2023 Ford Escape Owner Complaints

As I was driving home with about 5 minutes to go, in my brand new (2 week old)2023 Ford Escape, I smelled something burning. I pulled over and saw smoke so I turned off the car and got out. As I got out of the car I looked under and saw fire. I got away from the car and as I did, the fire kept growing and growing from under the hood. The fire went high enough to hit the trees on the side of the roasd. The police and fire department came and were able to put out the fire but not before the car was distroyed. There were no warning lights or any other symtoms of a problem prior to smelling burning. The Ford company has not responded to me from the day my wife spoke to a representative on Monday, October 2nd. The car fire was on Saturday, September 30th. It's been 3 days. My insurance company was going to do an inspection. Ford wants nothing to do with us. We have a police report and a fire report. This clearly was a engine or electrical problem with this car. I was lucy this happened on a small street and not on the highway where pulling over would have been difficult. Lucky I could smell it so I knew to stop. Lucky I didn't have one or both of my toddler grandchildren in the back seat in their car seats! I would never have been able to get them out in time!

10/5/2023

Vehicle has a 1.5L dragon 3 cylinder. When passing vehicles, on 3 occasions it throws codes that says that the engine has an engine overheated issue, service asap, and goes into a limp mode which does not give you any time to get to safety before your speed is dropped below 55 mph. It will not go out of limp mode until you completely shut off the vehicle and wait 5 or so minutes and turn it back on. Even after it stays in a limp mode capacity and does not easily get back up to highway speeds. The certified dealership service department has had my brand new vehicle 7 weeks with no resolution. Car was bought with 16 miles on the odometer, on August 25th, 2023, at 650 ish miles on September 6th it happened the 1st time. The 2nd time was on September 14th, 3rd time September 15th, 4th time was, September 29th. 3 times on a 4 lane highway, 1st time on a 2 lane country highway.

10/24/2023

At approximately 1,000 miles on 2 separate occasions while traveling on the interstate, roughly 10 minutes apart, an audible chime and visual alert within the speedometer cluster appeared “engine coolant over temperature” for approximately 10 seconds. The temperature gauge within the cluster indicated normal, midway within the span of the gauge. The following day prior to starting the vehicle, a cold start essentially, the coolant level was “full”. I ran a “check engine” check with no stored codes in temporary or permanent storage. My 2023 Ford Escape has the 1.5L EcoBoost engine. When the warnings appeared, there was no reduction in engine power(limp mode) and no signs of steam while looking in the rear view mirror.

8/18/2023

engine light came on took it into dealership. they said it was evap system then fixed it. picked car up in a wednesday by the friday, light came on again. took back into dealership, they didn’t detect any leaks.. said they were going to put in a canister purge solenoid. found out about 23S27.. apparently my vehicle vin doesn’t fall under that recall.. but yet my vehicle has all the signs.

10/4/2023

3 times, either merging on the highway or full throttle, vehicle screams overheat warning with wrench light for a couple of seconds and disappears. No limp mode or smoke at all. And coolant level is at MAX. No clue is this some sort of glitch or engine failure? Vehicles drives amazing and power is great. Maybe it’s a software glitch?

10/29/2023

On 1/29/24, I drove around town to run errands and on my second stop, I tried starting the car and it would not start, but it went into "accessory mode". I received SEVERAL warnings: Pedestrian Sounder, Memory Recall Failure, Front Collision Sensors, Tractions Control, Check Engine Light, etc. It also stated it would sound an alarm if we tried turning it on again. I sat there for 10 mins and tried turning it on after getting in and out of the car, looking underneath to see if oil or gas was leaking, which nothing was leaking. I kept trying to start the vehicle with no success, still getting the warnings. My spouse arrived after 15 mins and when she opened the hood and wiggled some cables around, we were able to start the car up and it was like it went through a factory reset as the memory for the driver seat went really close to the steering wheel. We called roadside assistance thinking we need to get this towed to a dealership but cancelled it after seeing it would start and my spouse driving it around the grocery parking lot carefully. When we got it to the dealership, it wasn't having those issues and they couldn't do much for it. On 2/10/24, the check engine light came on. We took it to the dealership on 2/12/24 and they told us the PCM malfunctioned. They did a software update on the PCM, which the dealership said has fixed the problem for now. Just worried this is going to happen again and will happen when I'm in a place where maybe my spouse can't come or we are traveling long distance. Prior to this incident, the dash (MPH, Gas level, Oil level, Engine Temp) of the vehicle, which is entirely digital, flickers like there is a short in the wiring somewhere. It doesn't happen every time we drive it, just sometimes (maybe 35% of the time). This was happening shortly after purchasing the vehicle in July 2023. I have a feeling that something relating to the electrical components, battery, chip/software/firmware in the Ford Escape needs to be replaced entirely.

