately 1750 eastern standard time. At approximately 2030 eastern standard time with the vehicle at 62 mile on the digital Odometer. I was Driving with my family, which is made up of my wife, daughter 22yrs old and son 14 years old on the Wantagh Parkway South approximately location 40.740739,-73.544842 at the speed limit of 55 MPH. I began to hear knocking noise from the front of the vehicle that progressively got louder. Then immediately the check engine, brake, oil, key with car, battery, open doors, every light that the dashboard has came on. Immediately the whole vehicle lost power and I could no longer accelerate. The steering wheel got stiff and the vehicle had no response to brakes. The vehicle started stuttering.The engine died, RPMs at 0 and no response on the accelerator, brakes and steering. The vehicle would not start.I tried push start several times start the vehicle, remote start, app start and putting the remote close to the push start with no results. I felt helpless and in a very dangerous situation that this brand new Hyundai vehicle put my family and me in. My family’s life was at the mercy of a 62 mile brand new 2023 Hyundai Tucson Sel that I received less than 2 and half hours ago from a certified dealership South Shore Hyundai in NY. We were stuck in the left lane in the middle of the Wantagh Parkway south bound with nowhere to go with the median divider to my left and to the right it was a fully active lane of on coming traffic in order to reach the safety of the shoulder. My family and I had to cross a full active lane of on coming traffic to get to the shoulder safely. We were able to get to the shoulder safely.The safety hazards presented by this vehicle created is dangerous to America Families. Brand New vehicle should not suddenly shut off.Put the public in danger.

3/20/2023

This is copy and pasted from your site. Hyundai does not have a recall ready, so I am filing a complaint. Is this the correct action? THE TRANSMISSION ELECTRIC OIL PUMP FOR THE IDLE STOP & GO SYSTEM (ISG) IN THE SUBJECT VEHICLES MIGHT HAVE BEEN ASSEMBLED WITH PRINTED CIRCUIT BOARDS (PCB) THAT WERE DAMAGED DURING MANUFACTURING BY THE OIL PUMP CONTROLLER SUPPLIER. A DAMAGED CAPACITOR ON THE PUMP CONTROLLER PCB COULD IMPACT ELECTRICAL OPERATION LEADING TO HEAT DAMAGE TO THE ELECTRIC OIL PUMP CIRCUIT BOARD, CONNECTOR, AND WIRING HARNESS. THE HEAT DAMAGE AT THE PUMP INCREASES THE RISK OF A VEHICLE FIRE IN ADDITION TO A POTENTIAL CONTROLLER AREA NETWORK (CAN) COMMUNICATION DISRUPTION FOR MULTIPLE ONBOARD CONTROLLERS. Thanks for your time.

8/6/2023

PEDAL ACCELERATOR NOT WORKED

10/15/2023

ICU Module Failure. Power Steering not as effective, instrument cluster failure, driver warnings like low tire pressure, blind spot detection and others do not work. Speedometer and miles driven stopped working. Advised to not drive the car as power steering could completely fail without warning.

12/30/2022

I just bought the car, it was brand new off the lot. The check engine light came on followed by every emergency warning on my dash. After this my power steering failed, I was able to move over to the right lane a bit, but that’s it. I tried turning the car off at this point and turning it back on, but it would not turn back on. I could not even put on my emergency 4 way blinkers. The car would not even detect the key at this point. Thankfully we were on a small, low traffic road and not the freeway or a major accident would have been inevitable.

1/22/2023

on 04/16/23 I got into my car and Immediately after going into drive the brakes completely failed. The car continued accelerating even after releasing the accelerator and refused to stop even while pumping the brakes. Thank god I turned into a tree and missed pedestrians. the car was totaled.

4/16/2023

The contact owns a 2023 Hyundai Tucson. The contact stated while driving at an undisclosed speed, the ABS, check engine, low oil pressure, and Forward Collision Avoidance warning lights illuminated. The vehicle was taken to the dealer but was not yet diagnosed. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 6,200.

