2020 Hyundai Santa Fe Owner Complaints

TL* THE CONTACT OWNED A 2020 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE DRIVING AT 65 MPH THE POWER STEERING SUDDENLY FAILED CAUSING THE STEERING WHEEL TO BECOME VERY DIFFICULT TO TURN. THE CONTACT STATED WHILE STOPPING THE VEHICLE IT SUDDENLY STALLED. THE CONTACT STATED VARIOUS WARNING ALERTS ILLUMINATED. THE VEHICLE WAS TOWED TO THE LOCAL DEALER PUGI HYUNDAI (1866 OGDEN AVE. DOWNERS GROVE, IL.) WHO DIAGNOSED THAT THE BATTERY WAS FAULTY. THE BATTERY WAS RECHARGED BUT THE FAILURE REOCCURRED. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE THE ALTERNATOR AND BATTERY WAS REPLACED. LATER, AFTER DRIVING AND PARKING THE VEHICLE, IT CAUGHT ON FIRE. THE FIRE DEPARTMENT WAS CALLED TO THE SCENE AND EXTINGUISHED THE FIRE. A FIRE DEPARTMENT REPORT WAS TAKEN AS THEY BELIEVE THE FIRE WAS STARTED IN THE ENGINE COMPARTMENT. A FIRE DEPARTMENT REPORT WAS FILED. THE VEHICLE WAS DESTROYED AND TOWED AWAY. THE CAUSE OF THE FAILURE WAS NOT DETERMINED BY THE DEALER OR AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND A CASE WAS OPENED. THE FAILURE MILEAGE WAS 80.

3/16/2020

MY HUSBAND AND I PURCHASED THIS CAR BRAND NEW, WITH ONLY 252 MILES ON IT. ON THE THIRD DAY OF OWNING IT WE WERE DRIVING AND WITHIN 5 MILES THE CAR BEGAN ALARMING WITH THE CENTER DRIVER CONSOLE INDICATING THE ENGINE WAS OVERHEATED. THE TEMPERATURE GAUGE WAS IN THE RED ZONE. AFTER A FEW SECONDS IT DROPPED SLIGHTLY AND FLUCTUATED IN THE UPPER 2/3S OF THE HIGH TEMPERATURE REGION. WE DROVE TO THE DEALERSHIP, WHICH WAS WITHIN 10 MILES. ONCE WE WERE WITHIN HALF A MILE THE CAR ENGINE BEGAN RATTLING EVERY-TIME I TRIED TO ACCELERATE AND THE TEMPERATURE GAUGE AT THIS POINT REMAINED IN THE REDLINE. IN ADDITION, DURING ALL OF THIS WE TURNED THE HEAT ON TO PULL SOME HEAT FROM THE ENGINE BUT ONLY COLD AIR WOULD BLOW. WE WERE WITHIN THE 3 DAY GRACE PERIOD OF NO QUESTIONS ASKED RETURN POLICY SO WE DECIDED TO RETURN THE CALL AS IT WAS BRAND NEW AND HAD SUCH A SERIOUS MALFUNCTION. WE HAVE NOT HEARD BACK FROM THE DEALERSHIP AS TO WHY THE CAR MALFUNCTIONED.

9/11/2020

THE FCA (FORWARD COLLISION AVOIDANCE) SYSTEM DOES NO WORK AS IT SHOULD. IT DOES NOT SEE VEHICLES OR PEDESTRIANS DIRECTLY IN FRONT WHILE NOT IN CRUISE CONTROL. THE ONLY TIME THE SYSTEM ALARMS IS WHEN FOLLOWING A VEHICLE, WHICH IS IN THE SAME LANE ON CITY STREETS, AND THEN THE TARGET VEHICLE TURNS RIGHT AND CREATES NO HAZARD. THE FCA DOES NOT WORK ACCORDING TO WHAT IS MENTIONED IN THE OWNERS MANUAL, NOR DOES IT OPERATE LIKE IT IS SHOWN IN A YOUTUBE VIDEO SPONSORED BY HYUNDAI.

1/11/2020

MY CAR IS SITING IN PARK, RUNNING WITH THE DRIVER'S DOOR OPEN IN MY TOWN HOUSE PARKING LOT. I GET OUT OF MY CAR TO OPEN THE PASSENGER'S BACK DOOR AS WELL AS MY TRUNK FOR HER. I THEN GET BACK INTO THE DRIVER'S SEAT. I AM WAITING ON MY FRIEND TO LOAD HER ITEMS INTO MY NEW SANTA FE FOR AN OUT OF TOWN RETREAT. SHE FINISHES LOADING ITEMS AND PROCEEDS TO GET INTO THE PASSENGER SIDE FRONT SEAT. AS SHE IS GETTING INTO THE CAR, "SHE SAYS SHE NEEDS TO GO TO THE BATHROOM". I TELL HER LET'S GO NOW BEFORE WE GET STARTED ON OUR TRIP. WE WERE SUPPOSE TO BE MEETING ABOUT 10 COLLEGE STUDENTS. SO I GET OUT OF MY CAR SINCE I HAVE THE HOUSE KEYS. MY CAR IS STILL IN PARK AND RUNNING. I DO LEAVE MY DRIVER'S DOOR OPEN ABOUT A 20-25 DEGREE ANGLE. MY FRIEND WALKS AROUND THE BACK OF THE CAR. AS WE ARE WALKING TOWARD MY TOWNHOUSE, I TURN AROUND BECAUSE I HEAR A NOISE. I IMMEDIATELY SEE MY CAR NOT ROLLING BUT BACKING UP ON A SMALL INCLINE UPWARD ACROSS MY PARKING LOT. IT SEEMS TO HAVE PICKED UP SPEED AND THEN HITS THE BACK OF A PARKED CAR IN THE PARKING LOT. MY CAR HITS THE PARKED GRAY CAMRY WITH SO MUCH MOMENTUM THAT IT BUTTERFLIES MY DRIVER'S DOOR COMPLETELY OPEN AND THE CAR NEVER SLOWS DOWN. THE CAR CONTINUES MOVING WHILE THE INSIDE OF MY DRIVER'S DOOR SCRUBS THE PARKED CAMRY. AFTER MY CAR MOVES PAST THE CAMRY IT IS STILL MOVING AT AN ACCELERATED RATE. I AM YELLING AND RUNNING TO MY CAR WITH MY KEYFOB TRYING TO PUSH BUTTONS TO GET IT TO STOP. MY FRIEND IS RUNNING AND CHASING MY CAR. SHE IS ABLE TO GET TO MY CAR AND JUMP IN WHERE SHE PUSHES ON THE BRAKES VERY HARD TO MAKE THE CAR STOP. IF SHE HAD NOT BEEN ABLE TO DO THAT MY CAR WOULD HAVE HIT A PARKED BLACK TRUCK OR WOULD HAVE JUMPED THE SIDEWALK AND RAN INTO A TOWNHOUSE BEFORE IT STOPPED. ONCE MY FRIEND GOT THE CAR TO STOP. SHE LOOKED DOWN AND IT WAS STILL IN PARK AND WAS NOT MAKING THE DINGING NOISE IT USUALLY DOES WHEN IT IS IN REVERSE.