2/12/2024

engine light came on took it into dealership. they said it was evap system then fixed it. picked car up in a wednesday by the friday, light came on again. took back into dealership, they didn’t detect any leaks.. said they were going to put in a canister purge solenoid. found out about 23S27.. apparently my vehicle vin doesn’t fall under that recall.. but yet my vehicle has all the signs.

10/4/2023

Vehicle has a 1.5L dragon 3 cylinder. When passing vehicles, on 3 occasions it throws codes that says that the engine has an engine overheated issue, service asap, and goes into a limp mode which does not give you any time to get to safety before your speed is dropped below 55 mph. It will not go out of limp mode until you completely shut off the vehicle and wait 5 or so minutes and turn it back on. Even after it stays in a limp mode capacity and does not easily get back up to highway speeds. The certified dealership service department has had my brand new vehicle 7 weeks with no resolution. Car was bought with 16 miles on the odometer, on August 25th, 2023, at 650 ish miles on September 6th it happened the 1st time. The 2nd time was on September 14th, 3rd time September 15th, 4th time was, September 29th. 3 times on a 4 lane highway, 1st time on a 2 lane country highway.

10/24/2023

The contact owns a 2023 Ford Escape. The contact stated while driving with the cruise control set to 45 MPH, the vehicle unintendedly accelerated to 65 MPH. No warning lights were illuminated. The vehicle was not taken to the dealer and was not diagnosed or repaired. The manufacturer was made aware of the issue and referred the contact to the NHTSA Hotline. The failure mileage was unknown.

3/29/2024

See attached document for complaint

4/12/2024

engine light came on took it into dealership. they said it was evap system then fixed it. picked car up in a wednesday by the friday, light came on again. took back into dealership, they didn’t detect any leaks.. said they were going to put in a canister purge solenoid. found out about 23S27.. apparently my vehicle vin doesn’t fall under that recall.. but yet my vehicle has all the signs.

10/4/2023

As I was driving home with about 5 minutes to go, in my brand new (2 week old)2023 Ford Escape, I smelled something burning. I pulled over and saw smoke so I turned off the car and got out. As I got out of the car I looked under and saw fire. I got away from the car and as I did, the fire kept growing and growing from under the hood. The fire went high enough to hit the trees on the side of the roasd. The police and fire department came and were able to put out the fire but not before the car was distroyed. There were no warning lights or any other symtoms of a problem prior to smelling burning. The Ford company has not responded to me from the day my wife spoke to a representative on Monday, October 2nd. The car fire was on Saturday, September 30th. It's been 3 days. My insurance company was going to do an inspection. Ford wants nothing to do with us. We have a police report and a fire report. This clearly was a engine or electrical problem with this car. I was lucy this happened on a small street and not on the highway where pulling over would have been difficult. Lucky I could smell it so I knew to stop. Lucky I didn't have one or both of my toddler grandchildren in the back seat in their car seats! I would never have been able to get them out in time!

10/5/2023

After reviewing my owner’s manual on my newly purchased vehicle, I was shocked at how quickly and unexpectedly I was propelled from 75mph to 105mph because of a new-to-me feature on this model. I was surprised and moreover shocked that a system like this is mass-produced and sold worldwide. Seems like the manufacturer should provide proper training materials and not just the dealer telling me to Youtube it. I fear for my life every time I get behind the wheel. If someone unassumingly were to drive this vehicle without becoming accustomed to they ways it operates, I fear of what horrible accidents may result. I wish I could give the car back but the dealership won’t do anything for me. So I felt it necessary to make this report. Hopefully the features on this particular model of a major vehicle manufacturing brand are re-examined. Something just doesn’t seem right with this specific sub-model.