9/20/2023

When driving in dark areas with low outdoor lighting, the instrument panel is reflected in the drivers window. Aside from being distracting, there is obstructed visibility where the reflection occurs. I have made repeated calls, that go ignored, to Hyndai Customer Care, brought it to my service dealer upon request for protocol, who could not react because it was daytime. The instrument panel happens not to be recessed as in other cars I have had. I simply want suggestions on how to alleviate the problem. Thank you

11/21/2022

I HAVE NOT HAD A PROBLEM BUT THE TURN SIGNALS ARE POLACED AT THE LOWEST POINT ON REAR BUMPER MAKING IT DIFFICULT FOR THE CAR FOLLOWING TO SEE THE SIGNAL. THIS MAY CAUSE A REAR COLLISION. IT NEEDS TO BE IN THE BRAKE LIGHT PANEL. A DESIGN FLAW IN MY OPINION. MAYBE A SIMPLE REWIRE WILL FIX THE DEFECT.03/22/202

6/17/2023

I just bought the car, it was brand new off the lot. The check engine light came on followed by every emergency warning on my dash. After this my power steering failed, I was able to move over to the right lane a bit, but that’s it. I tried turning the car off at this point and turning it back on, but it would not turn back on. I could not even put on my emergency 4 way blinkers. The car would not even detect the key at this point. Thankfully we were on a small, low traffic road and not the freeway or a major accident would have been inevitable.

1/22/2023

Power steering failed DURING vehicle operation while car was moving at speed. Steering wheel became excessively difficult to turn, severely limiting control of the vehicle and rendering the vehicle undriveable. Vehicle displayed DTC codes C168886 and C241396. These codes appear to be indicative of a failure of one or all of the power steering system wiring, motor, and electronic control unit.

6/20/2023

When the vehicle was started the SRS light remained illuminated and when driving the vehicle over 40 MPH the abs, traction control, collision avoidance, and start-stop lights on the instrument cluster come on and remained on. The adaptive cruise control, nor the button for the start-stop deactivation work. The vehicle has just over 500 miles on the vehicle and is less than a week old.

7/6/2023

Vehicle randomly keeps accelerating past the set speed when cruise control is set. Problem was first noticed in March. Have a video of the cruise set at 69 mph and the vehicle continued to accelerate to 87 mph before I disengaged it. Vehicle has been to two different Hyundai dealers for the issue but were unable to duplicate or find the issue. One moth ago were on a road trip and the cruise would accelerate to 8-10mph over the set speed on the cruise control especially after cresting a hill ,then the adaptive cruise control would brake hard when approaching another vehicle. 0

10/6/2023

When driving in dark areas with low outdoor lighting, the instrument panel is reflected in the drivers window. Aside from being distracting, there is obstructed visibility where the reflection occurs. I have made repeated calls, that go ignored, to Hyndai Customer Care, brought it to my service dealer upon request for protocol, who could not react because it was daytime. The instrument panel happens not to be recessed as in other cars I have had. I simply want suggestions on how to alleviate the problem. Thank you

11/21/2022

Car is 7 months old. We had it less than 2 weeks and a rock hit the windshield and caused a crack, which we had professionally repaired the next day. 3 weeks later another small rock hits the windshield and it cracks to the point we have to have it replaced. 5 weeks later another small item hits the windshield and it cracks and we have to have it replaced again. Today, a small rock hit the windshield and caused a crack that we will be having repaired tomorrow. I have never had a car where we had to have a repair or replacement of the windshield more than once every 1-2 years and this is the 3rd windshield in the car in less than 7 months. My insurance has covered the costs so far except for the time and trouble of me having to take time off of work to go to the windshield place and have it repaired or replaced. I complained to the Hyundai dealership about this situation and the service manager told me "maybe you should drive on a different road". We drive this car 2 times a week on well traveled paved freeways. This is insane and makes me concerned that the glass is too thin potentially being a danger in the case of an accident. Plus when you pay 45k for a car, you would expect the windshield to last more than a month at a time.

6/29/2023

ICU Module Failure. Power Steering not as effective, instrument cluster failure, driver warnings like low tire pressure, blind spot detection and others do not work. Speedometer and miles driven stopped working. Advised to not drive the car as power steering could completely fail without warning.

12/30/2022

I was backing out of my driveway, which is on a busy street. I waited for the traffic to clear. I backed out onto the main road, which I thought was completely clear, but a car came behind me and I smacked right into him. There was no beeping from my car, and the automatic braking system did not engage at all. The rear of my car, particularly the driver's side, was severely damaged. The other car's passenger front door was badly damaged. The side curtain airbag on their car deployed and their vehicle (Volvo station wagon) was not driveable. The emergency braking system frequently engages unexpectedly when I back out of my driveway, even when there is no hazard. The unexpected braking is oftentimes dangerous. However, this time, when I needed it, it did not engage. An outside diagnostic inspection was done on the vehicle, and showed "no event." If you saw the cars involved in the accident, it is clear there was a significant "event."