2/4/2020

BRAKE HAS BEEN STICKING LAST COUPLE OF WEEKS SO THAT I HAD TO PUMP BRAKE TO RELEASE TO START. THIS MORNING I WENT OUT TO THE DRIVEWAY AND COULD NOT GET INTO CAR WITH EITHER REMOTE OR BY USING BLUE LINK ON MY PHONE. I USED THE MANUAL KEY BUT COULD NOT RELEASE ANY OTHER DOORS OR LIFT GATE. NO LIGHTS, HAZARDS, RADIO NO NOTHING. I HAVE HAD A FEW DEAD BATTERIES AND NEVER HAD A CAR THAT DEAD OVERNIGHT. I DROVE HOME FROM WORK PREVIOUS NIGHT AND I WAS OUTSIDE AFTER DARK NEXT TO MY CAR, NO LIGHTS LEFT ON. I CALLED ROADSIDE ASSISTANCE, FIRST GUY SAID HE THOUGHT THERE WAS A SHORT, PARKING BRAKE WOULD NOT RELEASE AND CAR STILL DID NOT START. A DIFFERENT TOW TRUCK HAD TO COME WITH DOLLIES AND IT WAS TOWED TO THE DEALER. DEALER SAID IT WAS A DEAD BATTERY AT 4918 MILES! THANKFULLY I WAS AT HOME AND THE HEAT INDEX WAS NOT AT 105 DEGREES YET FOR THE DAY.

8/27/2020

MY HUSBAND AND I PURCHASED THIS CAR BRAND NEW, WITH ONLY 252 MILES ON IT. ON THE THIRD DAY OF OWNING IT WE WERE DRIVING AND WITHIN 5 MILES THE CAR BEGAN ALARMING WITH THE CENTER DRIVER CONSOLE INDICATING THE ENGINE WAS OVERHEATED. THE TEMPERATURE GAUGE WAS IN THE RED ZONE. AFTER A FEW SECONDS IT DROPPED SLIGHTLY AND FLUCTUATED IN THE UPPER 2/3S OF THE HIGH TEMPERATURE REGION. WE DROVE TO THE DEALERSHIP, WHICH WAS WITHIN 10 MILES. ONCE WE WERE WITHIN HALF A MILE THE CAR ENGINE BEGAN RATTLING EVERY-TIME I TRIED TO ACCELERATE AND THE TEMPERATURE GAUGE AT THIS POINT REMAINED IN THE REDLINE. IN ADDITION, DURING ALL OF THIS WE TURNED THE HEAT ON TO PULL SOME HEAT FROM THE ENGINE BUT ONLY COLD AIR WOULD BLOW. WE WERE WITHIN THE 3 DAY GRACE PERIOD OF NO QUESTIONS ASKED RETURN POLICY SO WE DECIDED TO RETURN THE CALL AS IT WAS BRAND NEW AND HAD SUCH A SERIOUS MALFUNCTION. WE HAVE NOT HEARD BACK FROM THE DEALERSHIP AS TO WHY THE CAR MALFUNCTIONED.

9/11/2020

WHEN STOPPED AT A TRAFFIC LIGHT AND THE AUTO ENGINE TURN OFF KICKS IN AS EXPECTED WITH MY FOOT ON THE BRAKE PEDAL. HOWEVER, THE BEHAVIOR IS VERY ERRATIC WHEN I RELEASE MY FOOT FROM THE BRAKE. SOMETIMES THE VEHICLE JUMPS AGGRESSIVELY WITHOUT ME APPLYING ANY ACCELERATION AND SOMETIMES THE ENGINE JUST STARTS AND THE VEHICLE DOES NOT MOVE UNTIL I APPLY SOME ACCELERATION. I ALMOST REAR ENDED THE CARS INFRONT OF ME FEW TIMES. I GOT WAY TOO SKEPTICAL AND BEGAN TURNING OFF THE AUTO TURN OFF FEATURE WHEN I GET INTO MY CAR.

2/15/2021

THERE ARE THREE ISSUES: 1.) IN SPORT MODE, THE TRANSMISSION WILL SOMETIMES GET STUCK/HUNG IN GEAR (MAYBE GEAR 3 OR GEAR4) AND WILL NOT SHIFT INTO THE NEXT GEAR, EVEN WHEN INCREASING SPEED. 2.) ALSO IN SPORT MODE, AFTER DRIVING FOR ABOUT 10 OR 15 MINUTES THE TRANSMISSION WILL OFTEN SLIP INTO GEAR 5, AFTER REVVING HIGH AND CAN BE HEARD REVVING, BUT IT IS NOT REFLECTED ON THE TACHOMETER, AND THEN WHEN THE GEAR CATCHES IT IS A VIOLET JERK FORWARD. 3.) LASTLY, IN ANY MORE, BUT MOST PRONOUNCED IN "SMART MODE" AFTER TAKING OUT FROM A COMPLETE STOP, AND ESPECIALLY AFTER THE ENGINE GOES INTO AUTO SHUT OFF MODE, THE TRANSMISSION WILL STUTTER AT ABOUT 3 - 5 MPH AND FEELS AS IF POWER HAS BEEN LOST FOR A FEW SECONDS. THIS IS MOST TERRIFYING WHEN MAKING A LEFT TURN INTO TRAFFIC, AS YOU NEVER KNOW IF IT WILL HAPPEN OR NOT.