12/11/2023

At any random time, all sensors fail. Blind spot systems, parking sensors, pre-collision assist, front camera fault, cross traffic system, cruise control, lane assist, auto headlights. Returned to the dealership multiple times, with no resolution. All sensors continue to fail, with no immediate fix available, according to Ford, until the fourth quarter. So, I am left with an unrepairable vehicle to drive in the already dangerous central Texas traffic. The problem has been confirmed at Leif Johnson Ford, 501 E. Koenig, Austin, Tx 78751. Main #512-454-3711, Service #512-454-3767, and reported to Ford Care at 800-392-3673

8/23/2024

After reviewing my owner’s manual on my newly purchased vehicle, I was shocked at how quickly and unexpectedly I was propelled from 75mph to 105mph because of a new-to-me feature on this model. I was surprised and moreover shocked that a system like this is mass-produced and sold worldwide. Seems like the manufacturer should provide proper training materials and not just the dealer telling me to Youtube it. I fear for my life every time I get behind the wheel. If someone unassumingly were to drive this vehicle without becoming accustomed to they ways it operates, I fear of what horrible accidents may result. I wish I could give the car back but the dealership won’t do anything for me. So I felt it necessary to make this report. Hopefully the features on this particular model of a major vehicle manufacturing brand are re-examined. Something just doesn’t seem right with this specific sub-model.

12/11/2023

Summary of Issues: 1. March 2024 – First Incident: •Warning lights appeared on the dashboard while driving (including ABS and power steering). •Vehicle was taken to Camelback Ford. •Dealership diagnosed a software update failure due to low voltage. •Battery was recharged, software updated, and codes cleared. ⸻ 2. April 6, 2024 – Battery Replacement: •Vehicle continued to experience electrical issues. •Battery was replaced by dealership under warranty. ⸻ 3. June 11, 2024 – Second Incident: •Dashboard warning lights returned. •Dealership again cleared codes, no new repair or replacement performed. •Explanation given was “modern cars have more computers” and that these issues were “normal.” ⸻ 4. July 12, 2024 – Third Incident: •While stopped at a red light, the entire dashboard shut off and restarted on its own. •Engine remained on, but the sudden blackout raised serious safety and reliability concerns. •Vehicle was not moved after the incident. •Dealership advised to return only if issue happens again. ⸻ Ongoing Concern: This vehicle has experienced repeated electrical system failures including instrument cluster blackout and communication errors, despite warranty repairs and a new battery. These intermittent issues pose a potential safety risk, especially if they occur while driving. The lack of a consistent fix raises concerns about the vehicle’s electrical integrity and reliability.

3/23/2025

Unknown

1/30/2024

The contact owns a 2023 Ford Escape. The contact stated while driving with the cruise control set to 45 MPH, the vehicle unintendedly accelerated to 65 MPH. No warning lights were illuminated. The vehicle was not taken to the dealer and was not diagnosed or repaired. The manufacturer was made aware of the issue and referred the contact to the NHTSA Hotline. The failure mileage was unknown.

3/29/2024

The contact owns a 2023 Ford Escape. The contact stated while driving at approximately 50 MPH, he observed a warning chime dinging, the power train warning light illuminated, and the 'low engine coolant' message was displayed. The vehicle was taken to the residence. The contact's wife received a notification via the Ford Pass APP stating that “There was a failure with the vehicle and to see the dealer”. The vehicle was taken to a dealer where it was diagnosed that the engine and head gasket needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 3,900.

5/30/2024

The contact owns a 2023 Ford Escape. The contact stated while driving 70 MPH, the vehicle suddenly decelerated after the engine overheated and shifted into "LIMP Mode". The contact stated that during the failure, the message "Engine Overheated" was displayed. The vehicle was taken to the local dealer who diagnosed that the engine was faulty and needed to be replaced. No further information was available. The vehicle was not yet repaired. The manufacturer was not contacted regarding the failure. The failure mileage was 4,200.

8/26/2024

At any random time, all sensors fail. Blind spot systems, parking sensors, pre-collision assist, front camera fault, cross traffic system, cruise control, lane assist, auto headlights. Returned to the dealership multiple times, with no resolution. All sensors continue to fail, with no immediate fix available, according to Ford, until the fourth quarter. So, I am left with an unrepairable vehicle to drive in the already dangerous central Texas traffic. The problem has been confirmed at Leif Johnson Ford, 501 E. Koenig, Austin, Tx 78751. Main #512-454-3711, Service #512-454-3767, and reported to Ford Care at 800-392-3673

8/23/2024

The contact owns a 2023 Ford Escape. The contact stated while driving 40 MPH, the "Blind Spot Detection System Fault" message was displayed. The contact stated that several unknown warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the trailer tow wiring harness (Part Number: LX6Z-15A416-B). The contact was informed that the wiring harness was damaged by the heat shield. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The approximate failure mileage was 9,000.