11/30/2025

I was driving on the highway & my sunroof exploded. Glass was shattered & rained down on me & my occupants. 1/The sun roof - I have since vacuumed the mess, but it is still not repaired. Available for inspection if needed until I get it into the shop. 2/ I was driving 65 mph when the loud noise (phone gave a warning of decibal level not safe) - broken glass & glass 'dust' blowing on us / breathed in by us. The shock of it happening when surrounded by busy traffic on a highway. 3/I have made many calls into Hyundai to get it taken care of - they are not returning my calls. 4/I initially took it into a dealership (Ken Garff-Surprise) & they did not seem interested in inspecting - had a glass company reach out to me to replace the sunroof thru my insurance. 5/No warning at all.

2/25/2023

Driving down the freeway at normal speeds and my panoramic sunroof literally just exploded, raining tempered glass all over the interior of the vehicle while I was driving. No evidence that it was caused by any road debris, objects, nor falling objects from the sky. I wasn’t driving under a bridge and no cars/trucks were immediately next to me nor in front of me. Traffic was flowing at normal speed. I wasn’t injured but was certainly startled and distracted for a moment to gauge what had just happened. The dealer is looking into it. Claims it could have been caused by a rock. That seems to defy the law of physics and the glass actually look like it bowed from the inside out as if too much pressure was being applied to the glass. Searches online seem to point to several class action lawsuits and plenty of reports of similar exploding sunroofs!

1/22/2024

When the vehicle was started the SRS light remained illuminated and when driving the vehicle over 40 MPH the abs, traction control, collision avoidance, and start-stop lights on the instrument cluster come on and remained on. The adaptive cruise control, nor the button for the start-stop deactivation work. The vehicle has just over 500 miles on the vehicle and is less than a week old.

7/6/2023

I was driving straight when a vehicle coming from the opposite direction made a left turn without yielding, crossing into my lane. As a result, my vehicle collided with the other car at full speed. However, the airbag in my steering wheel did not deploy upon impact, as it should have. My injuries have been significantly more severe than they would have been had the airbag functioned properly. I reported this issue to the vehicle manufacturer, and they opened a case and conducted an inspection. During their inspection, they found that the airbag had since deployed. However, my vehicle was transported off a steep hill and moved to multiple lots before the inspection, any of which could have triggered a delayed deployment. Despite this, the manufacturer has refused to accept liability. Because the airbag failed to deploy at the time of impact, there was no buffer between me and the steering wheel. This resulted in excessive force against my chest from the seatbelt and direct impact with the steering wheel, leading to more severe injuries. There were no warning lights on in the vehicle before the crash, nor were there any recalls related to this issue at the time of the incident.

2/19/2025

The contact owns a 2023 Hyundai Tucson. The contact stated that while driving approximately 70 MPH, the vehicle experienced phantom braking without another vehicle or object being nearby. The contact deactivated the system and was able to drive the vehicle safely. The contact stated that the failure recurred several times without warning. The vehicle was taken to the dealer who determined that the bracket supporting the sensor had detached, causing the system failure. The vehicle was not repaired. The contact deactivated the Forward Collision Avoidance system. The manufacturer was made aware of the failure and opened a case. The contact was referred to the NHTSA Hotline. The approximate failure mileage was 100.

10/27/2023

The contact owns a 2023 Honda Tucson. The contact stated while driving 74 MPH with the cruise control activated, the Forward Collision Avoidance system activated, after which the Automatic Emergency Braking activated, causing a rapid deceleration to the vehicle. The contact was able to regain control of the vehicle by lightly tapping the brake pedal, deactivating the system. The vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was taken to the dealer, who was unable to duplicate the failure but informed the contact that they would disable the Forward Collision Avoidance system pending a diagnosis. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 13,000.

2/22/2024

The contact owned a 2023 Hyundai Tucson. The contact stated that while his mother was driving at an undisclosed speed, she heard an abnormal sound emanating from an unknown location of the vehicle, after which the vehicle began to accelerate on its own. The driver attempted to stop the vehicle, but the brake pedal pulsated and failed to slow the vehicle, resulting in the driver briefly losing control of the vehicle and only coming to a complete stop after colliding with a utility pole. Both the driver and passenger side air bags deployed. No warning lights were illuminated. The vehicle was towed to a tow yard and deemed a total loss by the contact's insurance provider. A police report was filed, and injuries were reported. The driver and passenger were both transported to an area hospital by EMT and treated for injuries to the chest sustained from the air bags. The manufacturer was not notified of the failure. The failure mileage was 10,000.