3/19/2021

HAVE ONLY HAD THE 2020 SANTAFE 2.0T FOR A FEW WEEKS - 1,000 MILES. IT IS GOING TO THE SHOP (SELLING DEALER). THE TURBO LAG HAS ALMOST GOT ME T-BONED TWICE WHEN PULLING OUT INTO TRAFFIC. THIS IS CLEARLY A SAFETY ISSUE. IT DID NOT SEEM THIS WAY ON THE TEST DRIVE. THE OVERALL POWER HAS GONE DOWN THE PAST FEW WEEKS. TRYING TO PASS SOMEONE - HAH, MAKE SURE YOU HAVE PLENTY OF ROOM, BECAUSE THAT TURBO LAG WILL BITE YOU IN THE BUTT WHEN YOU PULL OUT AND SUDDENLY YOU ARE STUCK IN THE ONCOMING LANE WAITING FOR THE ENGINE TO KICK IN. AFTER AN INSPECTION BY THE DEALER - THEY SAID " NOTHING IS WRONG, IT IS PERFORMING EXACTLY AS DESIGNED AND WITH SPECS". REALLY SCARY WHEN THE DEALER SERVICE WRITER TELLS YOU - "IT IS PERFORMING AS DESIGNED". I TAKE THAT TO MEAN THEY ARE FULLY AWARE OF THIS SAFETY DESIGN FLAW/DEFECT. THE DEALER THEN SAID - JUST DRIVE IT IN THE "SPORT" MODE AND IT WILL NOT BE AS BAD. THAT IS LUDICROUS. THE DEFAULT MODE IS "COMFORT" AND THAT IS WHERE THE BEST RIDE AND PERFORMANCE, MILEAGE, ETC. IS TO BE ACHIEVED. I TOOK A TEST DRIVE WITH THE DEALER'S MECHANIC. HE ADVISED THAT HE GETS THIS COMPLAINT EVERY SINGLE DAY. IT IS A SAFETY DESIGN DEFECT INHERENT IN THE ENGINE. HE CHECKED FOR ANY ERROR CODES OR SOFTWARE UPDATES - NONE ARE PRESENT OR AVAILABLE. THE MECHANIC VERBALLY CONFIRMED THAT THE "ENGINE LAG" IS CLEARLY THERE. HOWEVER, WHEN THE SERVICE WRITER COMPLETED THE TICKET, HE WROTE THAT THE MECHANIC SAID HE COULD NOT DUPLICATE THE PROBLEM. THAT IS AN ABSOLUTE UN-TRUTH. IN MY OPINION - THIS IS A VERY CLEAR SAFETY ISSUE WHEN TRYING TO MERGE INTO TRAFFIC OR PASS ANOTHER VEHICLE.

1/3/2020

I PULLED INTO THE DRIVEWAY AND PUT ON THE BRAKES WHEN THE VEHICLE ACCELERATED AND RAN INTO THE GARAGE AND THE FRAME. THERE ARE TIRE MARKS ON THE CEMENT SHOWING THE BRAKES WERE APPLIED. I'VE HAD PROBLEMS WITH THE ACCELERATE CUTTING OUT WHILE ON THE FREEWAY ON RAMP.

9/10/2020

SUNROOF EXPLODED WHILE TRAVELING ON THE HIGHWAY. *TR

6/19/2020

The contact owns a 2020 Hyundai Santa Fe. The contact stated while driving 70 MPH, the contact heard a loud explosion. The contact felt the wind coming from the sunroof. The contact pulled over to the side of the road and saw that the glass sunroof had exploded and shattered. The contact stated that no object had struck the sunroof to cause it to explode. The contact was able to continue driving to her destination. The contact took the vehicle to a local dealer to have the vehicle inspected however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 15,000.

9/8/2021

TO MANY PROBLEMS TO LIST.

2/4/2021

On Thursday, May 11, 11:45 am, I experienced a distressing incident at Moulton Elementary School in Laguna Niguel, CA, 92677. my car was parked near the school building, with the engine turned off and the gear set to park. I was there to pick up my children, and at that time, nobody was inside the vehicle. Unexpectedly, my car started moving backward as if in neutral gear, despite being in park mode. I estimate I was approximately 10 feet from the vehicle in front of the school building. The situation was alarming because numerous children were nearby, which could have resulted in a tragedy. Thankfully, no one was injured or hit by the moving vehicle. Instinctively, I attempted to stop the car by using my entire body to push against it. Unfortunately, my efforts were unsuccessful, and as a result, I sustained severe back pain. I have been on bed rest for the past five days due to the discomfort caused by the incident. Subsequently, the vehicle collided with another car, which belonged to a teacher. The incident shocked everyone, and the reason behind the car's unexpected movement remains unclear. Later, I discovered through online research that my car was actually on the recall list, but I had not been informed of this beforehand. As a result of the incident, we contacted the police, and they arrived at the scene can confirm that the car was indeed in park gear during the incident. It is vital to investigate this matter thoroughly to determine the cause of the vehicle's accidental movement and prevent future accidents. I hope that this statement provides a clear account of the accident that occurred at Moulton Elementary School. I strongly urge authorities and the involved parties to take immediate action to address the issues surrounding my car's movement and prevent any similar incidents from happening again.

5/18/2023

THE 2020 HYUNDAI SANTA FE FOWARD COLLISION AVOIDANCE ASSISTANCE SYSTEM IS NOT FUNCTIONING CORRECTLY. WE HAVE CONTACTED HYUNDAI ON MULTIPLE OCCASIONS WITHOUT RESPONSE. THE SYSTEM IS BRAKING IN THE MIDDLE OF THE ROAD WITHOUT AND CAUSE. NO CARS ARE IN ANY PROXIMITY AND THE CAR BRAKES IN THE MIDDLE OF THE ROAD. THIS HAS OCCURRED TWICE WITHOUT WARNING IN THE LAST SEVERAL MONTHS. DEALERSHIP HAS NO ANSWER WHEN WE TOOK THE CAR IN. HYUNDAI CONSUMER LINE DOES NOT RETURN CALLS. IT IS AN EXTREME DANGER WITH OUR SON DRIVING CAR. REAR END COLLISON WILL HAPPPEN IF THIS CONTINUES.