3/14/2025

The contact owns a 2023 Ford Escape. The contact stated that while driving at undisclosed speeds, the back-over prevention camera screen went to a blue screen. The contact stated that while driving, the camera turned on and the image was shown. The camera was unavailable, and a message to contact the dealer was displayed. The vehicle was taken to the local dealer, where it was diagnosed and determined that the camera needed to be reset and the software updated. The vehicle was test-driven. The vehicle was repaired, but the failure recurred. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 10,668.

1/24/2025

The contact owns a 2023 Ford Escape. The contact state while reversing, the back over prevention camera failed to function as intended. The contact stated that the back over prevention camera failed to display images of pedestrians or vehicles. The contact stated that due to the failure, the contact almost struck a pedestrian. The vehicle was taken to the dealer; however, the failure was not duplicated. The vehicle was then taken to another dealer where a software update was performed. The manufacturer was made aware of the failure. The contact was offered a buyback. The failure mileage was approximately 55,000.

5/28/2025

After the vehicle sits idle for about two contiguous days and you open the driver's door, there are not lights on inside or outside. Normally when you open the driver's door, the center dash and console light up as well as the ambient lighting in various areas of the interior. There is no mention of the 'battery deep sleep' anywhere in the online user manual for a non electric vehicle (ICE). Entering a dark interior in the middle of the night creates the potential for a slip and fall accident. Not to mention contact with kees and the dash or the door opening and the side of the head when trying to get situated behind the steering wheel.

9/29/2023

After reviewing my owner’s manual on my newly purchased vehicle, I was shocked at how quickly and unexpectedly I was propelled from 75mph to 105mph because of a new-to-me feature on this model. I was surprised and moreover shocked that a system like this is mass-produced and sold worldwide. Seems like the manufacturer should provide proper training materials and not just the dealer telling me to Youtube it. I fear for my life every time I get behind the wheel. If someone unassumingly were to drive this vehicle without becoming accustomed to they ways it operates, I fear of what horrible accidents may result. I wish I could give the car back but the dealership won’t do anything for me. So I felt it necessary to make this report. Hopefully the features on this particular model of a major vehicle manufacturing brand are re-examined. Something just doesn’t seem right with this specific sub-model.

12/11/2023

See attached document for complaint

4/12/2024

The contact rented a 2023 Ford Escape. The contact stated that while driving at about 20 MPH and driving over a railroad track, the hood of the vehicle opened abruptly and struck the windshield. The contact lost visibility and went through an intersection before coming to a complete stop. The contact made the rental company aware and was informed that they could not diagnose the issue. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was unknown.

4/22/2024

The contact rented a 2023 Ford Escape. The contact stated that while driving at about 20 MPH and driving over a railroad track, the hood of the vehicle opened abruptly and struck the windshield. The contact lost visibility and went through an intersection before coming to a complete stop. The contact made the rental company aware and was informed that they could not diagnose the issue. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was unknown.

4/22/2024

I've had this thing less than 6 months, I've already had the engine rebuilt with 34 parts a month and a half in and the drivers side rear door handle replaced during this time because it would not open from the outside and only the inside despite being unlocked. All of this occurred at the beginning of May 2024 and it sat for 3 months due to the engine being basically rebuilt with most parts being on backorder. Today the same door is having the same issue, only this time the same exact door won't open neither from the inside or outside, which is a huge safety hazard in my eyes if I got into an accident and had passengers in the backseat. I do have video proof of this too.

8/11/2024

At any random time, all sensors fail. Blind spot systems, parking sensors, pre-collision assist, front camera fault, cross traffic system, cruise control, lane assist, auto headlights. Returned to the dealership multiple times, with no resolution. All sensors continue to fail, with no immediate fix available, according to Ford, until the fourth quarter. So, I am left with an unrepairable vehicle to drive in the already dangerous central Texas traffic. The problem has been confirmed at Leif Johnson Ford, 501 E. Koenig, Austin, Tx 78751. Main #512-454-3711, Service #512-454-3767, and reported to Ford Care at 800-392-3673

8/23/2024

The contact owns a 2023 Ford Escape. The contact stated while driving at various speeds, there was an abnormal sound coming from the engine and the front driver’s side tire. In addition, the instrument panel was occasionally turned off independently. Additionally, during rainy weather driving the brakes were making abnormal sounds. The contact stated that several unknown warning lights were occasionally illuminated. The vehicle was taken to a local dealer on several occasions and was diagnosed; however, the failure could not be replicated. The vehicle was taken to another local dealer, Mullinax Ford of Kissimmee (1810 E Irlo Bronson Memorial Hwy, Kissimmee, FL 34744); for a second opinion; however, the failure could not be replicated. The vehicle was also taken to a third local dealer, Tropical Ford (9900 S Orange Blossom Trl, Orlando, FL 32837); but the cause of the failure could not be determined. The vehicle was taken to a local independent mechanic where it was diagnosed and determined that an unknown material might have intruded into the engine. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 5,000.