7/3/2024

The contact owns a 2023 Hyundai Tucson. The contact stated that while driving at approximately 5 MPH in a parking lot and slowing down to park the vehicle, the vehicle independently accelerated. The contact depressed the brake pedal with force and stopped the vehicle, and was able to shift to park(P). The contact stated that the RPM revved up to 8,000 RPM, and the contact turned off the vehicle. There were no warning lights illuminated. The contact had taken the vehicle to a local dealer, and the dealer was unable to duplicate the failure. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was 19,241.

10/15/2025

I previously leased my vehicle from Rick Case Hyundai in April 2023, In November i started having issues with my vehicle as i moved to Colorado. My whole vehicle starts to uncontrollably shake going 25 mph and over. Since highway speed limit is 65 that is where i struggle the most with driving and that is the most endangering as well. I have to pump my breaks and hope they don't stop working. I have taken my car to get a diagnostic multiple times at different dealerships and each time i went to another dealership they advised a different problem I can send an email or mail with all attachments of diagnostic reports from Hyundai dealership. Each dealership advised one of these problems, engine, brakes, rotors, tires, etc, although the vehicle was a few months old! I reported lemon l to Hyundai Customer service with 2 different attempts and they denied my lemon law and advised i should pay for anything not under warranty. Although the vehicle has a manufacture defect i will be continuing to attempt different dealerships to help my cause since i am endangering myself and everyone around me. I have done enough research to know i am not the only person with this problem and this should be a recall defect. I need a solution so i can drive in the state i live in ,Colorado, and not be scared for my life that my car will stop working at some point.

6/16/2025

2023 Hyundai Tuscon - Very Low Milage approx 6500 Miles - while in a parking lot, The rear passenger Carrier ARM which holds the Control arm fully cracked causing the Control arm to fall off. This product failure is unprecedented as it was a total part manufacture failure. NO impact or under carriage damage was found, even upon Dealer inspection. I as the driver of the vehicle confirm that No impact, accident occurred, and luckily I was not on a highway when it occurred. This was caused ONLY as a result of Product Failure. My concern is that this may occur on the other wheel(s) as a product failure is often NOT a one- product issue, but usually a batch failure. So I am concerned for my safety and the safety of others on the road with this vehicle and product part. Another concern - this vehicle was manufactured during the covid era, and I am concerned about product failures as parts were difficult to get and may have been sourced without proper testing during this time). Kindly advise me on your findings, and if there is an inspection that can be performed to assure me that the car is safe.

10/30/2025

ICU Module Failure. Power Steering not as effective, instrument cluster failure, driver warnings like low tire pressure, blind spot detection and others do not work. Speedometer and miles driven stopped working. Advised to not drive the car as power steering could completely fail without warning.

12/30/2022

The contact owns a 2023 Hyundai Tucson. The contact stated while driving at an undisclosed speed, the ABS, check engine, low oil pressure, and Forward Collision Avoidance warning lights illuminated. The vehicle was taken to the dealer but was not yet diagnosed. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 6,200.

9/20/2023

The contact owns a 2023 Hyundai Tucson. The contact stated that while driving approximately 70 MPH, the vehicle experienced phantom braking without another vehicle or object being nearby. The contact deactivated the system and was able to drive the vehicle safely. The contact stated that the failure recurred several times without warning. The vehicle was taken to the dealer who determined that the bracket supporting the sensor had detached, causing the system failure. The vehicle was not repaired. The contact deactivated the Forward Collision Avoidance system. The manufacturer was made aware of the failure and opened a case. The contact was referred to the NHTSA Hotline. The approximate failure mileage was 100.

10/27/2023

The contact owns a 2023 Hyundai Tucson. The contact stated that on three occasions while the vehicle was in park(P), the vehicle failed to shift into the intended gear. The vehicle was towed to a dealer where it was diagnosed and determined that the rear-view sensor needed to be replaced. The vehicle was repaired. On another occasion, while at a car wash the rear hatch opened inadvertently. On another occasion, while driving approximately 65 MPH, the Emergency Automatic Braking Display light was illuminated, and the vehicle slowed down inadvertently. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 500.

12/8/2023

The contact owns a 2023 Hyundai Tucson. The contact stated that after placing the vehicle in park(P) and exiting the vehicle, the vehicle inadvertently rolled backwards. The contact stated that the vehicle was equipped with Automatic Emergency Braking; however, the system failed to activate, resulting in damage to the vehicle. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 22,000.