3/8/2021

The adaptive cruise control, automatic emergency braking, and forward collision avoidance systems in my SUV have been defective since purchase in June 2019. Hyundai has replaced the radar sensor but the dealer is waiting on a part to calibrate it which has been on indefinite backorder. I have waited over a year to have this issue fixed. I am paying a car payment which includes these features as the total cost and would like reimbursement for the cost difference, for the issue to get escalated and fixed, or the dealer to offer a vehicle buyback so that I may purchase a vehicle with no defects.

9/19/2022

MY CAR IS SITING IN PARK, RUNNING WITH THE DRIVER'S DOOR OPEN IN MY TOWN HOUSE PARKING LOT. I GET OUT OF MY CAR TO OPEN THE PASSENGER'S BACK DOOR AS WELL AS MY TRUNK FOR HER. I THEN GET BACK INTO THE DRIVER'S SEAT. I AM WAITING ON MY FRIEND TO LOAD HER ITEMS INTO MY NEW SANTA FE FOR AN OUT OF TOWN RETREAT. SHE FINISHES LOADING ITEMS AND PROCEEDS TO GET INTO THE PASSENGER SIDE FRONT SEAT. AS SHE IS GETTING INTO THE CAR, "SHE SAYS SHE NEEDS TO GO TO THE BATHROOM". I TELL HER LET'S GO NOW BEFORE WE GET STARTED ON OUR TRIP. WE WERE SUPPOSE TO BE MEETING ABOUT 10 COLLEGE STUDENTS. SO I GET OUT OF MY CAR SINCE I HAVE THE HOUSE KEYS. MY CAR IS STILL IN PARK AND RUNNING. I DO LEAVE MY DRIVER'S DOOR OPEN ABOUT A 20-25 DEGREE ANGLE. MY FRIEND WALKS AROUND THE BACK OF THE CAR. AS WE ARE WALKING TOWARD MY TOWNHOUSE, I TURN AROUND BECAUSE I HEAR A NOISE. I IMMEDIATELY SEE MY CAR NOT ROLLING BUT BACKING UP ON A SMALL INCLINE UPWARD ACROSS MY PARKING LOT. IT SEEMS TO HAVE PICKED UP SPEED AND THEN HITS THE BACK OF A PARKED CAR IN THE PARKING LOT. MY CAR HITS THE PARKED GRAY CAMRY WITH SO MUCH MOMENTUM THAT IT BUTTERFLIES MY DRIVER'S DOOR COMPLETELY OPEN AND THE CAR NEVER SLOWS DOWN. THE CAR CONTINUES MOVING WHILE THE INSIDE OF MY DRIVER'S DOOR SCRUBS THE PARKED CAMRY. AFTER MY CAR MOVES PAST THE CAMRY IT IS STILL MOVING AT AN ACCELERATED RATE. I AM YELLING AND RUNNING TO MY CAR WITH MY KEYFOB TRYING TO PUSH BUTTONS TO GET IT TO STOP. MY FRIEND IS RUNNING AND CHASING MY CAR. SHE IS ABLE TO GET TO MY CAR AND JUMP IN WHERE SHE PUSHES ON THE BRAKES VERY HARD TO MAKE THE CAR STOP. IF SHE HAD NOT BEEN ABLE TO DO THAT MY CAR WOULD HAVE HIT A PARKED BLACK TRUCK OR WOULD HAVE JUMPED THE SIDEWALK AND RAN INTO A TOWNHOUSE BEFORE IT STOPPED. ONCE MY FRIEND GOT THE CAR TO STOP. SHE LOOKED DOWN AND IT WAS STILL IN PARK AND WAS NOT MAKING THE DINGING NOISE IT USUALLY DOES WHEN IT IS IN REVERSE.

2/4/2020

While driving on the highway, the front pane of the panoramic sunroof spontaneously shattered. No contact from a foreign object was observed or heard prior to the breakage. The roof was closed, thus our family avoided any glass showering down into our cabin, but this would have been catastrophic had it happened with the roof open. This problem has happened to prior year models of the Santa Fe. Hyundai dealership has agreed to repair the broken sunroof at no cost, however, does not admit fault with the manufacture of the glass.

9/10/2021

STEERING WHEEL MAKES NOISE DURING BACK UP, FROM STOP TO MOTION (LOW SPEED) MAKING TURNS. SOMETIMES HAPPENED DURING LOW SPEED DRIVING AS WELL. THE FREQUENCY IS GETTING MORE AND MORE, VERY ANNOYING AND LITTLE BIT SCARY. WORRY STEERING WHEEL WILL BREAKDOWN. *TR

5/27/2020

TO MANY PROBLEMS TO LIST.

2/4/2021

I WAS IN A MAJOR CAR ACCIDENT AND THE CAR THAT HIT ME WAS TRAVELING ABOUT 60 MPH HIT ME IN THE REAR AND THE AIR BAG NEVER DEPLOYED, THIS IS VERY CONCERNING AND SHOULD BE LOOKED AT. I WAS STOPPED AT A RED LIGHT WHEN I GOT HIT.

5/5/2021

PASSENGER AIR BAG WARNING LIGHT COMES ON WHILE DRIVING WITH A PASSENGER SITTING IN THE FRONT PASSENGER SEAT.