11/19/2024

The contact owns a 2023 Ford Escape. The contact stated that the front driver's door window would not completely roll up and close. The vehicle was taken to the local dealer who replaced the front driver's side door window motor, and the vehicle was repaired but failure reoccurred. Additionally, while operating the vehicle, the message "Front Collision Camera Inoperable" was displayed. The vehicle was taken to the local dealer, but failure code could not be retrieved, and the cause of the failure was not yet determined. The manufacturer was notified of the failures, but no assistance was offered. The failure mileage was 13,000.

1/30/2025

The contact owns a 2023 Ford Escape. The contact stated while the vehicle was parked, the contact attempted to close the front driver’s side door; however, the door failed to close securely. No warning light was illuminated. The vehicle was taken back to the residence. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 30,000.

2/11/2025

The contact owns a 2023 Ford Escape. The contact stated while driving at various speeds with the Adaptive Cruise Control Mode engaged, the vehicle failed to respond as needed after another vehicle pulled in front of the vehicle. The contact stated that the vehicle jerked and decelerated, and then revved up and accelerated unintendedly until the vehicle was within proximity of the other vehicle. Additionally, the contact stated that the Lane Keep Assist failed to keep the vehicle within the intended lane while driving, and the vehicle veered to the left unintendedly while the Lane Keep Assist was engaged. The vehicle was taken to the dealer to be diagnosed, but the cause of the failure could not be determined. Additionally, the dealer informed the contact that the vehicle was previously repaired under NHTSA Campaign Number: 24V440000 (Forward Collision Avoidance), which the contact related to the failure. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 98,000.

6/26/2025

Recall Action Soon Issue Since 03-14-2025 Drivers side seat buckle replacement For More Information Telematics Generated Issue Recall Action Soon Issue Since 11-08-2024 Inspect front door check-arm reinforcement spot welds For More Information

7/19/2025

Recall Action Soon Issue Since 03-14-2025 Drivers side seat buckle replacement For More Information Telematics Generated Issue Recall Action Soon Issue Since 11-08-2024 Inspect front door check-arm reinforcement spot welds For More Information

7/19/2025

Campaign 23B56 Description Inspect front door check-arm reinforcement spot welds Next Steps Contact your dealer for next steps. ---------------------------------------------------------------------------------------------------------------- Recall Action Soon Issue Since 03-14-2025 Drivers side seat buckle replacement For More Information Telematics Generated Issue Recall Action Soon Issue Since 11-08-2024 Inspect front door check-arm reinforcement spot welds For More Information

7/20/2025

Sunroof molding roof drip rail. Ford part #LJ6Z5450036A. This part is held on with double stick tape. When it comes loose, it can interfere with the proper operation of the sunroof sunshade or fall into the passenger compartment. Mine has been replaced several times under warranty. Even though it was nearly detached, it did not fall. However, if it had, it has the potential of either damaging the sunshade or creating a driver distraction while driving.

8/11/2025

my 2023 ford edge caused burns to the back of my legs. i was unaware until my grandma informed me that something was wrong with my legs. i noticed when i got the car 2 months ago level 3 of the seat warmer was way to hot like i felt it burning. so i only used on setting 1 or 2 and did not feel the burning sensation like when used on 3 but somehow my legs are burned

10/11/2025

During braking the car experienced what seemed to be a glitch and lost all breaking power. Foot went to the floor and had to press and release multiple times for break power assist to come back. This happened three times within 100 mile drive.

11/12/2025

The contact owns a 2023 Ford Escape. The contact stated that the 12-Volt battery had become inoperable. The contact stated that the vehicle lost motive power while attempting to start the vehicle. There was no warning light illuminated. The contact had to charge the battery several times to start the vehicle. The vehicle was taken to the dealer, but was not diagnosed or repaired. The contact was informed that the issue was battery-related and was advised to drive the vehicle differently and to obtain a trickle charger for the battery. The manufacturer was not made aware of the failure. The approximate failure mileage was 8,000.

11/19/2025