1/31/2024

See attached document for complaint

3/12/2024

While driving 35mph on a 3-lane street in the far left lane, a driver of a Ford F-150 was in the center lane about two car lengths ahead, decided to make a right turn onto a residential street (as if he were driving a semi). As I got closer, the forward collision warning suddenly alerted and immediately initiated emergency braking system causing all 3 passengers to be thrown forward. I hit the steering wheel before seat belt caught me. I was not even within distance and he was turning in opposite direction of my lane. There also seems to be sensitivity issues with lane keeping feature as in Phoenix, there are never ending freeway construction with make-shift lanes not always marked well. On several occasions the steering wheel was jerked out of my hands because it couldn’t detect the lanes any longer. It has caused me to avoid freeways all together and has made me miss the exit off the freeway twice now. I thought this feature only activated during active cruise control, but apparently it does it regardless. Now I’m beginning to have problems with display going out at the worst times. I will be taking my Tucson to a dealer to have them deactivate both systems & advise of display. I shouldn’t have to pay for this. I’ll take over the driving, thank you very much!

4/20/2024

The contact owns a 2023 Hyundai Tucson. The contact stated while driving 20 MPH approaching a RED traffic light and depressing the brake pedal, the vehicle failed to stop as needed. The contact steered the vehicle on a patch of grass nearby and shifted into neutral(N) to stop the vehicle. There were no warning lights illuminated. The battery was detached and reconnected to reset the vehicle. The contact was able to drive the vehicle at low speeds. The dealer was contacted and informed of the failure. The dealer stated that without warning lights being illuminated they would not be able to diagnose the vehicle to determine the cause of the failure. The vehicle had not been taken to the dealer to be diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was 22,600.

6/14/2024

This week I noticed my low tone horn on my vehicle had stopped working It was replaced under warranty by Hyundai at 41000 miles Only a little while ago at 35000 miles both horns went out and I only learned this when I needed it to help avoid being hit and it wasn’t available Hyundai indicated they are aware of issue but are still replacing horns with the same original part that is prone to shorting out

4/17/2025

While on the road, the sunroof just shattered completely. In this instance, nobody was hurt as the cover below the sunroof was open and that caught all the glass pieces. The car is hardly 2 year old and warranty covered the repairs. The complaint is that Hyundai never gave a clear answer as to why this happened and what can be done to prevent it. There is no consideration of the passengers getting hurt and startled by this incident. Also no consideration for the time it took for the repairs, the dealership never gave a loaner and we didn’t know we could rent it and Hyundai would reimburse. I feel Hyundai cannot just say sorry and move on as there has to be a reason for this and we pay extra for having a sunroof. I am not satisfied with Hyundai’s method of dealing with customers who suffered bear of their own manufacturing.

6/16/2025

2023 Hyundai Tuscon - Very Low Milage approx 6500 Miles - while in a parking lot, The rear passenger Carrier ARM which holds the Control arm fully cracked causing the Control arm to fall off. This product failure is unprecedented as it was a total part manufacture failure. NO impact or under carriage damage was found, even upon Dealer inspection. I as the driver of the vehicle confirm that No impact, accident occurred, and luckily I was not on a highway when it occurred. This was caused ONLY as a result of Product Failure. My concern is that this may occur on the other wheel(s) as a product failure is often NOT a one- product issue, but usually a batch failure. So I am concerned for my safety and the safety of others on the road with this vehicle and product part. Another concern - this vehicle was manufactured during the covid era, and I am concerned about product failures as parts were difficult to get and may have been sourced without proper testing during this time). Kindly advise me on your findings, and if there is an inspection that can be performed to assure me that the car is safe.

10/30/2025

I was backing out of my driveway, which is on a busy street. I waited for the traffic to clear. I backed out onto the main road, which I thought was completely clear, but a car came behind me and I smacked right into him. There was no beeping from my car, and the automatic braking system did not engage at all. The rear of my car, particularly the driver's side, was severely damaged. The other car's passenger front door was badly damaged. The side curtain airbag on their car deployed and their vehicle (Volvo station wagon) was not driveable. The emergency braking system frequently engages unexpectedly when I back out of my driveway, even when there is no hazard. The unexpected braking is oftentimes dangerous. However, this time, when I needed it, it did not engage. An outside diagnostic inspection was done on the vehicle, and showed "no event." If you saw the cars involved in the accident, it is clear there was a significant "event."

11/30/2025