1/7/2025

On May 17th, I had an oil change completed on my 2020 Hyundai Santa Fe at a Hyundai dealership. On May 18th, I was parking my Santa Fe in a parking lot with which I am very familiar. I parked in front of the building, but realized that I had not pulled up far enough to the curb. I went to pull up a couple feet and as I started to put my foot on the gas pedal, I heard the engine roar and take off. I hit the brake, but it didn't stop, and I drove through the window and into the building. I was stunned. I have been driving for 44 years, and I have never had an accident that has been my fault. I was in shock that the car would not stop. I thought there might be a recall regarding this issue, but there wasn't. A friend told me he though he read somewhere that Kia and Hyundai were having acceleration issues. I went online and I was shocked that there are so many reports of sudden unintended acceleration and my Santa Fe was one of those vehicles. I saw one website where over 60 people with Santa Fe's have had similar issues. I was very lucky that I did not injure or kill anyone. Hyundai needs to investigate these instances, before more people are injured or killed. I feel these vehicles need to be recalled immediately. I have contacted Hyundai USA and opened a case file. After the extensive repairs to my vehicle were complete, I took my car to the dealership and instructed them to replace the throttle body assembly. To NHTSA: Please grant Defect Petition DP21-003 and investigate these issues.

6/29/2022

I was driving on an interstate highway at approximately 75 mph. I had cruise control activated. Suddenly the car dramatically slowed down, accompanied by rapid beeping noise. Luckily, there was no one close behind me.

6/24/2023

The adaptive cruise control, automatic emergency braking, and forward collision avoidance systems in my SUV have been defective since purchase in June 2019. Hyundai has replaced the radar sensor but the dealer is waiting on a part to calibrate it which has been on indefinite backorder. I have waited over a year to have this issue fixed. I am paying a car payment which includes these features as the total cost and would like reimbursement for the cost difference, for the issue to get escalated and fixed, or the dealer to offer a vehicle buyback so that I may purchase a vehicle with no defects.

9/19/2022

I was driving on an interstate highway at approximately 75 mph. I had cruise control activated. Suddenly the car dramatically slowed down, accompanied by rapid beeping noise. Luckily, there was no one close behind me.

6/24/2023

The adaptive cruise control, automatic emergency braking, and forward collision avoidance systems in my SUV have been defective since purchase in June 2019. Hyundai has replaced the radar sensor but the dealer is waiting on a part to calibrate it which has been on indefinite backorder. I have waited over a year to have this issue fixed. I am paying a car payment which includes these features as the total cost and would like reimbursement for the cost difference, for the issue to get escalated and fixed, or the dealer to offer a vehicle buyback so that I may purchase a vehicle with no defects.

9/19/2022

I was pulling out of a sidestreet and realized a car was coming and used the brake. The Automatic Braking system activated and VIOLENTLY stopped the car. I was only going about 5 miles an hour but the tremendous force from the Braking system caused my rotator cuff and my bicep to tear. It cost me thousands to pay for surgery and physical therapy. I am very worried about all the injuries that this system causes. I have since had the dealership turn it off. I can not risk being injured like that because the car thinks that there will be a collision when I know that my manual braking was sufficient. There was no chance of any accident. I had Hyundai (case # 20962390) inspect the car & they claim (after 4 different inspections) that there is no issue with the system. They also claimed that it wouldn't activate at 5mph but I know that is not true. So if it works correctly, how many people are injured? Before you mandate that the car stop at 65mph, you need to gather more info on how many injuries have occurred.

7/19/2023

HYUNDAI 2020 SANTA FE LIMITED BLIND SPOT COLLISION-AVOIDANCE ASSIST (BCA) SYSTEM WHEN SET IN ACTIVE MODE AND UNDER THESE CONDITIONS ITS ACTIVATION IS EXTREMELY DANGEROUS: IN THREE (3) OR MORE LANES OF TRAFFIC. IN NEITHER OF THE OUTER LANES. PASSING A TRUCK IN THE LANE ON THE IMMEDIATE RIGHT. VEHICLE(S) IN THE LANE ON THE IMMEDIATE LEFT. VEHICLE(S) IN THE LANE ON THE IMMEDIATE RIGHT. AT SPEEDS OF 50 ' 70+ MPH. WHEN THE SANTA FE APPROACHES THE FRONT END OF THE TRUCK, THE BOW WAVE OF AIR FROM THE TRUCK PUSHES THE SANTA FE TOWARDS THE LEFT LANE LINE ACTIVATING THE BCA, WHICH VIOLENTLY JERKS THE SANTA FE TO THE RIGHT. WHEN THIS OCCURS AND THE SANTA FE IS MOVED VIOLENTLY TOWARD THE RIGHT LINE LANE, THE BSA DETECTS THE TRUCK (OR OTHER VEHICLES) IN THE RIGHT HAND LANE, AND VIOLENTLY JERKS THE SANTA FE TOWARD THE LEFT HAND LANE. UPON DOING SO THE SANTA FE BSA AGAIN DETECTS VEHICLES IN THE LEFT HAND LANE AND AGAIN IMMEDIATELY JERKS THE SANTA FE TOWARD THE RIGHT HAND LANE. THIS ACTION CONTINUALLY OCCURS UNTIL THE DRIVER FORCIBLY REGAINS CONTROL OF THE STEERING WHEEL, AND/OR DEPRESSES THE BRAKE. THIS REPEATED VIOLENT JERKING THE SANTA FE BACK AND FORTH ACROSS THE LANE IT'S IN HAS VERY NEARLY CAUSED AN ACCIDENT IN AT LEAST TWO (2) OCCASIONS (OCT 27 & 28, 2020) UNTIL WE FOUND THAT THE BCA COULD BE DEACTIVATED AND SET TO WARNING ONLY. THIS VIOLENT ACTION OF THE BCA SHOULD BE REMOVED FROM THE SANTA FE VEHICLE TO PREVENT ACCIDENTS.

11/12/2020

Blind Spot System randomly fails to detect vehicle on right side, I have videos of failure. Dealer unable to find problem cause, contacted Hyundai customer service, waiting for response.

1/26/2022

FRONT WINDSHIELD HAS DEVELOPED NUMEROUS PIN-HEAD SIZE STAR SHAPED CRACKS THAT MOSTLY CAN BE SEEN WHEN CAR IS POINTED TOWARD THE SUN. THIS HAPPENED ALL OF A SUDDEN. I TRIED TO PHOTO BUT I CAN NOT GET A GOOD PICTURE. THIS DID NOT HAPPEN WHILE DRIVING.

1/14/2021

The Windshield cracked without anything striking it. The windshield is being replaced at my expense. There is wind noise coming from the area below the crack where it is attached to the vehicle.

7/13/2022

WAS DRIVING DOWN THE ROAD ABOUT 40 MPH, SLOWED DOWN TO ABOUT 10 TO 15 MPH TO MAKE A RIGHT HAND TURN WHEN THE RIGHT REAR TIRE ON MY 2020 HYUNDAI SANTA FE VIN: [XXX], EXPLODED RIPPING SEVERAL INCHES INTO THE SIDEWALL. HAD NO KNOWLEDGE OF HITTING ANYTHING ANY TIME PRIOR TO THE TIRE EXPLODING AND NOTHING IN THE ROADWAY TO CAUSE SAID DAMAGE AT THE SIGHT OF THE EXPLOSION. TEMPERATURE AT THE TIME OF THE EXPLOSION WAS ABOUT 55 DEGREES, NOT TO COLD OR TO HOT. HAD ONLY DRIVEN ABOUT 3 OR 4 MILES ON THE TIRE PRIOR TO EXPLOSION, SO HEAT WAS MOST LIKELY NOT PART OF THE PROBLEM. TIRES WERE MADE BY HANKOOK TIRES, DYNAPRO HP2, SIZE 235/65/R17 104H, DOT 15M8R RT HO 2719, WITH ABOUT 29,000 MILES ON THE TIRES, VERY LITTLE WEAR AT ALL THE TIRE, WITH AIR PRESSURE MAINTAINED AT ALL TIMES TO ABOUT 35 TO 36 PSI WHICH WAS CHECKED ALMOST DAILY. OF ALL OF MY YEARS OF DRIVING HAVE HAD FLAT TIRES, BUT NEVER HAVE I HAD A TIRE JUST EXPLODE AS IN THIS INSTANCE WITH THIS TIRE. FEEL LIKE THIS SHOULD HAVE BEEN REPORTED IN CASE OTHERS MAY HAVE EXPERIENCED ANY SIMILAR ISSUES WITH THESE TIRES. HANKOOK, DYNAPRO HP2, 235/65R17 104H, DOT 15M8R RT HO 2719. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

3/13/2021

The driver rear tire may be leaking air and the pressure monitoring system shows the pressure is 27-28. The car was brought brand new from Hyundai of Torrance, CA on 20 Jan 2020 and as of this date, 23 May 2021, the mileage is 2,007 miles. I have taken the car into the dealership twice about the tire (second time was on 20 May 2021) and they keep saying they don't fix tires and it may have a slow leak. I find this unacceptable and I feel like I'm being taken advantage of (I'm a senior citizen). I plan on driving to another state and I want to ensure the safety of myself and passengers. Just now, I checked the pressure monitoring system and the light is not on. At this point, I don't know if it's tire issue or the electronic system issue. Unfortunately, I don't have any documentation, but perhaps the Hyundai dealership have something on their service database/computer.

5/23/2021

The tires has a big noise like, it sounds like bum bum bum bum bum, and I bought this car brand new, I went To the dealer and they said there is not warranty for tires, that’s not good, because the noise still there.

2/11/2022

The Driver's-side rear wheel came completely off the vehicle while traveling at 65 mph on Interstate 75. The vehicle violently swerved into the left lane, and then my wife was able to pull off to the right side of the road. She almost tipped over from the side of the road being on a steep incline. A couple of days before this, the vehicle was at the Hyundai dealership getting a 'Service' where they changed the oil and performed a 'safety' inspection. They did NOT perform the inspection, but lied on the form saying all systems passed. They reluctantly admitted that they didn't do the inspections. There were NO warning lights of any kind before or after the incident, which could have killed my wife.

6/23/2022

The contact owns a 2020 Hyundai Santa Fe. The contact received notification of NHTSA Campaign Number: 21V00M000 (Visibility) however, the part to do the recall repair was not yet available. The dealer had been notified of the issue and confirmed that parts were not yet available. The manufacturer had been notified of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the repair. The contact had not experienced a failure. Parts distribution disconnect.

7/14/2022

The contact owns a 2020 Hyundai Santa Fe. The contact received notification of NHTSA Campaign Number: 21V00M000 (Visibility) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

3/9/2023

Vehicle not moving transmisión fail after u turn off the engine it will work again Oil leak by bolt in the oil pan

3/3/2023

Driving down the road I heard a loud noise when I stopped I noticed oil under my car. When I was 0.1 mile from my house the oil light came on. I arrived home called Hyundai and they towed the vehicle and reported that the oil plug had was missing and I need to contact the place that changed my oil last.

3/27/2023

Front passenger seat belt will no longer click and lock into place. When held in place by hand, the warning lamp turns off and the audible warning alert turns off. It has not yet been checked by any service department.

1/15/2025

Nothing just have a question for me and my friends that all own newer Hyundai SUV’s that seem to be having similar seatbelt issues

7/17/2025

HYUNDAI 2020 SANTA FE LIMITED BLIND SPOT COLLISION-AVOIDANCE ASSIST (BCA) SYSTEM WHEN SET IN ACTIVE MODE AND UNDER THESE CONDITIONS ITS ACTIVATION IS EXTREMELY DANGEROUS: IN THREE (3) OR MORE LANES OF TRAFFIC. IN NEITHER OF THE OUTER LANES. PASSING A TRUCK IN THE LANE ON THE IMMEDIATE RIGHT. VEHICLE(S) IN THE LANE ON THE IMMEDIATE LEFT. VEHICLE(S) IN THE LANE ON THE IMMEDIATE RIGHT. AT SPEEDS OF 50 ' 70+ MPH. WHEN THE SANTA FE APPROACHES THE FRONT END OF THE TRUCK, THE BOW WAVE OF AIR FROM THE TRUCK PUSHES THE SANTA FE TOWARDS THE LEFT LANE LINE ACTIVATING THE BCA, WHICH VIOLENTLY JERKS THE SANTA FE TO THE RIGHT. WHEN THIS OCCURS AND THE SANTA FE IS MOVED VIOLENTLY TOWARD THE RIGHT LINE LANE, THE BSA DETECTS THE TRUCK (OR OTHER VEHICLES) IN THE RIGHT HAND LANE, AND VIOLENTLY JERKS THE SANTA FE TOWARD THE LEFT HAND LANE. UPON DOING SO THE SANTA FE BSA AGAIN DETECTS VEHICLES IN THE LEFT HAND LANE AND AGAIN IMMEDIATELY JERKS THE SANTA FE TOWARD THE RIGHT HAND LANE. THIS ACTION CONTINUALLY OCCURS UNTIL THE DRIVER FORCIBLY REGAINS CONTROL OF THE STEERING WHEEL, AND/OR DEPRESSES THE BRAKE. THIS REPEATED VIOLENT JERKING THE SANTA FE BACK AND FORTH ACROSS THE LANE IT'S IN HAS VERY NEARLY CAUSED AN ACCIDENT IN AT LEAST TWO (2) OCCASIONS (OCT 27 & 28, 2020) UNTIL WE FOUND THAT THE BCA COULD BE DEACTIVATED AND SET TO WARNING ONLY. THIS VIOLENT ACTION OF THE BCA SHOULD BE REMOVED FROM THE SANTA FE VEHICLE TO PREVENT ACCIDENTS.

11/12/2020

Catalytic converter is failing Lane collision warning failing driver side rear view mirror

10/12/2023

HYUNDAI 2020 SANTA FE LIMITED BLIND SPOT COLLISION-AVOIDANCE ASSIST (BCA) SYSTEM WHEN SET IN ACTIVE MODE AND UNDER THESE CONDITIONS ITS ACTIVATION IS EXTREMELY DANGEROUS: IN THREE (3) OR MORE LANES OF TRAFFIC. IN NEITHER OF THE OUTER LANES. PASSING A TRUCK IN THE LANE ON THE IMMEDIATE RIGHT. VEHICLE(S) IN THE LANE ON THE IMMEDIATE LEFT. VEHICLE(S) IN THE LANE ON THE IMMEDIATE RIGHT. AT SPEEDS OF 50 ' 70+ MPH. WHEN THE SANTA FE APPROACHES THE FRONT END OF THE TRUCK, THE BOW WAVE OF AIR FROM THE TRUCK PUSHES THE SANTA FE TOWARDS THE LEFT LANE LINE ACTIVATING THE BCA, WHICH VIOLENTLY JERKS THE SANTA FE TO THE RIGHT. WHEN THIS OCCURS AND THE SANTA FE IS MOVED VIOLENTLY TOWARD THE RIGHT LINE LANE, THE BSA DETECTS THE TRUCK (OR OTHER VEHICLES) IN THE RIGHT HAND LANE, AND VIOLENTLY JERKS THE SANTA FE TOWARD THE LEFT HAND LANE. UPON DOING SO THE SANTA FE BSA AGAIN DETECTS VEHICLES IN THE LEFT HAND LANE AND AGAIN IMMEDIATELY JERKS THE SANTA FE TOWARD THE RIGHT HAND LANE. THIS ACTION CONTINUALLY OCCURS UNTIL THE DRIVER FORCIBLY REGAINS CONTROL OF THE STEERING WHEEL, AND/OR DEPRESSES THE BRAKE. THIS REPEATED VIOLENT JERKING THE SANTA FE BACK AND FORTH ACROSS THE LANE IT'S IN HAS VERY NEARLY CAUSED AN ACCIDENT IN AT LEAST TWO (2) OCCASIONS (OCT 27 & 28, 2020) UNTIL WE FOUND THAT THE BCA COULD BE DEACTIVATED AND SET TO WARNING ONLY. THIS VIOLENT ACTION OF THE BCA SHOULD BE REMOVED FROM THE SANTA FE VEHICLE TO PREVENT ACCIDENTS.

11/12/2020

Back up camera glitches. Causes driver assist to take control at times when not necessary. Have has this in for service at least 4 times since purchasing vehicle in 2020. Service states repaired each time bit eventually happens again. This last time is getting more severe cause multiple electrical short in Overhead lights, Panoramic roof failure to close at times and rear hatch sometimes only partially opens. I saw recent recall for 2021 and 2022 Santa fe's, I believe this problem is what is happening with my 2020 Santa fe and the scope of the recall should be expanded.

12/3/2024

TL* THE CONTACT OWNS A 2020 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE THE VEHICLE WAS BEING TRANSPORTED, THE CONTACT LEARNED THAT THE GAS CAP HAD DETACHED FROM THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO O'BRIEN HYUNDAI OF FORT MYERS (2850 COLONIAL BLVD, FORT MYERS, FL 33966; (239) 277-1222) WHERE THE GAS CAP WAS REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND OPENED A CASE. THE APPROXIMATE FAILURE MILEAGE WAS 4,862.

12/9/2020

The contact owns a 2020 Hyundai Santa Fe. The contact stated that while driving at an undisclosed speed and attempting to accelerate, the vehicle suddenly lost motive power. The check engine warning light was illuminated. The vehicle was taken to the dealer, who determined that one bolt on the fuel pump was sheared off and another was extremely loose. The vehicle was repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 63,000.

2/26/2024

The driver rear tire may be leaking air and the pressure monitoring system shows the pressure is 27-28. The car was brought brand new from Hyundai of Torrance, CA on 20 Jan 2020 and as of this date, 23 May 2021, the mileage is 2,007 miles. I have taken the car into the dealership twice about the tire (second time was on 20 May 2021) and they keep saying they don't fix tires and it may have a slow leak. I find this unacceptable and I feel like I'm being taken advantage of (I'm a senior citizen). I plan on driving to another state and I want to ensure the safety of myself and passengers. Just now, I checked the pressure monitoring system and the light is not on. At this point, I don't know if it's tire issue or the electronic system issue. Unfortunately, I don't have any documentation, but perhaps the Hyundai dealership have something on their service database/computer.

5/23/2021

235/60R18 Tire leak & brittle texture

8/2/2023

The contact owns a 2020 Hyundai Santa Fe. The contact received notification of NHTSA Campaign Number:23V181000 (Trailer Hitches) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

6/6/2023

The contact owned a 2020 Hyundai Santa Fe. The contact stated that while driving 40 MPH onto the ramp, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The contact was able to pull over to the side of the road. The vehicle stalled and shut off, and the contact was unable to restart the vehicle. The contact was calling for Roadside Assistance and noticed white smoke coming from under the hood. The stated that the smoke then turned dark brown and then black, and then flames appeared under the hood. The contact grabbed several things of value and exited the vehicle and started running. The vehicle was engulfed in flames, and the EDR was destroyed. The contact sustained minor scratches after falling while running away from the vehicle. No medical attention was sought. The Police and Fire Department were called to the scene. The contact stated that a Police report was not filed due to the incident not being related to a crash. The vehicle was towed to a tow yard. The local dealer where the vehicle was purchased was contacted; however, no assistance was provided. The manufacturer was not notified of the failure. The contact stated that the vehicle had been purchased two months prior to catching on fire. The vehicle was inspected by the Insurance provider and declared a total loss. Upon further investigation, the contact related the failure to NHTSA Campaign Number: 23V181000 (TRAILER HITCHES); however, the VIN was not included. The failure mileage was approximately 94,400.

11/25/2025

Intermittently when you turn the left turn signal, it will be a delay of 2-3 seconds to actually turn on the lights. Usually it happens in the morning when cold.

10/3/2023

There is a problem with the car's headlights. They are having to be replaced every couple months. I have taken it to the dealership and they told me it would be several hundreds of dollars to diagnose, but cannot tell me anything upon inspection other than needs replacement. We are having to purchase new bulbs every 2-3 months. One side goes out, then the other. We are being careful when replacing them, not to handle them with our fingers and using the bulb lubricant as advised per the parts store. I have receipts for multiple headlamp purchases.

8/29/2025

The contact owns a 2020 Hyundai Santa Fe. The contact stated while driving at higher speeds, the vehicle experienced a momentary loss of motive power. The check engine warning light was illuminated. An unknown local dealer was contacted, but the vehicle was not diagnosed or repaired due to the cost. The contact stated that prior to the failure, the vehicle was taken to Auto Zone where a diagnostic scanner was used to diagnose the vehicle. The contact was informed that the MAP sensor had failed and needed to be replaced. The vehicle was taken to Advance Auto Parts where, the DTC code: P2565; was retrieved. The contact stated that the spark plugs, and the MAP sensor were previously replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 100,363.

11/27/2024

The contact owns a 2020 Hyundai Santa Fe. The contact stated that while driving at 45 MPH, the check engine warning light illuminated. After scanning the vehicle, the contact received a code for torque converter damage. The vehicle was taken to the local dealer, where it was diagnosed, and the TCM update was needed. The vehicle was repaired, but the failure recurred. The vehicle was taken back to the local dealer, where it was diagnosed with transmission failure. The vehicle was repaired, but the failure persisted. The oil light was illuminated and then turned off. The contact became aware that the engine oil was 4 1/2 quarts low, and it was determined there was an oil consumption issue with the engine. The vehicle was taken back to the local dealer, where it was determined that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was contacted, and a complaint was filed. The failure mileage was approximately 98,000.

10/1/2025

Failed tire in question: Tire failed immediately when apparent road hazard occurred on a major freeway. Exited freeway and located a area where I was able to pull over. After changing said tire (Kumho 235.60/R18) I attempted to inspect tire and found the steel belt failed (punctured). Upon further investigation I observed that the steel belt has covered with less than as less than a 1/6th inch of rubber thereby exposing the belt for a potential failure. At this point the mileage said tire was 7700. As of yet the tire warranty has not been confirmed. This tire was delivered on a new 2020Hyundai Santa Fe limited.

9/10/2021

We are experiencing exactly what is listed in HYUNDAI TSB #21-BE-005H: intermittent abnormal camera image display conditions on the instrument cluster when the turn left signal is turned on or the radio screen when transmission is in reverse.

3/23/2022

The contact owns a 2020 Hyundai Santa Fe. The contact stated that while her husband was driving at an undisclosed speed, the vehicle was not able to stop immediately while the brake pedal was depressed, causing his vehicle to rear-end another vehicle. The failure recurred on a separate occasion while the contact's husband was driving, and the brakes failed to stop the vehicle from crashing into their daughter's residence. The air bags did not deploy in either collision. No injuries were sustained and no medical attention was received for either collision. No police report was filed for either collision. The contact's husband was able to drive the vehicle away from both the scenes of the collisions. The vehicle's front end was damaged; however, the vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 28,000.

5/5/2022

Driver’s door is not opening brought it to freeman Hyundai here in Irving and after a month I am still experiencing the same problem.

9/4/2022

Pantalla de instrumentos se apaga instrument display turns off

3/26/2023

La guagua a tenido problemas con el tren delantero. Comenzó con un sonido en el Guía. La Hyundai le reparo esa pieza y luego continuó con el mismo ruido. Ahora tienen que cambiarle el Rack and Piñogn. Mi guagua tiene solo 19,750 millas creo que vino mala de fábrica.

12/11/2023

The contact owns a 2020 Hyundai Santa Fe. The contact stated that occasionally while driving at various speeds in hot climate, the air conditioning failed to blow cold air. No warning light was illuminated. The vehicle was taken to a local dealer however, the failure could not be replicated. The vehicle was taken to a local independent mechanic for a second opinion, where it was diagnosed with an evaporator temperature sensor failure. The contact was informed that the evaporator temperature sensor needed to be replaced. The vehicle was not repaired. Upon further investigation, the contact related the failure to Technical Service Bulletin: 21-HA-001H; however, the VIN was not included. The manufacturer was made aware of the failure. The failure mileage was approximately 29,000.

6/17/2025

The contact owns a 2020 Hyundai Santa Fe. The contact stated that while driving approximately 40 MPH, the vehicle started shaking and lost power. The check engine warning light was illuminated. The vehicle was restarted immediately. The vehicle was taken to a dealer, where it was diagnosed and determined that the engine had an air leak with the fuel. The contact added that the leak was stopped after an undisclosed repair, but the failure reoccurred a day later. The vehicle was taken to the same dealer however, the failure could not be duplicated. The vehicle was then taken to the same dealer and was diagnosed and determined that the throttle body needed to be replaced. The vehicle was repaired, but the failure reoccurred two days later. The manufacturer was notified of the failure. The failure mileage was approximately 72,700.

11/13/2025